HCD-GN700GX8800

April 6, 2018 | Author: Anonymous | Category: Documents
Share
Report this link


Description

HCD-GN700/GX8800 SERVICE MANUAL Ver 1.0 2003.04 US Model HCD-GX8800 E Model HCD-GN700 HCD-GN700/GX8800 are the amplifier, CD player, tape deck and tuner section in MHC-GN700/GX8800. Photo: HCD-GN700 Model Name Using Similar Mechanism CD Section CD Mechanism Type Base Unit Name Optical Pick-up Name TAPE Section Model Name Using Similar Mechanism Tape Transport Mechanism Type NEW CDM74-K6BD47S BU-K6BD47S KSM-213DCP HCD-XGR66/XGR600 CWM43RR23 SPECIFICATIONS AUDIO POWER SPECIFICATIONS (MHC-GX8800 USA model only) POWER OUTPUT AND TOTAL HARMONIC DISTORTION: With 6-ohm loads, both channels driven, from 120 Hz – 10 kHz; rates 200 watts per channel minimum RMS power, with no more than 10% total harmonic distortion from 250 miliwatts to rated output. Amplifier section MHC-GX8800 Total harmonic distortion Outputs VIDEO OUT: (phono jacks) PHONES: (stereo mini jack) FRONT SPEAKER: SURROUND SPEAKER: CD player section System Laser Laser Output max. output level 1 Vp-p, unbalanced, Sync. negative load impedance 75 ohms accepts headphones of 8 ohms or more accepts impedance of 6 to 16 ohms accepts impedance of 24 ohms or more Less than 0.1% (6 ohms at 1 kHz, 100 W) MHC-GN700 The following are measured at AC 127V, 60 Hz (Mexican model only) The following are measured at AC 120, 220, 240V 50/60 Hz (except Mexican model) DIN power output (rated) 160 + 160 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference) 200 + 200 watts (6 ohms at 1 kHz, 10% THD) Inputs GAME (VIDEO): 1 Vp-p, 75 ohms (phono jack) GAME (AUDIO): Voltage 250 mV, (phono jacks) impedance 47 kilohms MD/VIDEO (AUDIO) IN: voltage 450 mV/250 mV, (phono jacks) impedance 47 kilohms MIC: sensitivity 1 mV, (phone jack) impedance 10 kilohms Frequency response Wave length CD OPTICAL DIGITAL OUT (Square optical connector jack, rear panel) Wave length 660 nm Output Level –18 dBm Compact disc and digital audio system Semiconductor laser (λ=795nm) Max. 44.6 µW* *This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block with 7 mm aperture. 2 Hz – 20 kHz (±0.5 dB) 795 nm – Continued on next page – MiNi Hi-Fi COMPONENT SYSTEM 9-877-280-01 2003D0200-1 C 2003.04 Sony Corporation Home Audio Company Published by Sony Engineering Corporation HCD-GN700/GX8800 Tape player section Recording system Frequency response 4-track 2-channel stereo 50 – 13,000 Hz (±3 dB), using Sony TYPE I cassette Tuner section FM stereo, FM/AM superheterodyne tuner FM tuner section Tuning range Antenna Antenna terminals Intermediate frequency This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. SAFETY CHECK-OUT 87.5 – 108.0 MHz FM lead antenna 75 ohm unbalanced 10.7 MHz After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. AM tuner section Tuning range North and Latin American models: 530 – 1,710 kHz (with the interval set at 10 kHz) 531 – 1,710 kHz (with the interval set at 9 kHz) Middle Eastern models: 531 – 1,602 kHz (with the interval set at 9 kHz) Other models: 531 – 1,602 kHz (with the interval set at 9 kHz) 530 – 1,710 kHz (with the interval set at 10 kHz) Antenna AM loop antenna Antenna terminals External antenna terminal Intermediate frequency 450 kHz General Power requirements US model: Mexican models: Argentina models: Other models: LEAKAGE The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) To Exposed Metal Parts on Set 2. 3. 120 V AC, 60 Hz 120 or 127 V AC, 60 Hz 220 V AC, 50/60 Hz 120 V, 220 V or 230 - 240 V AC, 50/60 Hz Adjustable with voltage selector 205 watts 220 watts Approx. 280 x 360 x 386.5 mm Approx. 11.4 kg Power consumption MHC-GN700 MHC-GX8800 Dimensions (w/h/d) Mass : HCD-GN700/GX8800 Design and specifications are subject to change without notice. 0.15 µF 1.5 kΩ AC Voltmeter (0.75 V) Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270 ˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. Earth Ground Fig. A. Using an AC voltmeter to check AC leakage. SAFETY-RELATED COMPONENT WARNING!! CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. 2 HCD-GN700/GX8800 TABLE OF CONTENTS 1. 2. 3. 3-1. 3-2. 3-3. 3-4. 3-5. 3-6. 3-7. 3-8. 3-9. 3-10. 3-11. 3-12. 3-13. 3-14. 3-15. 3-16. SERVICING NOTES ................................................ 4 GENERAL Location of Controls ....................................................... 5 DISASSEMBLY Case ................................................................................. Loading (Panel) ............................................................... Front Panel Assy ............................................................. Tuner Pack, Sub Trans Board ......................................... CD Mechanism Deck ...................................................... Game In Board, Tape Mechanism Deck ......................... CD Switch Board, Display Board .................................. Volume Board .................................................................. Subwoofer Board, Rear Panel ........................................ Main Board ...................................................................... Power Amp Board ........................................................... SW Board, Driver Board ................................................. CD Board, CD Block Assy ............................................. Sensor Board ................................................................... Motor (TB) Board ........................................................... Motor (LD) Board ........................................................... 8 8 9 9 10 10 11 11 12 12 13 13 14 14 15 15 7-14. 7-15. 7-16. 7-17. 7-18. 7-19. 7-20. Schematic Diagram – Display Board – ......................... Printed Wiring Board – Power Amp Board – ................ Schematic Diagram – Power Amp Board – .................. Printed Wiring Boards – Trans Board – ........................ Schematic Diagram – Trans Board – ............................. IC Block Diagram ........................................................... IC Pin Function Description ........................................... 43 44 45 46 47 48 49 8. 8-1. 8-2. 8-3. 8-4. EXPLODED VIEWS 54 55 56 57 58 Case, Rear Panel Section ................................................ Front Panel Section ......................................................... Chassis Section ............................................................... CD Mechanism Deck Section-1 (CDM74-K6BD47S) ....................................................... 8-5. CD Mechanism Deck Section-2 (CDM74-K6BD47S) ....................................................... 9. ELECTRICAL PARTS LIST ............................... 59 4. 5. 6. TEST MODE .............................................................. 16 MECHANICAL ADJUSTMENTS ....................... 20 ELECTRICAL ADJUSTMENTS Deck section .................................................................... 20 CD Section ...................................................................... 22 7. DIAGRAMS 26 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 7-1. Circuit Board Location ................................................... 7-2. Block Diagram – CD Servo Section – ........................... Block Diagram – Tuner/Tape Deck Section – ............... Block Diagram – Main/Power Section – ....................... Block Diagram – Display Section – .............................. 7-3. Printed Wiring Board – CD Board – ............................. 7-4. Schematic Diagram – CD Board – ................................ 7-5. Printed Wiring Board – CD Mechanism Board – ......... 7-6. Schematic Diagram – CD Mechanism Board – ............ 7-7. Printed Wiring Boards – Main Board – ......................... 7-8. Schematic Diagram – Main Board (1/3) – .................... 7-9. Schematic Diagram – Main Board (2/3) – .................... 7-10. Schematic Diagram – Main Board (3/3) – .................... 7-11. Printed Wiring Boards – Game In, CD Switch Board – ...................................... 7-12. Schematic Diagram – Game In, CD Switch Board – ...................................... 7-13. Printed Wiring Board – Display Board – ...................... 3 HCD-GN700/GX8800 SECTION 1 SERVICING NOTES • MODEL IDENTIFICATION – Back Panel – PART No. NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. LASER DIODE AND FOCUS SEARCH OPERATION CHECK Carry out the “S curve check” in “CD section adjustment” and check that the S curve waveforms is output three times. MODEL GN700 : E2, E3models GN700 : E51 model GN8800 : US models GN700 : Mexican model GN700 : Argentina model • Abbreviation E2 : 120 V AC Area in E model E3 : 240 V AC Area in E model E51 : Chilean and Peruvian model PART No. 4-244-106-0[] 4-244-106-1[] 4-244-106-2[] 4-244-106-3[] 4-244-106-4[] 4 SECTION 2 GENERAL HCD-GN700/GX8800 This section is extracted from instruction manual. Main unit ALPHABETICAL ORDER A-D ALBUM +/- qg AMP MENU rd CD r; CD SYNC qj DECK A wk DECK B wd DIRECTION 9 DISC 1~3 3 DISC SKIPEX-CHANGE 4 Disc tray 6 DISPLAY ra Display 2 GAME INPUT (jacks) wj GAME MIXING ef GROOVE ed IR (receptor) rs ILLUMINATION wl R-Z REC PAUSE/START qk REPEAT 8 SURROUND SPEAKER MODE w; TAPE A/B ek TUNER/BAND el TUNER MEMORY 7 VOLUME ws M-Q MD (VIDEO) ej MIC (jack) wh MIC LEVEL wg MOVIE EQ qh MUSIC EQ eg OPEN/CLOSE Z 5 P FILE wa PHONES (jack) wf PLAY MODE 7 Power illuminator e; PUSH ENTER q; SYMBOLS @/1 (power) 1 hH (play) qa x (stop) qs X (pause) qd . (go backward) qf > + (go forward) qf m (rewind) qg M (fast forward) qg V/v/B/b q; A A (Eject A) es A B (Eject B) ql E-L EDIT 9 EFFECT ON/OFFrf FM MODE 8 GAME eh GAME EQ ea 1 2 3 45 6 rf rd ra rs r; el ek ej eh eg 7 8 9 0 qa qs qd qf qg qh ef qj qk es ql w; wa ws wd ed ea e; wl wk wj wh wg wf 5 HCD-GN700/GX8800 This section is extracted from instruction manual. Remote Control ALPHABETICAL ORDER A-M CD ql CLEAR 7 CLOCK/TIMER SELECT 2 CLOCK/TIMER SET 3 D.SKIP 9 ENTER qd EFFECT ON/OFFqf GAME w; MD (VIDEO) q; TUNING + ws VOL +/- 8 SYMBOLS @/1 (power) 4 nN (play) wg X (pause) 5 x (stop) 6 .(go backward) wd > (go forward) wf m (rewind) wa M (fast forward) ws M/m/ button or . button to display next error) $$: Error type 01: Focus error 02: GFS error 03: Setup error %%: Not used &&: 00: No disc judgment without chucking retry. 01: No disc judgment after chucking retry. ##: The state when judged as no disc 01: Stop 02: Setup 03: TOC reading 04: Access 05: Playback 06: Pause 07: Manual search (Play) 08: Manual search (Pause) Button Display of Mechanical errors M + Button – m Button Display of no disc errors 4. To clear the error record, operate the cold reset. (Refer to the “MC COLD RESET”) 5. To release this mode, press the ?/1 button or disconnect the power plug to turn the power OFF. 1) Display of total error Display EMC**EDC** EMC**: The number of mechanical errors. EDC**: The number of no disc errors after chucking the disc. 2) Display of mechanical errors Display [CD REPEAT 5 LIMIT OFF MODE] • The number of repeat for CD playback is 5 times when the repeat mode is “REPEAT ALL”. This mode enables CD to repeat playback for limitless times. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select CD function. 3. Press x button, [REPEAT] button and [CD] button simultaneously to enter the CD repeat 5 limit off mode and the fluorescent indicator tube displays “LIMIT OFF”. 3. To release this mode, operate the cold reset. (Refer to the “MC COLD RESET”) M*$$%%&&##00 M*: The number of mechanical error (“00” is latest one) (Press > button or . button to display next error) $$: Not used %%: Loading related error (Second figure is not used) D: Stop by the problem other than mechanical problem while closing. E: Stop by the problem other than mechanical problem while opening. C: Stop by the problem other than mechanical problem while chucking up. F: Stop by the problem other than mechanical problem while chucking down. &&: Emerging error 01: Stop while chucking up. 02: Stop while chucking up. 03: Time-out of EX-CHANGE open. 05: Time-out of EX-CHANGE close. ##: Not used [CD SHIP MODE (WITH MEMORY CLEAR)] • This mode moves the optical pick-up to the position durable to vibration and clears all data including preset data stored in the RAM to initial conditions. Use this mode when returning the set to the customer after repair. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select CD function. 3. Press x button, [AMP MENU] button and [GAME] button simultaneously. The set will power off automatically. 4. After the “STANDBY” blinking display finish, a message “LOCK” is displayed on the fluorescent indicator tube and the CD ship mode is set. 18 HCD-GN700/GX8800 [CD SHIP MODE (WITHOUT MEMORY CLEAR)] • This mode moves the optical pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select CD function. 3. Press [CD] button and ?/1 button simultaneously. The set will power off automatically. 4. After the “STANDBY” blinking display finish, a message “LOCK” is displayed on the fluorescent indicator tube and the CD ship mode is set. [CD TRAY LOCK MODE] • This mode let you lock the disc trays. When this mode is activated, the disc tray will not open when Z OPEN/CLOSE button or [DISC SKIP/EX-CHANGE] button is pressed. The message “LOCKED” will be displayed in the will be displayed on the fluorescent indicator tube. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select CD function. 3. Press x button and Z OPEN/CLOSE button simultaneously and hold down until “LOCKED” or “UNLOCKED” displayed on the fluorescent indicator tube (around 5 seconds). [CD POWER MANAGE] • This mode let you switch on or off power supply to the BU during TUNER function. • When CD POWER is set to OFF, the power supply to the BU is cut off during TUNER function. It will increase the time taken to access CD when function change from TUNER to CD but it will improve tuner reception. • When CD POWER is set to ON, the power supply to the BU is not cut off during TUNER function. It will reduce the time taken to access CD when function change from TUNER to CD but it will decrease tuner reception performance. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select CD function. 3. Press ?/1 button to turn the set OFF. 4. Press x button and ?/1 button simultaneously. The set will power on automatically. 5. The message “CD POWER ON” or “CD POWER OFF” will be displayed on the fluorescent indicator tube. [MD/VIDEO SWITCHING] • This mode let you switch from MD to VIDEO and vice-versa. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select MD function. 3. Press [MD $VIDEO%] button and ?/1 button simultaneously. The function will change to VIDEO. Press the same buttons again to change from VIDEO to MD. 19 HCD-GN700/GX8800 SECTION 5 MECHANICAL ADJUSTMENTS Precaution 1. Clean the following parts with a denatured alcohol-moistened swab: record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement Mode Torque meter Meter reading SECTION 6 ELECTRICAL ADJUSTMENTS DECK SECTION 0 dB=0.775 V 1. Demagnetize the record/playback head with a head demagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjust. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and RCH. 7. Switches and controls should be set as follows unless otherwise specified. • Test Tape Tape P-4-A100 Signal 10 kHz, –10 dB Used for Azimuth Adjustment FWD CQ-102C FWD back tension REV CQ-102C CQ-102RC REV back tension FF/REW CQ-102RC CQ-201B FWD tension CQ-403A REV tension CQ-403R 3.06 N • m to 6.96 N • m 31 to 71 g • cm (0.43 – 0.98 oz • inch) 0.19 N • m to 0.58 N • m 2 to 6 g • cm (0.02 – 0.08 oz • inch) 3.06 N • m to 6.96 N • m 31 to 71 g • cm (0.43 – 0.98 oz • inch) 0.19 N • m to 0.58 N • m 2 to 6 g • cm (0.02 – 0.08 oz • inch) 6.96 N • m to 14.02 N • m 71 to 143 g • cm (0.98 – 1.99 oz • inch) 9.80 N • m 100 g or more (3.53 oz or more) 9.80 N • m 100 g or more (3.53 oz or more) RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENT DECK A DECK B Note: Perform this adjustments for both decks Procedure: 1. Mode: Playback test tape P-4-A100 (10 kHz, –10 dB) MAIN board CN301 Pin 1 (L-CH) Pin 3 (R-CH) level meter set MAIN board CN301 Pin 2 (GND) + – 20 HCD-GN700/GX8800 2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak. REC BIAS ADJUSTMENT DECK B Procedure: In the MC test mode, the “REC memory mode” is convenient for this adjustment. In the “REC memory mode” , when the REC starts the input signal FUNCTION is switched to VIDEO automatically. When the REC stops, the tape returns near to the recording start position. 1. Press MD (VIDEO) button to select VIDEO. (This step is not necessary if the above test mode has already been set) 2. Insert a tape into deck B. 3. After press [REC PAUSE/START] button, press [REC PAUSE/ START] button, then recording start. 4. Mode: Record MAIN board MD/VIDEO (AUDIO) IN (J750) 1) 315 Hz  50 mV (–23.8 dB)  2) 10 kHz  attenuator L-CH peak Output level within 1dB within 1dB Screw position R-CH peak L-CH peak R-CH peak Screw position 3. Mode: Playback test tape P-4-A100 (10 kHz, –10 dB) L-CH MAIN board CN301 set R-CH pin 3 waveform of oscilloscope oscilloscope pin 1 pin 2 L R V H AF OSC 600 Ω set blank tape CN-123 5. Mode: Playback MAIN board CN301 Pin 1 (L-CH) Pin 3 (R-CH) set recorded portion level meter + – in phase 45 ° good 90 ° 135 ° 180 ° wrong 4. After the adjustments, apply suitable locking compound to the pats adjusted. Adjustment Location: Playback Head (Deck A). Record/Playback/Erase Head (Deck B). MAIN board CN301 Pin 2 (GND) 6. Confirm the playback signal recorded in step 3 becomes adjustable level as follows. If these levels are not adjustable level, adjust the RV304 (LCH) and RV354 (R-CH) on the MAIN board to repeat steps 4 and 5. Adjustable level: Playback output of 315 Hz to playback output of 10 kHz: ±1.0 dB Adjustment Location: MAIN board forward reverse 21 HCD-GN700/GX8800 REC LEVEL ADJUSTMENT DECK B Procedure: In the MC test mode, the “REC memory mode” is convenient for this adjustment. In the “REC memory mode” , when the REC starts the input signal FUNCTION is switched to VIDEO automatically. When the REC stops, the tape returns near to the recording start position. 1. Press MD (VIDEO) button to select VIDEO. (This step is not necessary if the above test mode has already been set) 2. Insert a tape into deck B. 3. After press [REC PAUSE/START] button, press [REC PAUSE/ START] button, then recording start. 4. Mode: Record MAIN board MD/VIDEO (AUDIO) IN (J117) 315 Hz, 50 mV (–23.8 dB) 600 Ω attenuator set CD SECTION Note: 1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. S-curve Check Connection: oscilloscope CD board TP4 (FE) TP7 (DVC) + – AF OSC blank tape CS-123 5. Mode: Playback MAIN board CN301 Pin 1 (L-CH) Pin 3 (R-CH) set Procedure: 1. Connect an oscilloscope to test point TP4 (FE) and TP 7(DVC) on the CD board. 2. Turn the power on. 3. Put the disc (YEDS-18) in and turned power switch on again and actuate the focus search. (actuate the focus search when disc table is moving in and out) 4. Check the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 2.4 ± 1 Vp-p. S-curve waveform recorded portion level meter + – symmetry A B MAIN board CN301 Pin 2 (GND) within 2.4 ± 1 Vp-p 6. Confirm the play back signal recorded in step 3 becomes adjustable level as follows. If these levels are not adjustable level, adjust the RV301 (LCH) and RV351 (R-CH) on the MAIN board to repeat steps 4 and 5. Adjustable level: CN301 PB level: 47.2 to 53.0 mV (–24.3 to –23.3 dB) Adjustment Location: MAIN board – MAIN BOARD (Component Side) – Note: • Try to measure several times to make sure than the ratio of A : B or B : A is more than 10 : 7. • Take sweep time as long as possible and light up the brightness to obtain best waveform. Checking Location: CD board (SIDE B) (See page 24.) REC LEVEL ADJUSTMENT 3 1 CN301 (R-CH) RV351        RV301 (L-CH) IC301 RV304 RV354 (L-CH) (R-CH)        REC BIAS ADJUSTMENT 22 HCD-GN700/GX8800 RFAC Level Check Connection: oscilloscope CD board TP5 (RFAC) TP7 (DVC) + – E-F Balance Check Connection: oscilloscope CD board TP2 (TE) TP7 (DVC) + – Procedure: 1. Connect an oscilloscope to test point TP5 (RFAC) and TP 7(DVC) on the CD board. 2. Turn the power on. 3. Put the disc (YEDS-18) in to playback the number five track. 4. Confirm that oscilloscope waveform is clear and check RFAC signal level is correct or not. Note: A clear RFAC signal waveform means that the shape “◊” can be clearly distinguished at the center of the waveform. RFAC signal waveform VOLT/DIV: 200 mV TIME/DIV: 500 ns level: 0.9 ± 0.4 Vp-p Procedure: 1. Connect an oscilloscpe to test point TP2 (TE) and TP7 (DVC) on the CD board. 2. Turn the power on. 3. Select the function “CD”. 4. Press three buttons of [ENTER], M , and [SURRUUND MODE] simultaneously to set the CD service mode. 5. Put the disc (YEDS-18) in to playback the number five track. 6. Press the . button. The message “TRAVERSE” is displayed. (The tracking servo and the sledding servo are turned OFF) 7. Check the level B of the oscilliscope's waveform and the A (DC voltage) of the center of the Traverse waveform. Confirm the following : A/B x 100 = less than ± 22% Traverse Waveform Center of the waveform B Checking Location: CD board (SIDE B) (See page 24.) 0V A (DC voltage) level: 1.0 ± 0.5 Vp-p Press the . button. The message “TRAVERSE” is displayed. (The tracking servo and sledding servo are turned ON) Confirm the C (DC voltage) is almost equal to the A (DC voltage) is step 5. 9. To exit from this mode, perform as follows. 1) Move the optical pick-up to the most inside track. 2) Press three buttons of x , [CLEAR], and [DISPLAY] simultaneously. (cold reset) 8. Notes: • Always move the optical pick-up to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded. • Do not run the sled motor excessively, otherwise the gear can be chipped. Traverse Waveform 0V Tracking servo Sled servo OFF Tracking servo Sled servo ON C (DC voltage) Checking Location: CD board (SIDE B) (See page 24.) 23 HCD-GN700/GX8800 Checking Location: – CD BOARD (SIDE B) – TP4 (FE) TP2 (TE) TP7 (DVC) IC101 TP5 (RFAC) IC103 IC104 24 HCD-GN700/GX8800 SECTION 7 DIAGRAMS Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • f : internal component. • 2 : nonflammable resistor. • 5 : fusible resistor. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • • • • • C : panel designation. A : B+ Line. B : B– Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal conditions. CD board section no mark: CD PLAY Other board section no mark: TUNER (FM/AM) ( ): CD PLAY < >: TAPE PLAY [ ]: TAPE REC Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : TUNER (FM/AM) E : TAPE PALY (DECK A) d : TAPE PALY (DECK B) G : RECORD J : CD PALY (ANALOG OUT) c : CD PALY (DIGITAL OUT) q : MD/VIDEO (AUDIO) IN j : GAME IN (AUDIO) k : GAME IN (VIDEO) N : MIC INPUT • Abbreviation AR : Argentine model E2 : 120 V AC Area in E model E3 : 240 V AC Area in E model E51 : Chilean and Peruvian model MX : Mexican model Note on Printed Wiring Boards: • X : parts extracted from the component side. • : Pattern from the side which enables seeing. (The other layers´ Patterns are not indicated.) Caution: Pattern face side: Parts on the pattern face side seen from the (Side B) pattern face are indicated. Parts face side: Parts on the parts face side seen from the (Side A) parts face are indicated. • Indication of transistor. C Q B E These are omitted. Q B C E These are omitted. Q B C E These are omitted. • • • • • Abbreviation AR : Argentine model E2 : 120 V AC Area in E model E3 : 240 V AC Area in E model E51 : Chilean and Peruvian model MX : Mexican model 25 HCD-GN700/GX8800 7-1. CIRCUIT BOARD LOCATION TUNER PACK SUB TRANS board CD SWITCH board TRANS board POWER AMP board SENSOR board SW board MOTOR (LD) board CD board MOTOR (TB) board DRIVER board DISPLAY board MAIN board VOLUME board GAME IN board 26 HCD-GN700/GX8800 r WAVEFORMS – CD BOARD – XC-OUT – DISPLAY BOARD – TE – MAIN BOARD – 1 IC501 qa 1 IC101 ra 1 0.4Vp-p IC601 is X OUT 3.0Vp-p 32KHz VOL/DIV : 1V AC TIME/DIV : 10µsec 2.4Vp-p VOL/DIV : 0.2V AC TIME/DIV : 0.2msec 4MHz VOL/DIV : 1V AC TIME/DIV : 0.2µsec 2 IC501 qd X-OUT 2 IC101 el FE 2.0Vp-p 0.15Vp-p 16MHz VOL/DIV : 1V AC TIME/DIV : 50nsec VOL/DIV : 0.1V AC TIME/DIV : 1msec 3 T331 4 TAPE REC only 240Vp-p 3 IC101 t; RFAC 0.96Vp-p 13µsec VOL/DIV : 50V AC TIME/DIV : 10µsec VOL/DIV : 0.2V AC TIME/DIV : 0.5µsec 4 T331 5 TAPE REC only 64Vp-p 13µsec VOL/DIV : 50V AC TIME/DIV : 10µsec 27 27 HCD-GN700/GX8800 7-2. BLOCK DIAGRAM – CD SERVO Section – OPTICAL PICK-UP BLOCK (KSS-213DCP) VC CD A+3.3V A B C D E F Q101 LD LD DRIVE 1 LD 6 A 7 B 8 C 9 D 10 E 11 F RF AMP DIGITAL SERVO DIGITAL SIGNAL PROC. IC103 14 DVC RF AC 15 IC101 50 RFAC 43 RFDC D OUT 64 IC201 3 OPTICAL OUT OPTICAL OUT(CD) RFDCO 28 RFDCI 29 FE 16 D/A CONV, MP3 DECODER IC104 39 FE 41 TE PCMD 66 BCLK 67 LRCK 65 XTAI 71 XTAO 72 40 SE 12 SDIO 13 BCKIA 14 LRCKIA 60 CKI/CKO RO 26 R-CH SYSTEM CONTROL CD/TAPE MECHANISM CONTROL MUTE Q201 Q206, 207 BUFFER LO 23 CD L-CH A FEI 17 TE 18 MAIN/POWER SECTION IC501 (1/4) GND APC SW 12 MIDIO 5 62 XI X201 16.9MHz 63 XO 22 23 6 7 4 5 2 DRV 6 DATA IN 5 DATA OUT CD-A-MUTE 25 7 MP3 CLK 3 MP3 ACK 18 MP3 REQ 1 MP3 CS 2 MP3 LP 48 MP3 RESET PD VR 2 PD MICK 6 MIACK/AD2 7 PO7 39 MICS/AD0 3 MOTOR/COIL DRIVE IC150 FOCUS COIL DRV FT+ + 17 12 DRV 11 M101 SLED MOTOR 14 M 13 DRV + M102 SPINDLE MOTOR 16 M 15 MUTE 20 CD +3.3V SSTP 26 S101 LIMIT IN SW DISPLAY SECTION • R-CH is omitted due to same as L-CH • Signal Path : CD : DIGITAL OUT +2.5V 3 E-1 21 MOTOR DRIVER RE701 ROTARY ENCODER – TRACKING COIL T- + – – F+ 18 33 FFDR 34 FRDR 31 TFDR 32 TRDR 29 SFDR 30 SRDR 25 MDP DATA 4 CLOK 6 XLAT 5 SQCK 77 SCLK 8 SCOR 15 SQSO 76 SENS 7 MILP/AD1 4 RESET 1 35 CD-DATA 37 CD-CLK 36 CD-XLAT 33 SQ-CLK 19 SCOR 32 SQ-DATA-IN EJECTSW 42 34 SENSE S751 (LEVER) 27 25 D+3.3V SENS SQ-DATA D-SENS 41 Q731 3 4 TABL SENSOR 1 2 MOTOR DRIVER B SQ-CLK XRST 2 IC731 40 C-XRST 24 BU-PWM3 26 BU-PWM2 28 BU-PWM1 TM-F 44 TM-R 45 FIN 7 RIN 9 LMF 46 LMR 47 7 9 FIN RIN IC701 MOTOR DRIVE OUT 2 OUT 4 M M751 (LOADING) 38 LD-ON MOTOR DRIVE OUT 2 OUT 4 M M741 (TABLE) IC121 +2.5V 1 REG CD A+3.3V E-2 22 E-3 43 IC712 28 28 HCD-GN700/GX8800 – TUNER/TAPE DECK Section – IC303 R-CH + HPF MUTE Q306,389 AMS DETECT Q390, 398, 399 DECK-A L – CH PB HEAD R – CH R-CH REC/PB SWITCH DECK-B 1 L – CH REC/PB HEAD R – CH R-CH C333, L301 BIAS TRAP 2 GND 4 BUFFER Q304,305 DECK A/B SELECT PB/REC EQUALIZER AMP 34 32 AIN1 A B BIN1 120 93 EQ OUT1 28 27 TAI1 PB OUT1 26 CN301 L R-CH R TAPE L-CH C MAIN/POWER SECTION IC302 SWR1 TEST CONNECTOR IC301 REC-OUT1 REC IN1 RV301 REC(L) LEVEL REC L-CH 3 SWP1 R-CH NORM/HIGH SPEED 21 RV304 R-CH REC BIAS(L) REC MUTE ON/OFF EQ 24 D MAIN/POWER SECTION MUTE ON/OFF ALC ON/OFF SYSTEM CONTROL (CD/TAPE MECHANISM CONTROL) ERASE HEAD BIAS OSC Q302, 303 A/B T301 TC A+9V Q307,310 IC501(2/4) 63 52 51 54 53 56 60 66 90 89 61 68 91 67 55 59 AMS-IN TC-MUTE REC-MUTE ALC PB-A/B REC BIAS B REC, REV A REC, FWD B-SHUT A-SHUT B-PLAY A-PLAY B-HALF A-HALF TC-RELAY A-TRIG 13 12 11 15 14 RIPPLE FILTER Q301 TC BLOCK REC(REV) REC(FWD) BSHUT ASHUT BPLAY APLAY BHALF AHALF ATRGM+ • R-ch is omitted due to same as L-ch. • SIGNAL PATH : TUNER (FM/AM) : PLAYBACK (DECK A) : PLAYBACK (DECK B) : RECORD Q391, 392 A TRIG DRIVE Q395, 396 B TRIG DRIVE Q393,394 CAP MOTOR DRIVE BTRGM+ 58 B-TRIG CAP M+ CN304 FM/AM TUNER UNIT TUNER L – CH ST-L FM 75Ω FM ANT FM ANT ST-R ST-MUTE STEREO TUNED R-CH 57 CAPM-CTRL E MAIN POWER SECTION 100 ST-MUTE 85 STEREO 86 TUNED 65 88 97 87 ST-DIN ST-DOUT ST-CLK ST-CE AM ANT AM ANTENNA ST-DOUT/MC-DIN ST-DIN/MC-DOUT AM ANT ST-CLK ST-CE 29 29 HCD-GN700/GX8800 – MAIN/POWER Section – TUNER/TAPE DECK SECTION DISPLAY SECTION D F REC L-CH SPEANA J117 L 19 8 INPUT SELECT SWITCH, TONE CONTROL, ELECTRICAL VOLUME IC102 BB A1 R-CH BB B1 16 17 POWER AMP IC501 11 10 8 9 FEED BACK SWITCH Q101 R-CH D130 HEADPHONE MUTING Q671, 624 J631 PHONES SAOUT R R-CH RECB1 VIDEO/MD (AUDIO) IN + MUTING CONTROL SWITCH Q652 TM501 + CD SECTION TUNER/TAPE DECK SECTION TUNER/TAPE DECK SECTION A E C CD L-CH IND1 6 INB1 4 INC1 5 INA1 3 INEX1 INPUT SELECT SWITCH SOUND CONTROL CIRCUIT TOUT1 VOLIN1 OUT1 VOLUME CONTROL 18 TUNER L-CH 18 14 15 TAPE L-CH 7 R-CH R-CH R-CH 14 12 D507 CPU INTERFACE MUTING Q620 R-CH MIC DATA CLOCK D511 + + – + – + – + – RY502 L FRONT SPEAKER IMPEDANCE USE 6–16Ω R + 2 J601 L AUDIO GAME INPUT R R-CH J761 VIDEO OUT VIDEO 21 22 OVER LOAD DETECT Q501, 551 L + OVER CURRENT PROTECTOR IC502 2 VP 1 OCP D502 OVER LOAD DETECT SWITCH Q510 RELAY SWITCH Q511 FRONT SPEAKER RELAY DRIVE Q516, 517 D509 VL (AC) VL (AC) D508 RY501 R SURROUND SPEAKER IMPEDANCE USE 24Ω 79 80 AUDIO–DATA AUDIO–CLK STANDBY SWITCH Q503, 504, 581 + 3 OUT CT 4 SYSTEM CONTROLLER IC501 (3/4) J721 MIC SURROUND SPEAKER PROTECT RELAY DRIVE Q513, 515 MIC AMP IC722 (1/2) MIC AMP IC722 (2/2) BIAS Q721 A+9V PROTECTOR 78 FRONT-RELAY 83 RV722 MIC LEVEL TEMPERATURE DETECT SWITCH Q505, 506 FAN MOTOR ON SWITCH Q518 Q602 VACS IN 81 HP MUTE 76 HP DETECT 50 LINK-RELAY 84 TH502 TEMPERATURE DETECT SWITCH Q514 FAN MOTOR DRIVE Q851, 852 M891 (FAN) STK-MUTE 75 M OVER LOAD DETECT SWITCH Q385 TH501 MUTING CONTROL SWITCH Q650, 651 LINE-MUTE 77 R-ch is omitted due to same as L-ch. SIGNAL PATH : TUNER (FM/AM) : TAPE PLAY : REC : CD PLAY : VIDEO/MD (AUDIO) IN : GAME INPUT (AUDIO) : GAME INPUT (VIDEO) : MIC INPUT 30 30 HCD-GN700/GX8800 – DISPLAY Section – M+9V Q606 8 – 10, 12 – 22, 24 – 41, 43 – 46 P1 – 36 Q707 P1 – 36 SELECTOR 72 Q605 Q601 G14 94 G14 6 – 1, 100 – 95, 92 – 87 52 – 59, 73 FL601 FLUORESCENT INDICATOR TUBE G15 BUFFER Q807, 808 93 G15 LED DRIVE Q602 – 604, Q1001 – 1006 D603, 605, 601 D1002, 1004, 1006 D1008, 1010, 1012 D602, 606, 604 D1001, 1003, 1005, D1007, 1009, 1011 G1 – 13, 16 – 21 VF1 VF2 1G – 13, G16 – 21 DISPLAY CONTROL KEY CONTROL IC601 KEY2 64 – 66 D610 -VG (-32V) D101 2 6 BPF, RECT IC101 1 D102 7 D103 MAIN/POWER SECTION 70 SUPER LOW FREQUENCY (BPF0) 69 BPF1 48 VKK | KEY0 S782 – 792, 779 S765 – 772, 773 S751 – 763 VL(AC) VL(AC) F974 +VL –VL RECT D541 F975 F976 +VH IIC PROGRAM –VH RECT D543 F977 – 33V REGULATOR Q903 R941 D977 RECT VF1 VF2 T910 MAIN POWER TRANSFORMER VL VL GND VH VH X F SPEANA 2 6 BPF, RECT IC102 1 D104 7 68 BPF2 67 BPF3 D+3.3V CN501 2 D+3.3V 3 IIC-CLK 4 IIC-DATA BAFFER, RECT Q100, D105 71 ALL_BAND – VG (-32V) 80 VOL 1A 79 VOL 1B 83 X1 IIC DATA 60 IIC CLK 61 RESET 77 TXD1 TXD1 CNVSS 30 IIC-DATA 29 IIC-CLK 41 GC-RESET SYSTEM CONTROLLER IC501 (4/4) VP VOLUME ROTARY ENCODER S748 VF VF TO FLUORESCENT INDICATOR TUBE FL601 D913 – 915 M +7V +9V REGULATOR IC902 +9V REGULATOR IC901 SQ-CLK CD SECTION X601 4MHz 82 X0 B SENS SQ-DATA CN502 TXD1 2 RTS1 3 CLK1 6 RXD1 7 RESET 9 MCU VCC 5 CN VSS 8 CNVSS M +9V 31 TXD1 9 CNVSS F978 AC3 RECT D901 AC3 GX8800 A +9V TC +9V ON BOARD PROGRAM D748 LED DRIVE Q748 39 STBY-LED CD D+3.3V CD A+3.3V CD-POWER 23 +3.3V REGULATOR IC904 B+ SWITCH Q901, 902 GN700 MCU VCC S749 D +3.9V 74 POWER-KEY D501 73 DISPLAY-KEY S750 DISPLAY STBY-RELAY 27 REMOTE CONTROL RECEIVER IC603 4 SIRCS MCU VCC VREF D502 D504 D503 +3.9V REGULATOR IC903 R952 RECT D909 – 912 AC4 AC4 S901 S901 POWER ON/OFF RELAY DRIVE Q971 RY971 VOLTAGE SELECT 120V | 220V | 230 – 240V AC IN T972 SUB POWER TRANSFORMER 15 X-IN X502 16MHz 13 X-OUT RESET 12 10 XC-IN RESET SWITCH Q601 LEVEL DETECT IC601 EVER +3.9V +3.9V REGULATOR IC971 RECT D972 – 975 D505 X501 32.768kHz 11 XC-OUT AC-CUT 20 31 31 HCD-GN700/GX8800 7-3. PRINTED WIRING BOARD – CD Board – • See page 26 for Circuit Boards Location. 1 2 3 4 5 6 7 8 CD BOARD (SIDE A) A CD BOARD (SIDE B) R153 C151 C150 R155 M M102 SPINDLE MOTOR 28 IC150 15 S101 (LIMIT) R214 R215 R219 R156 B C273 C226 C206 C202 1 C152 14 20 1 80 R216 R218 R212 C203 C205 R213 C223 R202 C263 C215 C259 R151 C222 IC101 TP4(FE) TP2(TE) C102 C101 40 C103 C104 TP7(DVD) 41 R102 R120 R104 C107 R105 R103 R275 C257 R233 R232 C258 C271 C254 FB106 C216 R203 C158 R152 21 M X201 R254 C270 R251 R250 R259 M101 SLED MOTOR R252 R253 R249 C249 64 FB102 R206 C255 FB291 R201 R271 C230 61 60 C209 C227 R255 R205 R207 C108 C212 C211 C250 C274 C269 C109 C FB104 R131 C256 R126 C265 C262 C264 R280 C253 R111 C116 R260 C115 C117 C132 C133 17 32 C268 R117 R114 R125 C110 C267 C251 C252 R265 R266 CN101 FB103 FB107 C260 R279 R276 R113 C208 C276 R122 30 R118 1 C229 R123 R277 D C275 C231 E Q101 1-686-782- 11 (11) L101 C261 3 2 1 IC121 C114 C118 C119 C113 R133 CN102 R220 C131 IC103 C213 IC104 16 33 16 15 R132 R257 C292 C111 R101 TP5(RFAC) R204 R230 R272 C224 C266 R231 49 48 1 1-686-782FB101 11 (11) C279 OPTICAL PICK-UP BLOCK (KSS–213DCP) A MAIN BOARD (Page 36) E • Semiconductor Location Ref. No. IC101 IC103 IC104 IC121 IC150 Q101 Location B-6 C-6 C-7 D-2 B-5 D-3 32 32 HCD-GN700/GX8800 7-4. SCHEMATIC DIAGRAM – CD Board – • See page 49 for Pin Function Description. C271 10000p X201 16.9M R253 680 R252 1M C259 0.047 C249 0.01 C257 0.33 R251 220 C270 220p C258 22p C254 22p R249 FB106 R254 100k 0µH 470 XCKO C269 10 10V R250 220 FB102 0µH C263 10 10V FB104 0µH C256 0.1 C255 0.1 MP3RST C274 10000p R279 100 R271 10k R272 1k R275 10k MICS MILP SDA/MIDIO SCL/MICK AMUTE/MIACK R276 100 C292 1 R259 100 C266 0.1 F IC104 CXD9717R-008 D/A CONV. MP3 DECODER FB291 0µH MP3REQ ADATA BCLK LRCK C250 0.1 C119 1 R260 1k C264 47 4V C265 47 4V R277 0 C262 47 4V C213 3300p C253 0.1 C261 47 4V C251 0.1 C252 0.1 R102 10k R105 1k C107 22p TP5 RFAC C109 0.1 TP10 VC C276 100 4V C118 1 CN102 16P C267 0.0022 R265 220 R120 120k TP12 E TP13 D R126 18k R125 18k TP11 VCC TP14A TP15 B TP16 C C268 0.0022 R266 220 R280 0 C101 470p CH C104 3300p R103 100k C102 0.1 C115 220 4V C117 0.1 R117 120k C116 0.1 TP17 F R111 150k TP6 RFDC IC121 BA25BCOFP +2.5V REG C226 47 4V R207 1M L101 68µH C209 100p C208 C260 0.1 220 4V C211 0.1 R205 1k R206 2.2k C212 0.0022 C215 0.47 R204 2.2k R202 10k C216 0.01 R203 100k R101 0 R104 10k TP3 SE TP2 TE TP4 FE C103 470p CH R114 390k C110 0.1 TP20 PD Q101 2SB970 MUTE TP19 LD C114 0.001 FD+ TDTD+ FDLD TRACKING COIL C230 0.1 TP21 TP22 TP23 TP24 FOCUS COIL R113 3.9k R118 10k C111 100 4V C108 0.1 IC103 CXA2647 RF AMP R122 100k PD R201 33k C113 100 4V TP9 IOP TP18 AGND C224 0.1 TP7 DVC RFSW PWM3 PWM2 PWM1 C275 C279 C229 220 1000 0.1 4V 6.3V R123 3.3 R133 2.2k R132 330k R131 68k C132 0.022 C133 2.2 C131 0.068 R255 100 MICS MILP C227 0.1 R257 100 R230 220 LRCK SD+ TP25 SD- R231 100 R232 100 R233 100 FRDR FFDR TRDR FB101 0µH SCL/MICK AMUTE/MIACK SDA/MIDIO MP3RST MP3REQ PWM3 PWM2 PWM1 RFSW SQSO ADATA BCLK M101 SLED MOTOR TP26 R151 10k MDP C158 0.0022 B R153 0 SP+ IC101 XCKO TFDR SRDR SFDR TP27 R152 220k TP1 SP- CXD3068Q C203 0.001 R216 1M DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR, SFDR SRDR TFDR TRDR R155 0 M102 SPINDLE MOTOR TP28 FRDR FFDR C231 100 4V FB103 0µH MDP R156 0 TP8 MGND IC150 BA5947FP MOTOR DRIVER SQCK C152 0.1 F XRST DATA XLAT CLOK FB107 0µH R212 470 C223 47 4V C222 0.1 F R218 1k R213 470 S101 (LIMIT) C151 0.1 F R215 0 R219 1k C150 100 10V TDTD+ SDSD+ FD+ FDSP+ SP- R220 1k SENS SCOR CN101 31P C202 0.1 F C205 0.1 F SQSO R214 0 C206 47 4V C273 220p B SQCK SCOR CLOK SENS XRST DATA XLAT 33 33 XRST HCD-GN700/GX8800 7-5. PRINTED WIRING BOARDS — CD MECHANISM Board — • Refer to page 26 for Circuit Boards Location. 1 A 2 3 4 5 6 7 8 9 10 11 12 13 14 15 C751 B CN704 CN702 CN705 R733 C737 R735 R734 C736 R732 Q731 C CN703 C735 JW710 R723 R722 R721 JW709 JW708 JW707 JW706 JW705 C715 C741 JW711 C752 JW712 R751 CN742 CN741 D D701 D711 R702 CN721 R701 R711 R713 IC731 E JW713 JW714 R712 JW704 JW703 IC701 IC712 JW702 R731 MAIN BOARD (Page 36) CN731 F JW701 C731 G CN751 S751 H CN701 • Semiconductor Location Ref. No. D701 D711 IC701 IC712 IC731 Q731 Location D-6 D-7 F-6 F-7 E-11 C-9 34 34 HCD-GN700/GX8800 7-6. SCHEMATIC DIAGRAM – CD MECHANISM Board – IC701 BA6956AN LD MOTOR DRIVER OUT2 OUT1 VREF GND VCC RNF RIN VM FIN C715 100 16V CN701 12P R702 100 R701 470 D701 MTZJ-T-77-5.1B M751 (LD) CN721 2P CN704 2P C751 0.01 IC712 BA6956AN TBL MOTOR DRIVER OUT2 OUT1 VREF GND VCC RNF RIN VM FIN C752 0.1 S751 (LEVER SW) R712 100 R713 22k M741 (TBL) CN742 5P IC731 RPI-576 TABLE SENSOR CN731 3P CN741 3P D711 MTZJ-T-77-3.6B R732 4.7k R735 100 R734 22k R731 100 C731 10 50V Q731 DTC114ESA TBL ADDRES SENS SWITCH R721 4.7k R722 4.7k R723 4.7k CN703 4P CN751 4P RE701 ROTARY ENCODER E-3 E-2 E-1 R711 1k R751 4.7k CN705 2P CN751 2P C741 0.01 R733 1k C735 0.1 C736 0.1 C737 0.1 CN702 5P 35 35 HCD-GN700/GX8800 7-7. PRINTED WIRING BOARDS – MAIN Boards – 1 2 3 4 • See page 26 for Circuit Boards Location. 5 6 7 DRIVER BOARD (Page 34) 8 CD BOARD (Page 32) 9 10 11 12 13 (FOR CHECK) B (FOR CHECK) A A MAIN BOARD JW001 JW002 JW003 1 4 TUNER PACK R447 1 CN502 10 R421 R422 JW087 JW366 JR006 1 12 JW367 CN501 D502 D504 D501 R541 R432 JW011 JW012 JW013 R530 JW413 B JW004 JW005 JW006 D503 D509 D508 C211 R112 R537 R536 R535 NO202 R434 C434 R228 JW119 JW120 JW021 R539 JW020 JW017 JW019 R542 R429 R427 JW388 JW389 JW390 R597 R224 C603 R518 R420 JW384 C427 R603 R601 Q601 E FB286 FB204 JW023 R507 JW386 R503 JW387 R550 R587 JW395 JW396 JW405 JW404 JW403 JW402 JW018 R549 JW160 JW401 R588 JW400 JW095 JW398 JW134 R473 R509 1 R505 100 C498 JW183 JW025 R566 R565 FB562 C562 JW137 50 51 C564 R506 C510 R504 R501 R502 C596 C598 JW070 R167 CN402 JW099 JW071 JW072 JW073 JW074 C IC 1 50 C511 R513 R511 R519 JW161 JW165 JW166 JW167 JW168 JW169 JW170 R450 31 30 X502 JW079 R523 JW078 C288 GX8800 JW139 R448 R445 R517 3 R604 1 C416 IC601 C516 C512 FB516 X501 R446 C209 JW053 R544 R529 C432 R545 R543 JW024 R433 R430 R444 R442 C433 R532 R443 R431 D602 R602 C601 JW385 JW406 R538 C602 D601 JW179 JW081 JW382 R521 D505 JW435 C286 FB202 FB205 2 1 30 JW416 R110 R540 JW331 JW332 R522 JW408 FB201 R226 IC201 D OTU 3.3V GND JW180 C201 IC201 CD DIGITAL OUT C207 FB203 CN201 JW407 C210 31 JW022 D603 R419 C206 C203 FB284 JW164 JW171 JW172 JW173 JW391 C167 R168 FB167 R117 L L201 C200 JW014 JR009 JW411 JW412 CN702 J117 MD/VIDEO(AUDIO) IN R600 JW075 JR005 C219 R205 Q201 C269 JW185 R255 3 C918 1 JW136 R474 DISPLAY BOARD (Page 42) JW026 IC904 C104 C103 CLP303 JW175 JW174 C117 R R585 JW100 JW397 JW381 JR007 R204 R284 JW181 R286 JR045 E R583 JW106 JW107 E R118 FB117 JR118 R902 R903 JW096 JW097 R575 R589 R590 R492 R493 80 81 R577 R579 R581 R592 R593 R594 D917 E Q902 R285 Q206 E C109 I D JW033 R574 JW092 JW093 JW094 JW098 Q602 E R576 R573 JW027 R567 JW028 JW029 JW030 R568 R560 R561 R254 R256 R206 Q251 E C919 Q207 E JW103 R901 C105 R107 Q901 C111 R103 JR022 R106 Q101 E R121 C113 C150 21 1 JW431 JW432 JW433 JW434 C110 R102 C108 R104 C107 R101 C106 R477 JR015 C502 R478 R563 R584 R578 JW105 R401 R402 C503 EXCEPT GN700:E3 R591 R586 R580 JW184 JW193 JW194 JW195 JW196 JW221 JW220 JW222 C112 JR103 JW121 JW186 JW187 JW188 JW040 JW041 JW042 JW043 JW365 JW044 JW045 JW046 JW047 JW333 JW334 JW034 JW035 JW036 JW037 R105 C114 C101 C102 JW330 • Semiconductor Location Ref. No. D130 D392 D393 D394 D501 D502 D503 D504 D505 D508 D509 D601 D602 D603 D901 D909 D910 D911 D912 D913 D914 D915 D917 D941 IC102 IC201 IC301 IC302 IC303 IC501 IC502 IC601 IC901 IC902 IC903 IC904 Location F-9 E-4 F-4 F-5 B-2 B-2 B-2 B-2 B-5 B-2 B-2 B-5 B-6 C-5 I-7 H-7 H-7 H-7 H-7 G-7 G-7 G-7 D-6 H-6 E-10 B-12 G-4 I-4 F-4 C-4 J-9 C-6 H-8 H-8 H-7 C-9 Ref. No. Q101 Q151 Q201 Q206 Q207 Q251 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q310 Q389 Q390 Q391 Q392 Q393 Q394 Q395 Q396 Q398 Q399 Q601 Q602 Q620 Q621 Q650 Q651 Q652 Q670 Q671 Q851 Q852 Q901 Q902 Q903 Location D-9 E-9 D-7 D-7 D-8 D-8 I-5 I-5 I-5 I-4 I-4 F-3 I-5 I-5 F-3 F-5 E-4 E-3 E-5 F-5 F-5 F-5 F-5 F-5 B-5 D-3 F-11 I-2 F-11 F-11 J-2 F-11 I-2 G-11 G-11 D-9 D-8 H-7 JW088 JW089 JW090 R130 C115 JW189 JW190 JW068 JW192 JW225 C132 JR24 C121 C116 R155 R122 C122 R142 R141 R140 R150 C154 JW108 JW109 JW110 E GAME IN BOARD (Page 40) JW038 R374 JW048 JW050 JW337 JW049 JR016 JR26 1 E Q392 JR017 R361 R363 C386 JR008 R364 E Q393 D392 E Q391 Q394 Q395 D393 R372 E C387 JW335 E JW336 Q396 E D394 R360 JW380 C397 R395 R397 R396 C391 5 8 IC102 22 42 JW329 JW328 C620 R620 JW191 C130 Q151 E R371 R391 R399 R156 JW117 JW116 JW115 JW114 JW113 JW111 JW112 JR013 R369 R367 NO781 CN304 8 JW428 JW226 JW228 JW229 JW230 JW232 JW233 R373 J F TAPE MECHANISM DECK R366 JR018 JR011 R375 R378 JW256 R394 JW257 R368 R376 R377 JW234 R133 R131 D130 C131 R132 R134 JW245 JW246 JW247 JW248 R153 C161 R154 C159 C156 R151 C163 JR130 R157 C153 C155 C152 R622 R623 C670 Q620 R673 E JW316 R621 C140 JW349 JW351 R152 C160 C162 JW052 R362 JW307 JW308 C651 JW051 R656 JW056 JW059 JW060 JW061 JW076 R365 E R334 R313 C316 R320 C311 IC303 4 1 E Q399 E R390 R387 C157 JW313 C158 NO777 C656 R314 Q389 E Q306 JW235 JW236 JW427 JW237 JW238 JW239 JW240 JW241 JW242 JW243 JW265 JW244 C396 JW317 JR003 R672 R670 R671 R651 R650 E Q651 C650 R652 2 R327 C398 E Q670 E Q650 JW350 R333 R388 JW289 JW251 JW250 JW249 C395 R398 C306 R306 C308 R307 C365 JW197 JW342 C914 JW343 JW344 C913 JW347 JW436 JW414 JW150 JW253 JW252 JW419 JW198 JW320 NO711 2 1 JW310 JW311 JW312 JW309 R303 C315 R315 C304 JW062 R312 R330 R304 C303 R302 JW260 C314 C390 R305 R309 JW151 C305 JW266 JW418 C399 JW258 E JW259 Q398 Q390 JR390 CN301 JW255 JW254 JW429 JW199 JW200 JW201 JW202 JW205 JW346 JW341 JW324 JW323 G JW057 JW058 D915 JW420 JW421 L302 JW203 C312 JW204 JW410 C364 JW299 CLP4 NO901 1 4 JW261 JW363 D913 D914 R913 JW264 JW430 30 1 21 20 C307 11 R308 10 C356 R355 R353 C354 JW207 JW208 JW438 C851 C852 JW348 JW851 JW281 R852 E JW437 JW423 JW424 E Q851 JW352 JW353 R851 JWH001 JW322 JW345 1 1 IC R301 RV301 C911 C309 C301 JR138 30 31 C353 40 1 JW146 C351 R310 JW209 JW210 R370 JW206 RV351 R380 JW271 JW270 C321 NO302 JW145 C310 R905 R904 R906 JW267 C920 D941 C921 C917 JW901 C915 3 1 3 3 M891 FAN DC IC902 1 3 IC901 1 CN851 JW274 JW275 R351 JW138 JW140 C332 L301 JW141 JW154 NO303 8 E IC302 1 JW359 D901 C905 C904 JW358 C333 C382 R329 C381 JW144 JW213 R379 JW214 R317 R316 Q307 E Q310 E JW302 JW425 1 NO903 C335 JW364 RV354 JW142 C385 RV304 R382 R392 C383 L351 R347 R328 E Q301 D910 JW912 C908 C376 C326 E C909 TAPE B HEAD Q305 R393 Q304 R342 C331 C359 1 R332 JW448 JW149 Q903 C341 7 C903 TAPE A HEAD R352 JW211 JR012 E JW268 JW276 H C371 JW147 JW148 JW277 D912 R354 C342 C361 C910 R854 JW280 R853 C355 IC903 C912 JW278 JW279 Q852 D909 D911 C902 JW283 JW286 JW284 C GAME IN BOARD (Page 40) R674 Q671 9 C338 R345 JW360 R624 I R675 E R625 Q621 JW399 T301 CLP302 JR104 C384 JW287 JW292 JW291 C901 JW338 JW716 J716 VIDEO OUT JW288 R626 C339 R346 C337 E R676 R344 Q303 C334 R343 E JW298 JW297 JW361 JW362 R653 Q652 E Q302 E C923 R908 CN902 C922 JW356 JW357 C621 C340 C336 IC502 C924 1 3 1 CN901 1 6 EPT901 C906 JW355 JW354 JW296 JW295 JW294 JW293 4 6 JW306 JW215 JW216 JW217 C671 JW321 JW305 JW304 JW303 J R655 R654 13 (CHASSIS) JR001 1-686-933K SUB TRANS BOARD (Page 46) TRANS BOARD (Page 46) POWER AMP BOARD (Page 44) 11 (11) F H E D POWER AMP BOARD (Page 44) 36 36 HCD-GN700/GX8800 7-8. SCHEMATIC DIAGRAM – MAIN Board (1/3) – • See page 51 for Pin Function Description. REC-OUT-R REC-OUT-L EQ OUT2 EQ OUT1 TC-PB-R TC-PB-L AMS-IN D+3.3V MUTE CD B2 M+9V D3.3V 74 73 NO202 12P AMP-L 42 41 43 22 21 44 45 46 47 R474 100 80 78 77 76 75 79 67 66 65 C311 10 50V R330 22k B3 60 59 61 57 68 56 55 54 58 R567 100 R568 100 R566 100 R565 100 REC LEVEL (L) R304 2.2k C303 0.1 R301 3.3k C301 0.01 C304 10 C305 50V 1 50V R573 10k R305 47k TP325 TP318 C306 2.2 50V C502 0.022 TP320 R306 22k R401 10k C312 10 50V C308 470 16V R308 100 R585 100 R402 10k L302 100µH 51 52 53 81 83 84 86 87 88 54 89 90 91 R561 100 R560 100 R320 2.2k C564 0.01 FB562 0µH R577 100 R576 100 R575 100 R574 10k R580 100 R579 100 R578 100 C562 100 10V R303 10k R477 10k R302 4.7k RV301 47k R478 10k JR015 C314 0.0022 R473 100 53 52 51 C309 47 16V C503 0.022 EVER+3.3V CN301 3P MOLEX 85 C310 10 50V R307 1M (FOR ADJUSTMENT) C307 10 50V R581 100 R583 100 R584 100 R448 R447 R446 R445 R444 R443 R442 IC501 M30622MGN-B09FP SYSTEM CONTROL R541 R540 R539 R550 10k R450 100 470 100 100 100 100 100 100 100 100 100 R538 100 R537 470 R536 100 R535 470 R434 470 C434 47p C211 0.022 R545 10k R544 10k R543 10k R542 10k R549 10k 50 49 48 47 46 45 44 43 42 41 40 38 37 36 35 34 34P 33 33P 32 39 STBY RLY EVER+4V NO302 WIRE MT TAPE A HEAD C321 390p TP338 R309 4.7k R310 100 R586 100 R587 100 R588 100 R589 100 R590 100 R591 100 R592 4.7k R492 1.5k R493 *1 R594 1k C371 390p C359 47 16V C326 390p R312 IC301 100 HA12237 DECK A/B SELECT PB/REC EQUALIZER AMP NO303 WIRE MT TP311 C351 0.01 TAPE B HEAD R351 3.3k C353 0.1 R352 4.7k R370 2.2k C364 0.0022 C376 390p C354 10 50V R353 10k R380 22k C361 10 50V C355 1 50V RV351 47k REC LEVEL (R) TP309 C356 2.2 50V R593 *2 R354 2.2k *2 R593 2.2k 1k NO MT GX8800 GN700:AR,E2,E51,MX GN700:E3 94 97 R597 100 C598 10 50V C596 0.1 C498 0.1 25V R355 47k R433 100 R432 100 C433 47p C432 47p 100 R600 100 *1 R493 4.7k GN700:AR,E2,E51,MX,GX8800 GN700:E3 0 IC302 BA3126N R532 47k 32P 31P Q304 DTA124EKA BUFFER R431 100k 59 57 JR008 55 A-TRG R503 100 R504 100 R505 470 R506 470 R507 470 R501 1k R502 1k Q305 DTC114EKA BUFFER CAMP CONT Q391 2SB1116 R360 680 Q393 2SB1068 R364 680 Q396 2SB1116 R366 680 B-TRG 58 4.7k 100 100 100 R517 10k C416 0.1 R226 150k R519 10k R420 R393 4.7k R332 8.2k L301 27mH L351 27mH C333 330p C331 0.01 R329 10k R342 2.2k D392 1SS355 Q391,392 A TRIG DRIVE Q395 DTC114EKA R224 2.7k C332 120p D393 1SS355 Q394 DTC114EKA D394 1SS355 C427 47p R421 10k R422 10k C385 10 50V JR017 Q392 DTC114EKA R372 2.2k R427 R521 R522 R373 2.2k R513 0 C386 0.0047 R363 2.2k R361 2.2k R371 3.3k R391 3.3k X501 32.768K R511 330k R399 3.3k R509 10k C512 0.1 C387 0.0047 R419 100 R529 10k R429 100 GND R430 100 D508 1SS355 D+3.9V R518 100 R530 10k D501 1SS355 D502 1SS355 D503 1SS355 C510 C511 22p 15p 1 2 3 5 C334 27p 89 REC BIAS (L) 90 91 REC BIAS (R) C384 T301 27p BIAS TRANS 23 RV304 220k RV354 220k C382 120p Q302 2SC2001 C383 R382 330p 8.2k 19 18 21 22 24 25 26 Q301 2SC3624 RIPPLE FILTER Q307 2SA812 SWITCH R316 10k C516 1000 6.3V R367 R368 R369 R374 R375 10k 10k 10k 10k 10k 10k 10k Q601 2SC1623 RESET SWITCH C603 0.1 50V MF C602 0.1 50V MF D+3.3V R523 10k 28 29 30 C381 R379 0.01 10k R392 2.2k 7 X502 16M FB516 Q393,394 CAP MOTOR DRIVE Q395,396 B TRIG DRIVE R228 68k B1 68 67 66 61 R346 18k C339 0.0068 C340 0.018 C337 0.015 R345 18k R317 10k C342 47 16V 12P 9P R328 3.3k 60 10k 4 D504 1SS355 R602 4.7k D602 1SS355 IC601 M62703ML LEVEL DETECT C338 0.0068 Q303 2SC2001 C341 10 50V 31P 33P 32P JR018 CN304 13P D603 1SS355 R604 47k C601 10 50V D505 1SS355 CN501 4P TP432 C335 0.01 100V R344 5.6 1/4W R603 47k R601 220 9P R378 34P 12P C336 R343 2.2 5.6 50V 1/4W 56 D601 1SS355 R376 R377 R347 5.6k Q310 DTC114EKA SWITCH CN502 10P A+9V TAPE MECHANISM DECK (FOR CHECK) (FOR CHECK) 37 37 HCD-GN700/GX8800 7-9. SCHEMATIC DIAGRAM – MAIN Board (2/3) – GND JR118 C117 2.2 50V R157 100 R-OUT C154 10 50V C155 10 50V R141 100 R151 2.2k C159 1 50V R152 10k C158 0.033 C160 0.01 R153 620 JR130 C161 C162 C163 10 50V 0.22 0.33 R155 47k Q151 2SC1623 R156 10k R122 1k J117 2P L R R167 FB167 R168 100k 0 1k C156 0.022 FB117 0 R118 R117 1k 100k C157 0.022 C152 C153 10 R140 10 C140 10k 50V 50V R154 1k 0.068 80 C122 220p NO781 8P 100 R110 0 C167 2.2 50V 85 86 R112 0 50 87 88 65 97 76 77 C656 0.47 A+9V JR016 CN702 11P FFC-R C121 220p B2 79 REC-OUT-R TC-PB-R C107 0.022 C108 0.033 R142 100 C106 0.022 R101 2.2k R150 2.2k R107 100 R102 10k C109 1 50V C111 10 50V C112 C113 0.22 0.33 C115 0.1 C116 100 16V C114 10 50V JR005 R104 1k C110 JR103 0.01 R103 620 R670 10k R105 47k JR022 R620 10k R672 47k R673 10k R650 15k R623 10k R652 68k C650 1 50V BP Q651 DTC114EKA R651 470k Q652 DTA124EKA R654 100k R656 10k R675 1k D509 1SS355 R655 100k R625 1k C104 10 50V TC-PB-L REC-OUT-L JR003 R622 47k R621 1k Q621 2SC3661 HEADPHONE MUTE R626 56 JR24 C101 C150 C102 C103 100 10 10 10 16V 50V 50V 50V C105 10 50V R106 10k Q101 2SC1623 FEED BACK SWITCH Q650 DTA124EKA C670 4.7 50V R671 1k Q670 2SC3661 MUTING R121 1k Q650-652 MUTING CONTROL SWITCH HP-R R653 1k C651 47 50V BP R674 680 JR26 2W 0µH Q671 2SC3661 HEADPHONE MUTE R676 56 C671 4.7 100V BP Q620 2SC3661 MUTING R624 680 2W C621 4.7 100V BP HP-L C130 10 50V IC102 M61529FP-D60G INPUT SELECT SWITCH TONE CONTROL ELECTRICAL VOLUME R130 2.2k R132 1M C131 0.47 50V R133 100k D130 1SS355 C620 4.7 50V C132 0.1 R134 2.4k R131 2.2k R-IN L-IN DBFB F/B SPEANA MUTE AMS-IN D+3.3V EQ OUT1 EQ OUT2 CD C315 1 50V C365 1 50V R315 10k R365 10k *1 FB202-205,284,286 FB286 *1 C206 0.1 C207 1000 6.3V 0 0µH GN700 GX8800 CD-D+3.3V FB203 *1 C219 10 50V FB202 *1 FB204 *1 FB205 *1 C288 0.01 R205 1K R206 33k R255 1K C269 10 50V 1 2 Q201 2SC3661 CD MUTE R204 10k R394 10k R254 10k Q251 2SC3661 CD MUTE IC303(1/2) NJM4565M(TE2) IC303(2/2) NJM4565M(TE2) R333 2.2k R313 1k C316 1 50V R398 2.2M C395 22p IC303 HPF CD-A+3.3V R256 33k JR390 0 C397 10 50V M+7V FB201 0µH FB284 *1 C203 0.01 GX8800 C399 0.01 R397 15k R387 10k Q398 DTC114EKA Q390 DTC114EKA Q390,398,399 AMS DETECT D+3.9V C398 0.01 7 3 5 48 18 24 26 28 38 32 25 R286 22k R285 22k C286 0.47 Q206 DTC114EKA-T146 BUFFER Q207 DTA124EKA-T146 BUFFER R327 15k R388 22k R395 4.7k R362 10k R334 100k C391 100 16V R314 1k Q306 DTC114EKA MUTE R396 10k C390 470 10V Q399 2SC3624A B1 C396 22 50V R390 10k Q389 DTC114EKA MUTE R284 470k 33 C210 0.1 C209 3300 10V 40 35 36 IC201 TOTX141 L201 JW C201 100 10V C200 0.1 NO711 CD OPTICAL OUT J716 1P JR009 37 34 19 CN201 31P 38 38 HCD-GN700/GX8800 7-10. SCHEMATIC DIAGRAM – MAIN (3/3) Boards – EVER+3.3V STBY RLY DBFB F/B EVER+4V D+3.9V D3.3V M+9V B3 CN402 19P FFC-R 49 29 30 4 73 74 39 SPEANA A+9V R563 10k Q602 FA1L3Z 81 23 GND RT1P137L B+ SWITCH IC904 TA78033LS +3.3V REG M+7V CD-A+3.3V CD-D+3.3V R-IN L-IN HP-L HP-R Q901 C909 0.1 D912 D909 10EDB40 10EDB40 JW912 D910 C903 2200 10EDB40 16V D911 10EDB40 C908 0.1 R902 2.2k C918 0.1 R901 2.7k C919 2200 6.3V R903 2.2k NO901 4P R913 47k D917 1SS355 Q902 DTC114EKA B+ SWITCH C921 100 50V D941 UDZ-TE-17-33B CN901 6P B-TO-B 94 C923 2.2 50V C917 470 10V R908 10k IC903 TA7804LS +3.9V REG JW901 C915 0.1 C920 10 50V Q903 R906 1k 2SB1375 R905 8.2k -33V REG R904 8.2k NO903 7P D915 D914 D913 10EDB4010EDB4010EDB40 C914 470 16V CN902 13P B-TO-B R854 4.7k 75 84 83 IC902 TA7809LS +9V REG C905 0.01 C913 470 16V C912 0.1 C902 2200 25V JW907 D901 C904 D3SBA20-4101 0.01 IC901 TA7809LS +9V REG C901 3300 25V EPT901 GND PLATE C922 2.2 50V IC502 RT8H015C-TH12-1 C911 470 16V C910 0.1 78 JW851 C924 0.1 C906 100 16V R853 18 1W R852 10k Q851 2SB1116 R851 2.2k Q851,852 FAN MOTOR DRIVE C851 0.1 CN851 3P M891 FAN DC B1 Q852 2SC2603 39 39 HCD-GN700/GX8800 7-11. PRINTED WIRING BOARD – GAME IN, CD SWITCH Board – 1 2 3 4 • See page 26 for Circuit Boards Location. 5 6 7 8 9 10 11 12 13 GAME IN BOARD DISPLAY A J631 PHONES C630 C631 VOLUME BOARD EP701 S765 EDIT/ DIRECTION BOARD M (Page 42) S768 AMP MENU S750 DISPLAY S766 FM MODE REPEAT TUNER MEMORY PLAY MODE S767 • Semiconductor Location Ref. No. Location H-12 E-9 D-10 D-10 C-10 C-9 B-9 C-8 C-8 D-8 D-8 E-8 B-11 D-2 E-3 H-11 D-9 D-10 C-9 C-8 D-8 D-8 D748 D1001 D1002 D1003 D1004 D1005 D1006 D1007 D1008 D1009 D1010 D1011 IC603 IC722 Q721 Q748 Q1001 Q1002 Q1003 Q1004 Q1005 Q1006 R775 R776 R766 R767 R774 JW1011 R770 EFFECT ON/OFF S771 R765 V R750 JW1010 JW1009 B V R625 R769 R768 R777 R772 R773 R771 JW608 JW1005 JW605 R1008 R1007 D1008 JW1022 E JW1017 C740 C739 R736 C719 C715 SURROUND SPRAKER MODE JW1013 S759 D1013 S748 VOLUME JW1004 C VOL 4 JW1020 R760 R745 R735 5 8 JW604 C738 D 4 MIC LEVEL 1 R742 R1010 D1010 VOL 10 JW1014 C743 R737 C742 C741 R738 R739 R744 R734 RV722 J721 MIC R761 C737 C744 Q1006 R1011 E E Q1001 R1002 R1001 VOL 2 C748 R743 JW602 JW603 E R746 C747 E JW764 Q721 R721 R740 S760 P.FILE D1011 VOL 11 D1001 VOL 1 S762 GAME EQ 1-686-937S761 ILLUMINATION C718 C717 JW601 11 (11) C749 J601 GAME INPUT R C716 JW609 CLP702 R605 R722 C635 F AUDIO R603 1 L R602 R604 C634 JW610 JW613 C606 J 9 CN606 MAIN BOARD (Page 36) C604 G VIDEO C720 CD SWITCH BOARD CLP704 D748 R788 NO603 R789 R790 S790 S788 S789 S791 R791 R792 S792 E Q748 R749 D748 R748 S749 DISC 3 DISC 2 DISC 1 H R762 CLP703 C750 JW1001 JW1002 IC722 R759 D1009 VOL 9 R1009 E R1003 D1002 R763 Q1005 JW1015 C752 C751 C736 JW607 CN607 C EP703 MAIN BOARD (Page 36) L DISPLAY BOARD (Page 42) OPEN/CLOSE I 1-686-93511 (11) 40 V V S773 PUSH ENTER MOVIE EQ S770 CN605 D1006 VOL 6 MUSIC EQ JW1008 3 2 1 IC603 VOL 7 D1007 VOL 8 Q1003 E R1006 R1005 D1005 VOL 5 C614 S769 D1004 JW1007 C615 Q1004 JW1018 JW1003 Q1002 R1004 JW1019 S763 GROOVE E D1003 VOL 3 JW1016 3 1 2 1-686-936- 11 (11) Z EX-CHANGE DISK SKIP 40 HCD-GN700/GX8800 7-12. SCHEMATIC DIAGRAM – GAME IN, CD SWITCH Board – R792 33k C740 100p C719 2.2 50V RV722 50k R791 22k R790 15k R789 10k R788 6.8k IC722(1/2) NJM4565D C747 2.2 50V R742 1k C742 47p 3 2 R743 10k C748 0.022 C749 0.1 1 4 IC722 MIC AMP R745 100 C741 0.15 50V R736 10k C739 47p 50V R735 180k IC722(2/2) NJM4565D S792 S791 S790 S789 EX-CHANGE DISC SKIP C738 2.2 50V R734 100 OPEN/CLOSE S788 NO603 5P AMP-L J721 6 5 7 8 C744 0.001 R739 100k R738 1k R737 22k C743 470p Q721 2SC2785TP BIAS R721 10k R722 18k J631 C736 10 50V C715 47p C737 10 50V C718 100 10V C717 100 10V D748 SELS5223S RED I/ R748 330 Q748 BA1A4M LED DRIVE R749 270 S749 I/ R746 1k C716 47p J601 3P GAME INPUT VIDEO L AUDIO R R603 1k CLP702 CN607 2P R604 100k R605 100k C606 2.2 50V C604 2.2 50V C634 0.001 C635 0.001 R744 100k R740 2.2k C630 0.001 C631 0.001 CN606 8P EP701 R602 1k EP703 S748 VOLUME ENCODER VOLUME CN605 17P FFC-L IC603 C752 0.1 C751 0.1 C614 0.001 R625 47 C615 47 10V R773 6.8k R774 10k R775 15k R776 22k R777 33k 52 55 54 55 54 53 52 56 57 D1011 SLI-325URT31WT RED D1010 SLI-325URT31WT RED D1009 SLI-325URT31WT RED D1008 SLI-325URT31WT RED D1007 SLI-325URT31WT RED D1006 SLI-325URT31WT RED D1005 SLI-325URT31WT RED D1004 SLI-325URT31WT RED D1002 SLI-325URT31WT RED D1003 SLI-325URT31WT RED D1001 SLI-325URT31WT RED R750 270 R765 470 R766 680 R767 1k R768 1.5k R769 1.5k R770 2.2k R771 3.3k R772 4.7k S773 ROTARY SWITCH S750 R1011 470 R1010 470 R1009 470 53 56 57 R1008 470 R1007 470 R1006 470 R1005 470 R1004 470 R1003 470 R1002 470 R1001 470 C750 0.1 S766 S765 S767 S768 S769 S770 S771 CLP703 WIRE Q1006 BA1A4M Q1005 BA1A4M Q1004 BA1A4M Q1003 BA1A4M Q1002 BA1A4M Q1001 BA1A4M R759 6.8k R760 10k R761 15k R762 22k R763 33k Q1001-1006 LED DRIVE S759 S760 S761 S762 S763 41 41 HCD-GN700/GX8800 7-13. PRINTED WIRING BOARD – DISPLAY Board – 1 2 3 • See page 26 for Circuit Boards Location. 4 5 6 7 8 9 10 C653 FL601 A DISPLAY BOARD C652 R645 NO602 JW753 R817 R818 R819 R820 R821 E E D610 R646 R647 C651 R752 C711 C710 C618 C620 Q808 L602 1 100 JW747 Q807 JW763 Q602 D604 E S787 B L CD SWITCH BOARD (Page 40) CLP701 R751 IC C619 Y2 Y1 R660 JW749 81 80 R807 hh R753 R808 JW751 R657 60 X601 JW748 1 S751 JW746 C623 L601 R754 S752 30 31 D605 JW762 JW744 JW745 JW743 JW742 R626 R627 S786 CD R787 x C R755 R756 R757 S753 JW752 JW750 JW758 JW736 JW737 JW738 JW739 JW740 C622 50 51 R661 JW729 R662 JW733 JW732 JW735 JW734 C712 C628 C627 C626 C625 C624 JW741 Q603 R112 TUNER/BAND R105 R110 C106 R109 R108 C107 C109 D102 D606 E S785 R628 R786 R107 R111 R113 R117 R119 R123 R125 X C121 JW726 C105 5 8 C104 R106 TAPE A/B R663 JW727 R658 R659 JW728 S755 > ,+ S754 –, > D105 D JW754 JW724 JW725 JW720 JW721 JW722 JW760 JW723 R128 JW731 JW730 C110 IC101 4 R102 R104 R103 D603 R629 Q604 E S784 R785 1 C101 R133 C102 D101 R132 R129 R130 JW761 R653 R652 R655 R656 JW718 D100 R822 R823 JW719 S756 JW713 M ,ALBUM+ S757 M ,ALBUM– C123 R127 R139 R136 C115 E Q100 R138 C120 MD(VIDEO) D602 R630 C122 S783 R654 R140 R137 JW108 JW107 JW106 C118 C124 R134 JW113 JW105 JW104 JW103 C152 C153 D103 CN601 D107 JW717 JW109 C100 C157 C156 C155 CN604 C154 R131 JW710 JW709 JW112 GAME D104 JW714 D106 JW712 JW755 R118 S779 CD SYNC JW759 R124 MAIN BOARD (Page 36) I JW708 JW707 JW706 JW705 JW704 JW101 E • Semiconductor Location Ref. No. Location D-6 D-8 C-8 E-8 E-8 D-6 E-4 E-4 F-2 E-9 D-9 B-9 C-9 C-9 A-2 D-7 F-9 B-5 D-6 G-2 B-9 C-9 D-9 F-2 F-2 G-2 B-7 B-7 D100 D101 D102 D103 D104 D105 D106 D107 D601 D602 D603 D604 D605 D606 D610 IC101 IC102 IC601 R784 R758 C125 JW715 JW716 C114 R779 R781 JW102 E Q605 R122 C116 JW703 R121 R120 C117 S782 R670 JW702 F JW756 JW757 D601 REC PAUSE/START S758 E Q606 M VOLUME BOARD (Page 40) GAME MIXING R631 JW701 R637 5 8 R636 4 IC102 R116 C111 C112 JW700 E Q601 R634 R635 R633 R632 1 R114 R115 G E Q707 R782 C119 R783 1-686-934- 11 (11) Q100 Q601 Q602 Q603 Q604 Q605 Q606 Q707 Q807 Q808 42 42 HCD-GN700/GX8800 7-14. SCHEMATIC DIAGRAM – DISPLAY Board – • See page 53 for Pin Function Description. FL601 FLUORESCENT INDICATOR TUBE 120 180 180 R819 R818 R817 R820 180 R821 120 100 99 98 96 97 95 92 91 90 89 88 43 25 28 26 31 29 34 32 37 35 38 45 46 44 41 40 39 36 33 30 27 24 22 21 20 19 18 17 16 15 14 13 12 10 Q807 BA1L3Z BUFFER 93 C711 0.01 L602 JW C710 0.01 9 8 87 C651 0.1 C652 10 50V C653 10 50V 4 7 5 6 3 2 1 R646 100 R645 10k R647 100 D610 MTZJ-T-72-5.1B 24 21 20 30 28 17 25 19 27 26 22 18 16 15 14 13 12 Q808 BA1L3Z BUFFER 29 10 9 4 5 8 94 7 6 3 2 1 R808 100k R807 100k R114 1.5k IC102(1/2) NJM4565D C112 0.022 R116 47k C111 0.022 R115 1.5k 77 61 R103 1.5k IC101(1/2) NJM4565D 60 31 32 33 34 35 36 37 38 C622 4.7 50V 39 40 41 43 44 45 46 48 IC601 MB90M407PF-G-124 -BND DISPLAY CONTROL, KEY CONTROL 100 99 98 97 96 95 94 93 92 91 90 89 88 87 C620 0.01 X601 4MHz C619 47 10V R132 100k R109 1.5k R133 100k R102 1.5k C101 0.47 C102 0.47 R104 47k CN601 19P FFC-S R131 100k IC101(2/2) NJM4565D R121 1.5k R134 100k IC102(2/2) NJM4565D D107 10EDB40 R108 1.5k C106 0.1 R110 47k R120 1.5k C116 0.0033 R122 47k C117 0.0033 48 D106 10EDB40 C107 0.1 NO602 5P AMP-L R662 10k R660 1M C618 0.01 C104 10 50V C109 10 50V C114 10 50V C119 10 50V D105 1SS133T-72 R127 220 C118 10 50V D101 1SS133T-72 D102 1SS133T-72 D103 1SS133T-72 R663 10k D100 MTZJ-T-72-3.3B 71 68 65 66 66 69 70 72 67 73 R661 10k R653 10k R654 100 R106 100k R112 100k D104 1SS133T-72 L601 JW R118 100k R124 100k R138 1k Q100 2SC3623 BUFFER R136 68k C100 10 50V 56 57 53 58 55 49 59 51 54 60 52 61 R822 1k R823 1k R105 680 R107 100k R111 680 R113 100k R117 680 R119 100k R123 680 R125 100k R128 470k C124 10 50V R139 330 C123 100 10V R137 22k C122 100 6.3V R130 4.7k 100 100 77 79 0.01 0.01 0.01 0.01 0.01 15k 15k 15k 80 R658 R657 R659 C624 C625 C626 C627 C628 C623 0.001 C105 0.22 50V C110 0.22 50V R655 C115 0.22 50V R656 C120 0.22 50V C121 4.7 50V 70 68 Q605 2SB1116 SWITCH Q606 2SB1116 SWITCH 69 67 71 C712 0.01 R652 10k R140 100 R129 4.7k REC PAUSE/START R670 JW 64 S755 + R787 4.7k R786 3.3k R785 2.2k R784 1.5k R783 1.5k R782 1k R781 680 R779 470 R751 470 R752 680 R753 1k R754 1.5k R755 1.5k R756 2.2k S757 R636 10k R632 680 R637 10k R633 680 ALBUM R757 3.3k R758 4.7k R635 10k D602 SEL5923A AMBER D603 SEL5923A AMBER D606 SEL5923A AMBER D605 SEL5923A AMBER D604 SEL5923A AMBER D601 SLR325VC RED R634 10k R630 330 CN604 17P FFC-L 80 79 65 57 56 55 54 53 52 C157 C156 C155 C154 C153 C152 220p 220p 220p 220p 220p 220p S787 S786 S785 S784 S783 S782 S779 S751 S752 S753 ALBUM + S754 S756 S758 REC PAUSE/START 72 Q707 BA1A4M INV. Q601 BA1A4M INV. Q604 BA1A4M R629 330 R628 330 R627 330 R626 330 R631 680 Q603 BA1A4M Q602 BA1A4M 59 Q602-604 LED DRIVE C125 0.1 50V 64 43 43 58 73 HCD-GN700/GX8800 7-15. PRINTED WIRING BOARDS – POWER AMP Boards – 1 2 3 • See page 26 for Circuit Boards Location. 4 5 6 FRONT SPEAKER (IMPEDANCE USE 6–16Ω) 7 SURROUND SPEAKER TM501 (IMPEDANCE USE 24Ω) 8 A R L R L + - + - + - + - POWER AMP BOARD EP502 JW886 JW887 R533 R578 R532 R531 JW877 R523 E Q518 E Q514 JW900 R577 R522 Q506 Q505 R521 JW874 R559 C526 C558 JW880 JW881 C557 E E R547 JW899 JW878 JW876 JW875 D507 D511 R509 R548 JW882 C508 C524 C523 C527 JW894 RY501 JW893 PL003 JW884 JW885 B C507 JW879 JW890 JW891 D506 C PL010 R539 RY502 D510 EP501 JW897 JW898 D502 JW827 JW826 JW927 TH501 R530 C553 R553 IC501 TH502 R540 C509 D503 D504 JW845 R511 R518 R528 R529 JW828 JW829 D JW820 JW821 JW822 JW823 JW824 JW832 JW833 C503 JW830 JW831 C551 JW834 R552 C502 JW810 R502 R501 JW811 JW812 C501 D551 D501 JW836 C504 R508 C554 JW846 R551 C552 R558 D C512 R512 JW847 JW848 JW849 JW850 JW851 MAIN BOARD (Page 36) JW857 JW853 JW854 JW855 R554 R504 R503 JW852 R527 CN504 JW856 C513 R505 JW835 R555 R556 E Q551 E R524 R520 JW861 JW862 JW860 JW859 • Semiconductor Location Ref. No. D501 D502 D503 D504 D506 D507 D508 D509 D510 D511 D541 D543 D551 D581 IC501 Q501 Q503 Q504 Q505 Q506 Q510 Q511 Q513 Q514 Q515 Q516 Q517 Q518 Q551 Q581 Location E-3 D-2 D-4 D-5 C-7 B-5 H-2 H-2 C-8 B-5 G-3 H-4 E-3 F-2 D-4 E-4 G-2 F-2 B-2 B-2 F-6 F-6 H-6 B-2 H-6 H-5 H-5 B-2 E-4 F-2 JW813 JW814 JW837 MAIN BOARD (Page 36) CN503 E Q501 JW863 R507 JW809 E JW808 R516 Q504 R517 R515 E JW819 JW818 JW817 JW816 JW815 R506 R557 JW839 JW842 JW838 JW841 JW840 JW844 JW843 JW864 JW865 JW866 JW867 JW869 JW868 C592 C542 Q511 E R545 JW858 Q581 E C559 JW807 JW806 JW805 JW804 R519 C581 R581 R582 D581 R514 Q503 JW796 F R513 JW797 R561 JW798 JW799 R546 R591 JW801 JW800 JW870 JW803 JW802 R541 JW873 C596 C546 PL005 JW871 C517 E Q510 C516 JW795 D541 – JW926 G JW792 JW791 C541 JW794 JW793 E JW783 NO502 + JW789 R565 D509 D508 R564 C591 1 R592 JW788 JW787 R542 JW782 JW781 – D543 + Q517 R570 R569 JW896 R568 JW780 E E Q515 R567 E Q516 R571 Q513 R566 R573 JW790 C544 JW786 H 6 PL006 C545 JW785 PL007 R572 1-686-932- 11 (11) O TRANS BOARD (Page 46) 44 44 HCD-GN700/GX8800 7-16. SCHEMATIC DIAGRAM – POWER AMP Boards – C509 22 100V R511 100 1/4W FR R520 3.3k 1W D504 MTZJ-T-72-18C *1 R539,540 560/2W 680/2W GN700 GX8800 Q503 2SA988TP-PAFAEA STANDBY SWITCH R514 2.2k R508 0.1 5W R501 1k C501 4.7 50V JW884 C503 220p IC501(1/2) STK412-150 POWER AMP R513 33k R515 22k R505 820 Q517 2SA1175TP-HFE FRONT SPEAKER RELAY DRIVE RY501 RELAY 24V JW566 R CH + R TM501 8P FRONT SPEAKER (IMPEDANCE USE 6-16Ω) JW567 R547 47k D506 1SS133T Q511 2SC2785 RELAY SWITCH D507 1SS133T R548 47k D511 1SS133T C524 0.01 25V C523 0.01 25V R GND – R503 330 C502 1000p R502 47k C554 100 10V C581 22 50V R519 68k D501 1SS133T -72 C504 100 10V Q581 2SC1841 STANDBY SWITCH R582 33k R581 33k D581 1SS133T-72 Q504 2SC1841 STANDBY SWITCH R506 33k Q501 2SC1841 OVER LOAD DETECT R507 100k R569 47k R545 1k JW885 R504 47k C507 0.068 R527 56k R570 10k R528 R529 47k 22k R530 22k R539 *1 L CH + L L GND – REAR R-CH JW890 + R R517 10k C508 0.068 R509 10 1/2W Q516 2SC2785 FRONT SPEAKER RELAY DRIVE REAR R GND – C516 100 10V R572 100k Q510 2SC2785 OVER LOAD DETECT SWITCH R568 10k C517 10 50V JW891 R546 22k EP501 TERMINAL, EARTH RY502 REAR L-CH JW886 – + L SURROUND SPEAKER (IMPEDANCE USE 24Ω) JW887 Q515 2SA1175TP-HFE SURROUND SPEAKER PROTECT RELAY DRIVE C527 0.01 25V R552 47k C559 22 100V R512 1 1/4W FR D551 1SS133T-72 R524 3.3k 1W R516 10k R557 100k C552 1000p R553 330 R561 100 1/4W FR R518 33k Q551 2SC1841 OVER LOAD DETECT R540 *1 D510 1SS133T D509 1SS133T C513 0.01 JW871 D508 1SS133T R556 33k Q505,506,514 TEMPERATURE DETECT SWITCH R554 47k R559 10 1/2W R558 0.1 5W R521 100k Q505 2SC2785 D543 D5SBA20 R531 330k R532 100k Q514 2SC2785 Q518 2SC2785 FAN MOTOR ON SWITCH R578 560k R567 10k R555 820 C545 0.1 100V R565 22k R564 22k C541 0.1 C558 0.068 R523 100k D503 MTZJ-T-72-18C R522 100k D541 D5SBA204101 R CH L CH C553 220p IC501(2/2) STK412-150 POWER AMP C557 0.068 R542 100k R577 100 Q506 2SC2785 R541 100k C542 3300 50V C544 0.1 100V R592 100k NO502 VH VH R533 47k TH502 TH501 C526 10 50V C546 2200 100V R551 1k C551 4.7 50V EP502 EARTH D502 1SS133T C596 2200 100V VL C592 3300 50V C591 0.1 VL (Page 47) R571 47k R591 100k JW926 C512 0.01 R566 10k Q513 2SC2785 SURROUND SPEAKER PROTECT RELAY DRIVE JW927 R573 100k CN503 13P CN504 6P 45 45 HCD-GN700/GX8800 7-17. PRINTED WIRING BOARDS – TRANS Board – • See page 26 for Circuit Boards Location. 3 4 1 2 5 MAIN BOARD (Page 36) 6 7 AC IN F PL004 1 4 A SUB TRANS BOARD PL001 CN974 2 D971 RY971 Q971 JW920 CN976 C973 IC971 1 3 C975 GN700 C978 • Semiconductor Location Ref. No. D971 D972 D973 D974 D975 D977 IC971 Q971 Location B-4 B-6 B-6 C-6 C-6 D-3 A-5 B-4 R975 GN8800 B GX8800 JW925 1 CN971 C971 GN700 JW921 4 1 E R974 S901 VOLTAGE SELECTOR 120V t 220V t 230-240V GX8800 T972 C977 D972 D973 JW923 C976 D975 D974 JW924 C B100 1-686-931- 11 (11) TRANS BOARD C941 * NOT REPLACEABLE: BUILT IN TRANSFORMER T910 POWER TRANSFORMER PL008 D JW928 CN998 1 JW929 D977 R941 * R952 GN700 GX8800 MAIN BOARD (Page 36) E H 7 1 2 JW912 JW911 GN700 F978 3 4 NO973 JW913 GN700 1 POWER AMP BOARD (Page 44) F975 F977 F974 JW907 JW906 O 6 CN997 JW909 JW908 PL009 F F976 PL002 1-686-930- 11 (11) 46 46 HCD-GN700/GX8800 7-18. SCHEMATIC DIAGRAM – TRANS Board – JW910 *2 F976,977 8A/125V T8AL/250V GX8800 GN700 *1 F974,975 6.3A/125V T6.3AL/250V GX8800 GN700 R954 3.3M 1/2W GX8800 *2 NO973 4P GN700 GX8800 2P JW912 T910 POWER TRANSFORMER GN700 NO973 GN700 GN700 CN997 F977 *2 F976 *2 JW911 GX8800 F974 *1 F975 *1 * * JW913 NOT REPLACEABLE: GX8800 F978 *3 *3 F978 4A/125V T4AL/250V GX8800 GN700 C941 100 63V BUILT IN TRANSFORMER R952 0.15 1/4W JW928 D977 11ES2 JW929 R941 1 CN998 GN700 GN700 GX8800 GX8800 JW925 CN971 *3 GX8800 *3 CN971 4P 2P GN700 GX8800 S901 VOLTAGE SELECTOR 120V GX8800 Q971 2SC2785 POWER ON/OFF RELAY DRIVE CN976 R975 10k IC971 TA7804LS +3.9V REG D973 11ES2 D972 11ES2 T972 JW923 JW924 220V 230-240V GN700 RY971 C971 10000p R974 100k C973 100 16V D975 11ES2 D974 11ES2 D971 1SS133T C978 0.1 AC IN C975 2200 16V C977 0.1 C976 0.1 JW920 CN974 2P VH 47 47 HCD-GN700/GX8800 7-19. IC Block Diagrams IC103 CXA2647N-T4 (CD BOARD) IC101 CXD3068Q (CD BOARD) XTAI XTAO XTSL V16M VPCO VCTL XUGF GFS EMPH WFCK WDCK C2PO LRCK PCMD BCK MUTE IC701 IC712 BA6956AN (DRIVER BOARD) BA6956AN (DRIVER BOARD) RW/ROM 30 DC OFST 29 RFDCI + – DVC VCC VC VC + – DVC VOFST RW/ROM 27 VC EQ PD 2 APC AMP RFAC VCA VCC B C A A A B C D 6 7 8 9 A B C D B C D D DVC VC RW/ROM RW/ROM 19 TE BAL VOFST + – + – VC SW 12 DVCC 13 B DVC DVC 14 D A C DVC VC RW/ROM RFAC 15 VOFST + – + – 17 FEI APC-OFF (Hi-Z) RW/ROM (H/L) RW/ROM RW/ROM + – DVC EQ ON/OFF EQ IN 3 RW/ROM AC SUM 4 RFAC SUMMING AMP 23 RFG 22 VCC 21 CEI + – 28 RFDCO FSTO CAM A B C D ERROR CORRECTOR CLOCK GENERATOR EFM DEMODURATOR ASYMMETRY CORRECTOR D/A INTERFACE TES1 TEST XRST TSD RFAC ASYI ASYO ASYE BIAS 32K RAM DIGITAL OUT MD2 DOUT CONTROL LOGIC VC LD 1 26 RFC 25 VFC 24 BST XPCK FILO FILI PCO CLTV MDP LOCK PWMI SENS DATA XLAT CLOK SCOR SBSO EXCK SCSY SQSO SQCK RNF VM VCC VREF FIN GND OUT2 DIGITAL CLV CPU INTERFACE SERVO AUTO INTERFACE SERVO BLOCK GND 5 20 CE SERVO INTERFACE SOUT SOCK XOLT SCLK COUT SSTP ATSK MIRR DFCT FOK MIRR DFCT FOK E 10 GM 18 TE F 11 GM RFDC CE TE SE FE VC IGEN SERVO DSP FOCUS SERVO OPAMP A/D ANALOG SW CONVERTER TRACKING SERVO SLED SERVO PWM GENERATOR FOCUS PWM GENERATOR TRACKING PWM GENERATOR SLED PWM GENERATOR FFDR FRDR TFDR TRDR SFDR SRDR IC150 PRFVCC BA5974FM-E2 (CD BOARD) CH3OUTR CH4OUTR CH3OUTF CH4OUTF POWVCC CAPAIN3 CH4SIN' CH3RIN CH4BIN CH4SIN CH3FIN MUTE GND 16 FE 28 27 ADIO 26 25 24 23 22 21 20 19 18 17 OUT1 16 15 F R R MUTE INTERFACE F LEVEL SHIFT F INTERFACE F R R INTERFACE F R R F THERMAL SHUTDOWN 1 VREFOUT 2 CH1FIN 3 CH1RIN 4 CAPAIN1 5 CH2FIN 6 CH2RIN 7 CAPAIN2 8 GND 9 VREFIN 10 POWVCC 11 CH2OUTR 12 CH2OUTF 13 CH1OUTR 14 CH1OUTF 48 48 RIN DIGITAL PLL 1 SUB CODE PROCESSOR 2 3 4 5 6 7 8 9 HCD-GN700/GX8800 7-20. Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 IC Pin Function Description Pin Name RESET MIMD MICS/AD0 MILP/AD1 MIDIO MICK MIACK/AD2 VDDT SDO BCKO/AD3 LRCKO/AD4 SDI0 BCKIA LRCKIA SDI1/AD5 BCKIB/CE LRCKIB/OE VDD STANDBY VSS VSSL VRAL LO VDAL VDAR RO VRAR VSSR TESTP CSK I/O I I I I I/O I O – O O O I I I I I I – I – – – O – – O – – I O O – O O O O – I – I I – I – I I – I Reset input terminal “L”: reset Microcomputer interface mode selection input “H”: I2C, “L”: TSB (fixed at “L”) Microcomputer interface chip select signal input Microcomputer interface latch pulse input Serial data input/output Serial clock input Microcomputer interface acknowledge signal output Power supply (3.3V) for digital circuit Data output (open) Bit output (open) LR clock output (open) Data input 0 Bit clock input A LR clock input A Data input 1 (fixed at “L”) Bit clock input B (fixed at “L”) LR clock input B (fixed at “L”) Power supply (2.5V) for digital circuit Standby mode control signal input “H”: STB, “L”: normal (fixed at “H”) Ground for digital circuit Ground for DAC Lch Reference voltage terminal for DAC Lch DAC Lch signal output Power supply (2.5V) for DAC Lch Power supply (2.5V) for DAC Rch DAC Rch signal output Reference voltage terminal for DAC Rch Ground for DAC Rch Terminal for test “H”: test mode, “L”: normal (fixed at “L”) SPDIF signal output (open) General purpose output (open) Power supply (3.3V) for digital circuit General purpose output (open) General purpose output (open) General purpose output (open) Interrupt request signal output to the system control Ground for digital circuit External interrupt signal input (fixed at “L”) Power supply (2.5V) for the internal 1Mbit SRAM Flag signal input 0 (fixed at “L”) Flag signal input 1 (fixed at “L”) Ground for the internal 1Mbit SRAM General purpose input (fixed at “L”) Ground for digital circuit General purpose input (fixed at “L”) General purpose input (fixed at “L”) Power supply (2.5V) for digital circuit General purpose input/SUBQ interface data input (fixed at “L”) Description • IC104 CXD9717R-008 D/A Converter, MP3 Decoder (CD Board) 31 to 34 PO0/AD12 to PO3/AD09 35 36 37 38 39 40 41 42 43 44 45 46, 47 48 49, 50 51 52 53 VDDT PO4/AD8 PO5/AD7 PO6/AD6 PO7 VSS FI0/AD13 FI1/AD14/VDDM FI2/WR FI3/AD16 VSSM PI0, PI1 VSS PI2/IO2, PI3/IO3 PI4/IO4 VDD PI5/IO5 49 HCD-GN700/GX8800 Pin No. 54 55 56 57 58 59 60 61 62 63 64 Pin Name BOOT/IO6 TXO/IO7 VSSP PDO VCOI VDDP CKO VDDX XI XO VSSX I/O I I – O I – O – I O – Description Terminal for test/SUBQ interface frame sync input (fixed at “L”) Flag signal input 2/SUBQ interface block sync input (fixed at “L”) Ground for VCO circuit PLL phase error detection signal output VCO control voltage input Power supply (2.5V) for VCO circuit External clock output Power supply (2.5V) for oscillation circuit Resonator terminal (input) Resonator terminal (output) Ground for oscillation circuit 50 HCD-GN700/GX8800 • IC501 M30622MGN-B14FP SYSTEM CONTOL (MAIN Board) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 Pin Name MP3 CS MP3 LP MP3 ACK SIRCS MP3 DATA OUT MP3 DATA IN MP3 CLK BYTE CNVSS XC-IN XC-OUT RESET X-OUT VSS X-IN VCC NMI MP3 REQ SCOR AC-CUT E-1 E-2 CD-POWER BU-PWM3 CD-A-MUTE BU-PWM2 STBY-RELEY BU-PWM1 IIC-CLK IIC-DATA TXD1 SQ-DATA SQ-CLK SENS CD-DATA XLAT CD-CLK LD-ON STBY-LED XRST TBL-SENS EJECTSW E-3 TM-F TM-R LMF LMR MP3 RESET GC-RESET HP DETECT ––––––––––––––––––––– I/O O O I I O I O I — I O I O — I — I I I I I I O O O O O O I I — I O I O O O O O O I I I O O O O O O I O O O MP3 chip select signal output MP3 latch pules output MP3 acknowledge signal input SIRCS input Serial data output Serial data input Serial clock output Not used (connected to ground) Description Not used (Connected to ground with resistor) Sub clock input Sub clock output System reset input Main system clock output (16MHz) Ground Main system clock input (16MHz) Power supply (+5V) Not used (Pull up with resistor) Interrupt request signal input Subcode sync (S0+S1) detection signal input AC cut check signal input Disc tray status detection signal input Disc tray status detection signal input CD power on/off signal output BU PWM 3 (for CD-RW) signal output CD mute signal output BU PWM 2 (for CD-RW) signal output Reley drive signal output BU PWM 1 (for CD-RW) signal output IIC serial data clock input IIC serial data input Not used Subcode Q data input Subcode Q data reading clock signal output SENS signal input from CXD3068Q CD data output CD latch signal output CD data clock output Laser diode control signal output Standby LED drive signal output CD reset signal output Table sensor signal input Eject switch signal input Disc tray status detection signal input Table motor control signal output Table motor control signal output Loading motor control signal output Loading motor control signal output MP3 reset signal output GC reset signal output Headphone detect input REC mute signal output TC line mute signal output TC A/B select signal output REC-MUTE PB-A/B TC-MUTE 51 HCD-GN700/GX8800 Pin No. 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 Pin Name ALC TC-RELAY REC BIAS CAPM-CONT B-TRIG A-TRIG B-REC, REV B-PLAY VCC –––––––––––––– I/O O O O O O O O I — I — I O I I O O O O I I O O O I O O I O O O I I O O I I I I I I I — O I — O Discription ALC signal output REC/PB selection signal output Bias on/off signal output Capstan motor REV/FWD/STOP control signal output TCM-B Trigger output TCM-A trigger output Record tab switch for SIDE B signal output TCM-B play switch input Power supply (+3.3V) AMS signal input Ground Tuner data input Record tab switch for SIDE A signal output A deck half detection signal input TCM-A play switch input Subwoofer LED drive signal output (open) Subwoofer LED drive signal output (open) Subwoofer LED drive signal output (open) Subwoofer LED drive signal output (open) DISPLAY key signal input Power key signal input Mute signal output to power IC Headphone mute signal output TA LINE mute signal output Speaker protection signal input Serial data output to Audio EQIC Serial data clock output to Audio EQIC VACS signal input Subwoofer relay control signal output (open) Front speaker relay driver signal output Surround speaker relay driver signal output Stereo signal input Tuned signal input Tuner chip enable signal output Tuner data output TCM-A reel pulse input TCM-B reel pulse input B deck half detection input Model input Destination input Over-voltage protection detection input termnal Subwoofer key signal input (open) Ground Tuner clock signal output Reference voltage input Power supply (+3.3V) Tuner mute signal output AMS-IN VSS ST-DIN A-REC, FWD A-HALF A-PLAY LED-SW-LINK LED-SW-ON LED-MATRIX-SURR-2 LED-MATRIX-SURR-1 KEY-DISPLAY POWER-KEY STK-MUTE –––––––––––––––––– HP-MUTE PROTECT LINE-MUTE –––––––––––––––––– AUDIO-DATA AUDIO-CLK –––––––––––––––– VACS IN SW-RELAY FRONT-RELAY LINK-RELAY STEREO –––––––––––––– ––––––––––––––– TUNED ST-CE ST-DOUT A-SHUT B-SHUT B-HALF MODEL-IN DEST-IN I-HOLD SW-AD-KEY AVSS ST-CLK VREF AVCC ST-MUTE 52 HCD-GN700/GX8800 • IC601 MB90M407APF-G-124-BND DISPLAY CONTROL (DISPLAY Board) Pin No. 1 to 7 8 to 10 11 12 to 22 23 24 to 41 42 43 to 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 to 66 67 to 70 71 72 73 74 to 76 77 78 79 80 81 82 83 84 85, 86 87 to 100 Pin Name G7 to G1 P1 to P3 VSS-IO P4 to P14 VDD-FIP P15 to P32 VSS-IO P32 to P36 NO USED VKK MD0 MD1/VDD-VFT MD2 VOLUME5,6 LED VOLUME7,8 LED VOLUME9,10 LED VOLUME11,MULTI CH LED VOLUME3,4 LED VOLUME1,2 LED TAPE A/B,TUNER LED GAME,MD/VIDEO LED I2C-DATA I2C-CLOCK AVCC AVSS KEY0 to KEY2 BPF3 to BPF0 ALL BAND SELECTOR CD/DVD, REC/PAUSE LED NO USE RESET SOFT TEST VOL 1B VOL 1A VSS-CPU XOUT XIN VCC-CPU NO USE G21 to G8 I/O O O — O — O — O O — I I I O O O O O O O O O O — — I I I O O O I O I I — O I — — O FLD grid output FLD segment output Ground FLD segment output Power supply (+3.3V) FLD segment output Ground FLD segment output Not used Power supply (-35V) Not used (pull up with resistor) Not used (pull up with resistor) Not used (pull down with resistor) LED drive signal output LED drive signal output LED drive signal output LED drive signal output LED drive signal output LED drive signal output LED drive signal output LED drive signal output IIC serial data output IIC clock signal output Power supply (+3.3V) Ground Key input (A/D port) Spectrum analyzer BPF signal input L+R signal input LED group select signal output LED drive signal output Not used Reset input Not used (open) Volume encoder signal B input Volume encoder signal A input Ground Crystal oscillator output (4MHz) Crystal oscillator input (4MHz) Power supply (+3.3V) Not used FLD grid output Description 53 HCD-GN700/GX8800 SECTION 8 EXPLODED VIEWS • Abbreviation AR : Argentine model E2 : 120 V AC Area in E model E3 : 240 V AC Area in E model E51 : Chiri and Peru model MX : Mexican model The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • Accessories are given in the last of the electrical parts list. 8-1. CASE, REAR PANEL SECTION 3 #2 not supplied #2 #1 M891 #2 5 6 2 #2 #1 2 #1 #2 1 #2 #1 #1 #1 4 not supplied #1 #1 not supplied #1 #1 Ref. No. 1 1 2 3 4 4 Part No. 4-244-102-11 4-244-102-31 3-363-099-41 4-231-828-31 A-4731-346-A Description #1 Remark Ref. No. 5 6 6 M891 #1 #2 Part No. 1-920-838-32 1-693-603-11 1-693-623-11 1-763-072-11 Description WIRE (FLAT TYPE) (11 CORE) TUNER (FM/AM) (GN700) TUNER (FM/AM) (GX8800) FAN, DC Remark LOADING (PANEL) (GN700) LOADING (PANEL) (GX8800) SCREW (CASE 3 TP2) CASE SUB TRANS BOARD, COMPLETE (GN700) A-4733-069-A SUB TRANS BOARD, COMPLETE (GX8800) 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S 7-685-871-09 SCREW +BVTT 3X6 (S) 54 HCD-GN700/GX8800 8-2. FRONT PANEL SECTION 51 62 80 68 62 80 64 63 69 not supplied 70 62 67 62 71 65 80 66 64 72 62 FL601 62 61 73 60 79 76 supplied with S748 77 78 75 62 59 not supplied 58 52 62 #4 53 not supplied #4 62 57 56 55 54 74 62 Ref. No. 51 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 Part No. X-4955-229-1 X-4955-554-1 4-225-252-01 4-244-075-01 4-244-093-01 4-244-072-01 4-244-073-01 4-244-090-01 4-244-074-01 4-224-578-21 4-244-097-01 4-244-089-11 4-951-620-01 4-963-404-21 4-224-104-11 Description FRONT PANEL ASSY (GN700) FRONT PANEL ASSY (GX8800) CUSHION (FOOT) HOLDER (TC-R) SPRING (LID) LID (TC) WINDOW (TC) COVER (AL-TC) HOLDER (TC-L) KNOB (MIC) KNOB (VOL) COVER (AL-STR) SCREW (2.6X8), +BVTP EMBLEM (5-A), SONY DAMPER Remark Ref. No. 67 68 69 70 71 71 72 73 74 75 76 77 78 79 80 FL601 #4 Part No. Description Remark 1-686-936-11 CD SWITCH BOARD A-4731-329-A VOLUME BOARD, COMPLETE 4-244-096-01 KNOB (CURSOR) 1-773-040-11 A-4731-330-A A-4733-055-A 4-231-581-01 1-773-110-11 A-4731-327-A 1-796-487-31 4-243-609-01 4-243-610-01 4-243-608-01 1-751-688-11 3-378-434-01 1-518-862-11 7-685-781-09 WIRE (FLAT TYPE) (17 CORE) DISPLAY BOARD, COMPLETED (GN700) DISPLAY BOARD, COMPLETE(GX8800) HOLDER (FL) WIRE (FLAT TYPE) (19 CORE) GAME IN BOARD, COMPLETE DECK, MECHANICAL BELT (AF) BELT (AL) BELT (BR) WIRE (FLAT TYPE) (13 CORE) CUSHION, SARANET INDICATOR TUBE, FLUORESCENT SCREW +PTT 2X4 (S) 4-244-094-01 SPRING (L) 4-244-095-01 SPRING (R) 55 HCD-GN700/GX8800 8-3. CHASSIS SECTION not supplied not supplied #1 #5 101 #5 #1 F974 T910 #1 #1 103 #3 F978 F975 F976 F977 107 104 108 105 109 not supplied The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 106 not supplied #1 #1 Ref. No. 101 0 103 0 103 0 103 0 103 * 104 104 105 105 105 106 107 107 108 * 109 0 F974 0 F974 Part No. 1-686-930-11 1-777-071-53 1-783-531-31 1-783-941-12 1-791-901-12 Description TRANS BOARD CORD, POWER (GN700:E51) CORD, POWER (GX8800) CORD, POWER (GN700:AR) CORD, POWER (GN700:E2,E3,MX) Remark Ref. No. 0 F975 0 F975 0 F976 Part No. Description Remark 1-533-454-11 FUSE, GLASS TUBE (DIA. 5) (6.3A 125V) (GX8800) 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V) (GN700) 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (8A 125V) (GX8800) 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (T8AL 250) (GN700) 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (8A 125V) (GX8800) 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (T8AL 250) (GN700) 1-533-452-11 FUSE, GLASS TUBE (DIA. 5) (4A 125V) (GX8800) 1-533-471-11 FUSE, GLASS TUBE (DIA. 5) (T4AL 250V) (GN700) 1-439-555-11 1-439-617-11 7-685-647-79 7-685-650-79 7-685-881-09 POWER TRANSFORMER (GN700) POWER TRANSFORMER (GX8800) SCREW +BVTP 3X10 TYPE2 N-S SCREW +BVTP 3X16 TYPE2 IT-3 SCREW +BVTT 4X8 (S) 3-703-244-00 BUSHING (2104), CORD (GN700:AR,E51,MX,GX8800) 3-703-571-11 BUSHING (S) (4516), CORD (GN700:E2,E3) A-4731-356-A MAIN BOARD, COMPLETE (GN700:AR,E2,E51,MX) A-4733-061-A MAIN BOARD, COMPLETE (GN700:E3) A-4733-066-A MAIN BOARD, COMPLETE (GX8800) 4-225-252-01 A-4731-361-A A-4733-071-A 4-943-687-01 4-988-533-01 CUSHION (FOOT) POWER AMP BOARD, COMPLETE (GN700) POWER AMP BOARD, COMPLETE (GX8800) HOLDER, PC BOARD HOLDER, PWB 0 F976 0 F977 0 F977 0 F978 0 F978 1-533-454-11 FUSE, GLASS TUBE (DIA. 5) (6.3A 125V) (GX8800) 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V) (GN700) 0 T910 0 T910 #1 #3 #5 56 HCD-GN700/GX8800 8-4. CD MECHANISM DECK SECTION-1 (CDM74-K6BD47S) 156 162 158 157 156 155 155 156 158 157 151 159 161 164 160 164 165 163 M741 154 153 152 chassis assy 151 Ref. No. 151 152 153 154 155 156 157 158 159 Part No. 4-218-253-21 1-776-182-11 1-687-134-11 4-243-815-01 4-245-571-01 4-218-252-61 4-245-570-01 4-245-572-01 1-687-132-11 Description SCREW (M2.6), +BTTP WIRE (FLAT TYPE) (5 CORE) MOTOR (TB) BOARD TABLE (LOADING) GEAR (STOPPER) SCREW (+PTPWH M2.6), FLOATING GEAR (JOINT) BUSHING (GEAR) SENSOR BOARD Remark Ref. No. 160 161 162 163 164 165 M741 Part No. Description Remark 4-243-820-01 GEAR (TABLE) 4-243-819-01 4-243-816-01 4-243-823-01 4-985-672-01 4-243-821-01 GEAR (GENEVA) TRAY BELT (TABLE) SCREW (+PTPWH M2.6), FLOATING PULLEY (TABLE) A-4723-963-A MOTOR ASSY, TABLE 57 HCD-GN700/GX8800 8-5. CD MECHANISM DECK SECTION-2 (CDM74-K6BD47S) 205 205 217 216 212 211 210 RE701 213 214 205 215 231 219 220 202 208 222 229 M751 205 222 230 207 203 206 205 218 202 201 202 228 227 #6 205 223 222 223 205 223 224 222 223 224 226 225 204 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Ref. No. 201 202 203 204 205 206 207 208 210 211 212 213 214 215 216 217 218 219 Part No. 1-687-135-11 4-218-253-31 1-687-669-11 4-244-034-01 4-218-252-61 4-225-844-01 4-224-613-01 1-687-133-11 4-244-108-01 4-224-609-01 4-224-608-01 3-016-533-01 4-224-611-01 4-224-606-01 4-243-818-01 Description DRIVER BOARD SCREW (M2.6), +BTTP SW BOARD BELT (LOADING) SCREW (+PTPWH M2.6), FLOATING GEAR (LOADING A) GEAR (SHAFT) MOTOR (LD) BOARD GEAR, SWING GEAR (LOADING C) COLLAR, SWING WASHER (FR), STOPPER GEAR (LOADING B) GEAR (RV) GEAR (U/D) Remark Ref. No. 222 223 224 220 222 223 224 225 226 227 228 0 229 230 231 M751 RE701 #6 Part No. Description Remark 4-277-549-11 INSULATOR 4-277-045-11 SPRING (INSULATOR), COIL 4-231-151-01 X-4955-536-1 4-277-549-11 4-277-045-11 4-231-151-01 4-218-253-31 1-782-817-11 1-775-280-11 A-4731-446-A A-4735-357-A 1-471-035-11 4-243-817-11 A-4737-553-A 1-477-680-11 7-685-534-19 STOPPER (BU) HOLDER (213) ASSY INSULATOR SPRING (INSULATOR), COIL STOPPER (BU) SCREW (M2.6), +BTTP WIRE (FLAT TYPE) (16 CORE) WIRE (FLAT TYPE) (31 CORE) CD BOARD, COMPLETE BASE ASSY, OP (including KSS-213DCP) MAGNET ASSY CHASSIS MOTOR ASSY, LOADING ENCODER, ROTARY SCREW +BTP 2.6X8 TYPE2 N-S 4-243-822-01 LEVER (LIFTER) X-4955-774-1 PULLEY (SM) ASSY, CHUCKING 4-221-688-01 PULLEY (B), CHUCKING 58 SECTION 9 ELECTRICAL PARTS LIST NOTE: Ref. No. Part No. Description • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable HCD-GN700/GX8800 CD Remarks Ref. No. Part No. Description Remarks • Items marked “*” are not stocked since they The components identified by mark 0 or dotted line with mark are seldom required for routine service. 0 are critical for safety. Some delay should be anticipated when orderReplace only with part number ing these items. specified. • SEMICONDUCTORS In each case, u: µ, for example: When indicating parts by reference uA. . : µA. . uPA. . : µPA. . number, please include the board. uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. . • Abbreviation • CAPACITORS AR : Argentine model uF: µF E2 : 120 V AC Area in E model • COILS E3 : 240 V AC Area in E model uH: µH E51 : Chiri and Peru model MX : Mexican model Ref. No. Part No. Description A-4731-446-A CD BOARD, COMPLETE ******************* < CAPACITOR > Remarks Ref. No. C249 C250 C251 C252 C253 C254 C255 C256 C257 C258 C259 C260 C261 C262 C263 C264 C265 C266 C267 C268 C269 C270 C271 C273 C274 C275 C276 C279 C292 Part No. 1-162-974-11 1-164-360-11 1-164-360-11 1-164-360-11 1-164-360-11 1-162-919-11 1-164-360-11 1-164-360-11 1-165-112-11 1-162-919-11 1-164-361-11 1-126-246-11 1-126-607-11 1-126-607-11 1-125-822-11 1-126-607-11 1-126-607-11 1-164-360-11 1-162-966-11 1-162-966-11 1-125-822-11 1-162-960-11 1-162-970-11 1-162-960-11 1-162-970-11 1-126-246-11 1-126-209-11 1-100-588-21 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP ELECT CHIP TANTAL. CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP ELECT CHIP 0.01uF 0.1uF 0.1uF 0.1uF 0.1uF 22PF 0.1uF 0.1uF 0.33uF 22PF 0.047uF 220uF 47uF 47uF 10uF 47uF 47uF 0.1uF 0.0022uF 0.0022uF 10uF 220PF 0.01uF 220PF 0.01uF 220uF 100uF 1000uF 1uF Remarks 50V 16V 16V 16V 16V 50V 16V 16V 16V 50V 16V 4V 4V 4V 10V 4V 4V 16V 50V 50V 10V 50V 25V 50V 25V 4V 4V 6.3V 10V C101 C102 C103 C104 C107 C108 C109 C110 C111 C113 C114 C115 C116 C117 C118 C119 C131 C132 C133 C150 C151 C152 C158 C202 C203 C205 C206 C208 C209 C211 C212 C213 C215 C216 C222 C223 C224 C226 C227 C229 C230 C231 1-164-315-11 1-107-826-11 1-164-315-11 1-162-967-11 1-162-919-11 1-164-360-11 1-164-360-11 1-107-826-11 1-126-209-11 1-126-209-11 1-162-964-11 1-126-246-11 1-107-826-11 1-164-360-11 1-115-156-11 1-115-156-11 1-110-563-11 1-164-227-11 1-125-838-11 1-128-995-21 1-164-360-11 1-164-360-11 1-162-966-11 1-164-360-11 1-162-964-11 1-164-360-11 1-126-607-11 1-164-360-11 1-162-927-11 1-107-826-11 1-162-966-11 1-162-967-11 1-117-863-11 1-162-970-11 1-164-360-11 1-126-607-11 1-164-360-11 1-126-607-11 1-164-360-11 1-164-360-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 470PF 0.1uF 470PF 0.0033uF 22PF 0.1uF 0.1uF 0.1uF 100uF 100uF 0.001uF 220uF 0.1uF 0.1uF 1uF 1uF 0.068uF 0.022uF 2.2uF 100uF 5% 10% 5% 10% 5% 50V 16V 50V 50V 50V 16V 16V 16V 4V 4V 50V 4V 16V 16V 10V 10V 16V 25V 6.3V 10V 16V 16V 50V 16V 50V 16V 4V 16V 50V 16V 50V 50V 6.3V 25V 16V 4V 16V 4V 16V 16V 16V 4V 5% 5% 20% 20% 20% 20% 20% 20% 10% 20% 20% 10% 20% 10% 10% 10% 10% 20% 10% 10% 20% 10% 10% 10% 10% 20% 20% 20% 0.1uF 0.1uF 0.0022uF 10% 0.1uF 0.001uF 10% 0.1uF 47uF 0.1uF 100PF 0.1uF 0.0022uF 0.0033uF 0.47uF 0.01uF 0.1uF 47uF 0.1uF 47uF 0.1uF 0.1uF 0.1uF 100uF 1-115-156-11 CERAMIC CHIP < CONNECTOR > 20% 5% 10% 10% 10% 10% 10% CN101 CN102 1-784-387-11 CONNECTOR, FFC/FPC 31P 1-777-937-11 CONNECTOR, FFC/FPC 16P < FERRITE BEAD > 20% 20% FB101 FB102 FB103 FB104 FB106 FB107 FB291 1-500-283-11 1-500-283-11 1-500-283-11 1-500-283-11 1-500-283-11 FERRITE FERRITE FERRITE FERRITE FERRITE 0uH 0uH 0uH 0uH 0uH 0uH 0uH 1-500-283-11 FERRITE 1-500-283-11 FERRITE < IC > 1-164-360-11 CERAMIC CHIP 1-126-209-11 ELECT CHIP 20% IC101 8-752-408-73 IC CXD3068Q 59 HCD-GN700/GX8800 CD Ref. No. IC103 IC104 IC121 IC150 CD SWITCH Part No. 8-752-106-21 6-704-150-01 6-700-394-01 8-759-677-90 Description IC IC IC IC DISPLAY Remarks Ref. No. R254 R255 R257 R259 R260 R265 R266 R271 R272 R275 R276 R277 R279 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W D748 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W C100 C101 C102 R280 Part No. Description 100K 100 100 100 1K 220 220 10K 1K 10K 100 0 100 0 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1-216-845-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-809-11 1-216-821-11 1-216-813-11 1-216-813-11 1-216-833-11 1-216-821-11 1-216-833-11 1-216-809-11 1-216-864-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CXA2647N-T4 CXD9717R-008 BA25BC0FP-E2 BA5947FP-E2 < COIL > L101 1-412-063-21 INDUCTOR < TRANSISTOR > Q101 8-729-046-90 TRANSISTOR 2SB970-(TX).S0 < RESISTOR > R101 R102 R103 R104 R105 R111 R113 R114 R117 R118 R120 R122 R123 R125 R126 R131 R132 R133 R151 R152 R153 R155 R156 R201 R202 R203 R204 R205 R206 R207 R212 R213 R214 R215 R216 R218 R219 R220 R230 R231 R232 R233 R249 R250 R251 R252 R253 1-216-864-11 1-216-833-11 1-216-845-11 1-216-833-11 1-216-821-11 1-216-847-11 1-216-828-11 1-216-852-11 1-216-846-11 1-216-833-11 1-216-846-11 1-216-845-11 1-216-791-11 1-216-836-11 1-216-836-11 1-216-843-11 1-216-851-11 1-216-825-11 1-216-833-11 1-216-849-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-839-11 1-216-833-11 1-216-845-11 1-216-825-11 1-216-821-11 1-216-825-11 1-216-857-11 1-216-817-11 1-216-817-11 1-216-864-11 1-216-864-11 1-216-857-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-813-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-817-11 1-216-813-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 10K 100K 10K 1K 150K 3.9K 390K 120K 10K 120K 100K 3.3 18K 18K 68K 330K 2.2K 10K 220K 0 0 0 33K 10K 100K 2.2K 1K 2.2K 1M 470 470 0 0 1M 1K 1K 1K 220 100 100 100 470 220 220 1M 680 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 68uH 1-216-296-11 SHORT CHIP < SWITCH > S101 1-771-853-11 SWITCH, DETECTION (LIMIT) < VIBRATOR > X201 1-767-408-21 VIBRATOR, CRYSTAL (16.9MHz) ************************************************************* 1-686-936-11 CD SWITCH BOARD **************** < DIODE > 8-719-058-04 DIODE SEL5223S-TP15(=/1) < TRANSISTOR > Q748 8-729-116-02 TRANSISTOR BA1A4M-TP < RESISTOR > R748 R749 R788 R789 R790 R791 R792 1-249-411-11 1-249-410-11 1-249-427-11 1-249-429-11 1-249-431-11 CARBON CARBON CARBON CARBON CARBON 330 270 6.8K 10K 15K 22K 33K 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1-249-433-11 CARBON 1-249-435-11 CARBON < SWITCH > S749 S788 S789 S790 S791 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (=/1) SWITCH, KEYBOARD (Z,OPEN/CLOSE) SWITCH, KEYBOARD (EX-CHANGE/DISK SKIP) SWITCH, KEYBOARD (DISC 3) SWITCH, KEYBOARD (DISC 2) S792 1-762-875-21 SWITCH, KEYBOARD (DISC 1) ************************************************************* A-4731-330-A DISPLAY BOARD, COMPLETE (GN700) A-4733-055-A DISPLAY BOARD, COMPLETE (GX8800) ******************************** 4-231-581-01 HOLDER (FL) < CAPACITOR > 1-126-964-11 ELECT 1-137-194-81 FILM 1-137-194-81 FILM 10uF 0.47uF 0.47uF 20% 5% 5% 50V 50V 50V 1-216-857-11 METAL CHIP 1-216-819-11 METAL CHIP 60 HCD-GN700/GX8800 DISPLAY Ref. No. C104 C105 C106 C107 C109 C110 C111 C112 C114 C115 C116 C117 C118 C119 C120 C121 C122 C123 C124 C125 C152 C153 C154 C155 C156 C157 C618 C619 C620 C622 C623 C624 C625 C626 C627 C628 C651 C652 C653 C710 C711 C712 Part No. Description 10uF 0.22uF 0.1uF 0.1uF 10uF 0.22uF 0.022uF 0.022uF 10uF 0.22uF 0.0033uF 0.0033uF 10uF 10uF 0.22uF 4.7uF 100uF 100uF 10uF 0.1uF 220PF 220PF 220PF 220PF 220PF 220PF 0.01uF 47uF 0.01uF 4.7uF 0.001uF 0.01uF 0.01uF 0.01uF 0.01uF 0.01uF 0.1uF 10uF 10uF 0.01uF 0.01uF 0.01uF 20% 20% 5% 5% 20% 20% 5% 5% 20% 20% 5% 5% 20% 20% 20% 20% 20% 20% 20% 10% 10% 10% 10% 10% 10% 30% 20% 30% 20% 10% 30% 30% 30% 30% 30% Remarks 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 10V 10V 50V 50V 50V 50V 50V 50V 50V 50V 16V 16V 16V 50V 50V 16V 16V 16V 16V 16V 50V 50V 50V 16V 16V 16V Ref. No. D604 D605 D606 D610 Part No. 8-719-057-97 8-719-057-97 8-719-057-97 8-719-109-85 Description DIODE DIODE DIODE DIODE Remarks 1-126-964-11 ELECT 1-126-957-11 ELECT 1-136-165-00 1-136-165-00 1-124-261-00 1-126-957-11 1-136-157-00 1-136-157-00 1-126-964-11 1-126-957-11 1-137-367-11 1-137-367-11 1-126-964-11 1-124-261-00 1-126-957-11 1-126-963-11 1-124-584-00 1-104-665-11 1-126-964-11 1-164-159-11 1-162-286-31 1-162-286-31 1-162-286-31 1-162-286-31 1-162-286-31 1-162-286-31 1-162-306-11 1-124-589-11 1-162-306-11 1-126-163-11 1-162-294-31 1-162-306-11 1-162-306-11 1-162-306-11 1-162-306-11 1-162-306-11 1-164-159-11 1-124-261-00 1-124-261-00 1-162-306-11 1-162-306-11 1-162-306-11 FILM FILM ELECT ELECT FILM FILM ELECT ELECT MYLAR MYLAR ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT CERAMIC ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC CERAMIC < CONNECTOR > * CN601 CN604 1-569-935-11 SOCKET, CONNECTOR 19P 1-568-860-11 SOCKET, CONNECTOR 17P < DIODE > D100 D101 D102 D103 D104 D105 D106 D107 D601 D602 D603 8-719-983-63 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 6-500-522-11 6-500-522-11 8-719-063-93 8-719-057-97 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE MTZJ-T-72-3.3B 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 10EDB40-TA2B5 10EDB40-TA2B5 SLR325VC-N-T32 (REC PAUSE/START) SEL5923A-TP15 (GAME) SEL5923A-TP15 (CD) SEL5923A-TP15 (TUNER/BAND) SEL5923A-TP15 (TAPE A/B) MTZJ-T-72-5.1B < FLUORESCENT INDICATOR TUBE > FL601 1-518-862-11 INDICATOR TUBE, FLUORESCENT < IC > IC101 IC102 IC601 8-759-167-88 IC NJM4565D 8-759-167-88 IC NJM4565D 6-802-534-01 IC MB90M407PF-G-124-BND < TRANSISTOR > Q100 Q601 Q602 Q603 Q604 Q605 Q606 Q707 Q807 Q808 8-729-141-30 8-729-116-02 8-729-116-02 8-729-116-02 8-729-116-02 8-729-140-04 8-729-140-04 8-729-116-02 8-729-029-94 8-729-029-94 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R125 R127 R128 R129 R130 R131 R132 R133 R134 R136 R137 1-249-419-11 1-249-419-11 1-249-437-11 1-249-415-11 1-249-441-11 1-249-441-11 1-249-419-11 1-249-419-11 1-249-437-11 1-249-415-11 1-249-441-11 1-249-441-11 1-249-419-11 1-249-419-11 1-249-437-11 1-249-415-11 1-249-441-11 1-249-441-11 1-249-419-11 1-249-419-11 1-249-437-11 1-249-415-11 1-249-441-11 1-249-441-11 1-249-409-11 1-247-895-00 1-249-425-11 1-249-425-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-439-11 1-249-433-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1.5K 1.5K 47K 680 100K 100K 1.5K 1.5K 47K 680 100K 100K 1.5K 1.5K 47K 680 100K 100K 1.5K 1.5K 47K 680 100K 100K 220 470K 4.7K 4.7K 100K 100K 100K 100K 68K 22K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/4W 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W F 1/4W 1/4W 1/4W F 1/4W F 1/4W 1/4W F 1/4W 1/4W 1/4W F 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2SC3623ATP-LK BA1A4M-TP BA1A4M-TP BA1A4M-TP BA1A4M-TP 2SB1116-TP-LK 2SB1116-TP-LK BA1A4M-TP BA1L3Z-TP BA1L3Z-TP 20% 20% 30% 30% 30% 8-719-057-97 DIODE SEL5923A-TP15 (MD(VIDEO)) 61 HCD-GN700/GX8800 DISPLAY Ref. No. R138 R139 R140 R626 R627 R628 R629 R630 R631 R632 R633 R634 R635 R636 R637 R645 R646 R647 R652 R653 R654 R655 R656 R657 R658 R659 R660 R661 R662 R663 R751 R752 R753 R754 R755 R756 R757 R758 R779 R781 R782 R783 R784 R785 R786 R787 R807 R808 R817 R818 R819 R820 R821 R822 R823 Part No. DRIVER Description 1K 330 100 330 330 330 330 330 680 680 680 10K 10K 10K 10K 10K 100 100 10K 10K 100 100 100 15K 15K 15K 1M 10K 10K 10K 470 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 470 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 100K 100K 120 180 180 180 120 1K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F C715 C731 C735 C736 C737 C741 C751 C752 Ref. No. S753 S754 S755 S756 S757 S758 S779 S782 S783 S784 S785 S786 S787 Part No. Description Remarks 1-762-875-21 SWITCH, KEYBOARD (X) 1-762-875-21 SWITCH, KEYBOARD (-,.) 1-762-875-21 SWITCH, KEYBOARD (>,+) 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (M,ALBUM +) SWITCH, KEYBOARD (m,ALBUM -) SWITCH, KEYBOARD (REC PAUSE/START) SWITCH, KEYBOARD (CD SYNC) SWITCH, KEYBOARD (GAME MIXING) SWITCH, KEYBOARD (GAME) SWITCH, KEYBOARD (MD(VIDEO)) SWITCH, KEYBOARD (TAPE A/B) SWITCH, KEYBOARD (TUNER/BAND) SWITCH, KEYBOARD (CD) < VIBRATOR > X601 1-781-282-51 VIBRATOR, CERAMIC (4MHz) ************************************************************* 1-687-135-11 DRIVER BOARD ************* < CAPACITOR > 1-126-933-11 1-126-964-51 1-164-159-11 1-164-159-11 1-164-159-11 ELECT ELECT CERAMIC CERAMIC CERAMIC 100uF 10uF 0.1uF 0.1uF 0.1uF 0.01uF 0.01uF 0.1uF 20% 20% 16V 50V 50V 50V 50V 16V 16V 50V 1-249-417-11 CARBON 1-249-411-11 1-247-807-31 1-249-411-11 1-249-411-11 1-249-411-11 1-249-411-11 1-249-411-11 1-249-415-11 1-249-415-11 1-249-415-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-247-807-31 1-247-807-31 1-249-429-11 1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-249-431-11 1-249-431-11 1-249-431-11 1-247-903-00 1-249-429-11 1-249-429-11 1-249-429-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-425-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-425-11 1-249-441-11 1-249-441-11 1-249-406-11 1-249-408-11 1-249-408-11 1-249-408-11 1-249-406-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON < SWITCH > 1-162-306-11 CERAMIC 1-162-306-11 CERAMIC 1-164-159-11 CERAMIC < CONNECTOR > 30% 30% CN701 CN702 * CN703 CN704 1-785-338-11 1-784-766-11 1-564-720-11 1-785-328-11 PIN, CONNECTOR(LIGHT ANGLE)12P CONNECTOR, FFC 5P PIN, CONNECTOR (SMALL TYPE) 4P PIN, CONNECTOR (LIGHT ANGRE)2P < DIODE > F F F F F F F F D701 D711 8-719-947-16 DIODE MTZJ-T-72-5.1A 8-719-983-66 DIODE MTZJ-T-72-3.6B < IC > IC701 IC712 8-759-598-69 IC BA6956AN 8-759-598-69 IC BA6956AN < TRANSISTOR > Q731 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W F F F F 8-729-029-66 TRANSISTOR DTC114ESA-TP < RESISTOR > R701 R702 R711 R712 R713 R721 R722 R723 R731 R732 1-249-413-11 1-247-807-31 1-249-417-11 1-249-425-11 1-249-433-11 1-249-425-11 1-249-425-11 1-249-425-11 1-247-807-31 1-249-425-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 470 100 1K 4.7K 22K 4.7K 4.7K 4.7K 100 4.7K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F S751 S752 1-762-875-21 SWITCH, KEYBOARD (gG) 1-762-875-21 SWITCH, KEYBOARD (x) 62 HCD-GN700/GX8800 DRIVER Ref. No. Part No. Description Remarks Ref. No. R722 R734 R735 R736 R737 R738 R739 R740 R742 R743 20% 20% 10% 10% 10% 10% 5% 5% 20% 20% 20% 20% 20% 20% 5% 10% 20% 5% 10% 10% 20% 50V 50V 50V 50V 50V 50V 50V 50V 10V 10V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 25V 50V R744 R745 R746 Part No. 1-249-432-11 1-247-807-31 1-247-885-00 1-249-429-11 1-249-433-11 1-249-417-11 1-249-441-11 1-249-421-11 1-249-417-11 1-249-429-11 R733 1-249-417-11 CARBON 1K 5% 1/4W F R734 1-249-433-11 CARBON 22K 5% 1/4W R735 1-247-807-31 CARBON 100 5% 1/4W R751 1-249-425-11 CARBON 4.7K 5% 1/4W F ************************************************************* A-4731-327-A GAME IN BOARD, COMPLETE ************************ < CAPACITOR > C604 C606 C630 C631 C634 C635 C715 C716 C717 C718 C719 C736 C737 C738 C739 C740 C741 C742 C743 C744 C747 C748 C749 1-124-257-00 1-124-257-00 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-215-31 1-162-215-31 1-124-584-00 1-124-584-00 1-124-257-00 1-124-261-00 1-124-261-00 1-124-257-00 1-162-215-31 1-162-282-31 1-124-250-11 1-162-215-31 1-162-290-31 1-162-294-31 ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC ELECT CERAMIC CERAMIC CERAMIC 2.2uF 2.2uF 0.001uF 0.001uF 0.001uF 0.001uF 47PF 47PF 100uF 100uF 2.2uF 10uF 10uF 2.2uF 47PF 100PF 0.15uF 47PF 470PF 0.001uF 2.2uF 0.022uF 0.1uF CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON GAME IN 18K 100 180K 10K 22K 1K 100K 2.2K 1K 10K 100K 100 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% MAIN Remarks 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W F Description 1-249-441-11 CARBON 1-247-807-31 CARBON 1-249-417-11 CARBON < VARIABLE RESISTOR > RV722 1-227-452-11 RES, VAR, CARBON 50K (MIC LEVEL) ************************************************************* A-4731-356-A MAIN BOARD, COMPLETE (GN700:AR,E2,E51,MX) A-4733-061-A MAIN BOARD, COMPLETE (GN700:E3) A-4733-066-A MAIN BOARD, COMPLETE (GX8800) ********************** 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S < CAPACITOR > C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C121 C122 C130 C132 C115 C140 C150 C152 C153 C154 C155 C156 C157 C158 C159 C160 C161 1-126-933-11 1-126-964-11 1-126-964-11 1-126-964-11 1-126-795-11 1-136-157-00 1-136-157-00 1-136-159-00 1-115-871-11 1-137-150-11 1-126-795-11 1-136-169-00 1-136-171-00 1-126-964-11 1-164-156-11 1-126-933-11 1-126-961-11 1-162-960-11 1-162-960-11 1-126-964-11 1-126-959-11 1-164-156-11 1-136-495-11 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11 1-136-157-00 1-136-157-00 1-136-159-00 1-115-871-11 1-137-150-11 1-126-795-11 ELECT ELECT ELECT ELECT ELECT FILM FILM FILM ELECT MYLAR ELECT FILM FILM ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP FILM ELECT ELECT ELECT ELECT ELECT FILM FILM FILM ELECT MYLAR ELECT 100uF 10uF 10uF 10uF 10uF 0.022uF 0.022uF 0.033uF 1uF 0.01uF 10uF 0.22uF 0.33uF 10uF 0.1uF 100uF 2.2uF 220PF 220PF 10uF 0.47uF 0.1uF 0.068uF 10uF 10uF 10uF 10uF 10uF 0.022uF 0.022uF 0.033uF 1uF 0.01uF 10uF 20% 20% 20% 20% 20% 5% 5% 5% 20% 5% 20% 5% 5% 20% 16V 50V 50V 50V 50V 50V 50V 50V 50V 100V 50V 50V 50V 50V 25V 16V 50V 50V 50V 50V 50V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 100V 50V 1-124-257-00 ELECT 1-161-494-00 CERAMIC 1-164-159-11 CERAMIC < CONNECTOR > * CN606 CN607 1-564-724-11 PIN, CONNECTOR (SMALL TYPE) 8P 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE) 2P < GROUND TERMINAL > EP701 EP703 1-537-738-21 TERMINAL, GROUND 1-537-738-21 TERMINAL, GROUND < IC > IC722 8-759-167-88 IC NJM4565D < JACK > 20% 20% 10% 10% 20% 20% 5% 20% 20% 20% 20% 20% 5% 5% 5% 20% 5% 20% J601 J631 J721 1-764-592-11 JACK 3P (GAME INPUT) 1-794-702-11 JACK, HEADPHONE (PHONES) 1-817-629-11 JACK (LARGE TYPE) (MIC) < TRANSISTOR > Q721 8-729-119-79 TRANSISTOR 2SC2785TP-FEK < RESISTOR > R602 R603 R604 R605 R721 1-249-417-11 1-249-417-11 1-249-441-11 1-249-441-11 1-249-429-11 CARBON CARBON CARBON CARBON CARBON 1K 1K 100K 100K 10K 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/4W 1/4W 1/4W 63 HCD-GN700/GX8800 MAIN Ref. No. C162 C163 C167 C200 C201 C203 Part No. Description 0.22uF 0.33uF 2.2uF 0.01uF 100uF 0.01uF 5% 5% 20% 10% 20% 10% Remarks 50V 50V 50V 25V 10V 25V (GX8800) 25V 6.3V 10V 25V 25V 50V 50V 10V 25V (GX8800) 50V 50V 50V 50V 50V 50V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 100V 50V 50V 50V 50V 50V 50V 16V 50V 50V 50V 50V 50V 16V 50V 50V 50V 50V 50V 50V 50V 50V 50V Ref. No. C385 C386 C387 C390 C391 C395 C396 C397 C398 C399 C416 C427 C432 C433 C434 C498 C502 C503 C510 C511 C512 C516 C562 C564 C596 C598 C601 C602 C603 C620 C621 C650 C651 C656 C670 C671 C851 C901 C902 C903 C904 C905 C906 C908 C909 C910 C911 C912 C913 C914 C915 C917 C918 C919 C920 C921 C922 C923 C924 Part No. Description 10uF 20% 0.0047uF 10% 0.0047uF 10% 470uF 100uF 22PF 22uF 10uF 0.01uF 0.01uF 0.1uF 47PF 47PF 47PF 47PF 0.1uF 0.022uF 0.022uF 22PF 15PF 0.1uF 1000uF 100uF 0.01uF 0.1uF 10uF 10uF 0.1uF 0.1uF 4.7uF 4.7uF 1uF 47uF 0.47uF 4.7uF 4.7uF 0.1uF 3300uF 2200uF 2200uF 0.01uF 0.01uF 100uF 0.1uF 0.1uF 0.1uF 470uF 0.1uF 470uF 470uF 0.1uF 470uF 0.1uF 2200uF 10uF 100uF 2.2uF 2.2uF 0.1uF 20% 20% 5% 20% 20% 10% 10% 5% 5% 5% 5% 10% 10% 5% 5% 20% 20% 10% 20% 20% 5% 5% 20% 20% 20% 20% 10% 20% 20% 20% 20% 20% 5% 5% 20% 5% 5% 20% Remarks 50V 50V 50V 10V 16V 50V 50V 50V 25V 25V 25V 50V 50V 50V 50V 25V 25V 25V 50V 50V 25V 6.3V 10V 25V 25V 50V 50V 50V 50V 50V 100V 50V 50V 25V 50V 100V 25V 25V 25V 16V 50V 50V 16V 50V 50V 25V 16V 25V 16V 16V 25V 10V 25V 6.3V 50V 50V 50V 50V 25V 1-136-169-00 FILM 1-136-171-00 1-126-961-11 1-162-970-11 1-104-665-11 1-162-970-11 FILM ELECT CERAMIC CHIP ELECT CERAMIC CHIP 1-126-964-11 ELECT 1-162-968-11 CERAMIC CHIP 1-162-968-11 CERAMIC CHIP 1-126-935-11 1-126-933-11 1-162-919-11 1-126-965-91 1-126-964-11 1-162-970-11 1-162-970-11 1-164-156-11 1-162-923-11 1-162-923-11 1-162-923-11 1-162-923-11 1-164-156-11 1-164-227-11 1-164-227-11 1-162-919-11 1-162-917-11 1-164-156-11 1-126-916-11 1-104-665-11 1-162-970-11 1-164-156-11 1-126-964-11 1-126-964-11 1-136-165-00 1-136-165-00 1-126-963-11 1-107-721-11 1-109-889-11 1-107-717-11 1-125-891-11 1-126-963-11 1-107-721-11 1-164-156-11 1-126-944-11 1-126-943-61 1-126-768-11 1-130-483-00 1-130-483-00 1-126-933-11 1-136-165-00 1-136-165-00 1-164-156-11 1-126-935-11 1-164-156-11 1-126-935-11 1-126-935-11 1-164-156-11 1-126-935-11 1-164-156-11 1-104-656-11 1-126-964-11 1-126-968-11 1-126-961-11 1-126-961-11 ELECT ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT FILM FILM ELECT ELECT ELECT ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT ELECT ELECT MYLAR MYLAR ELECT FILM FILM CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT C206 C207 C209 C210 C211 C219 C269 C286 C288 C301 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C314 C315 C316 C321 C326 C331 C332 C333 C334 C335 C336 C337 C338 C339 C340 C341 C342 C351 C353 C354 C355 C356 C359 C361 C364 C365 C371 C376 C381 C382 C383 C384 1-164-156-11 1-126-916-11 1-126-928-11 1-164-156-11 1-164-227-11 1-126-964-11 1-126-964-11 1-125-891-11 1-162-970-11 CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP 0.1uF 1000uF 3300uF 0.1uF 0.022uF 10uF 10uF 0.47uF 0.47uF 0.01uF 0.1uF 10uF 1uF 2.2uF 10uF 470uF 47uF 10uF 10uF 10uF 0.0022uF 1uF 1uF 390PF 390PF 0.01uF 120PF 330PF 27PF 0.01uF 2.2uF 0.015uF 0.0068uF 0.0068uF 0.018uF 10uF 47uF 0.01uF 0.1uF 10uF 1uF 2.2uF 47uF 10uF 0.0022uF 1uF 390PF 390PF 0.01uF 120PF 330PF 27PF 20% 20% 10% 20% 20% 10% 10% 5% 5% 20% 20% 20% 20% 20% 20% 20% 20% 20% 10% 20% 20% 10% 10% 5% 5% 10% 5% 5% 20% 5% 5% 5% 10% 20% 20% 5% 5% 20% 20% 20% 20% 20% 10% 20% 10% 10% 5% 5% 10% 5% 1-130-483-00 MYLAR 1-136-165-00 1-126-964-11 1-126-960-11 1-126-961-11 1-126-964-11 1-126-935-11 1-126-947-11 1-126-964-11 1-126-964-11 1-126-964-11 1-162-966-11 1-126-960-11 1-126-960-11 1-164-392-11 1-164-392-11 1-130-483-00 1-137-427-11 1-162-961-11 1-162-946-11 1-137-150-11 1-126-961-11 1-130-485-00 1-130-481-00 1-130-481-00 1-130-486-00 1-126-964-11 1-126-947-11 1-130-483-00 1-136-165-00 1-126-964-11 1-126-960-11 1-126-961-11 1-126-947-11 1-126-964-11 1-162-966-11 1-126-960-11 1-164-392-11 1-164-392-11 1-130-483-00 1-137-427-11 FILM ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP MYLAR MYLAR CERAMIC CHIP CERAMIC CHIP MYLAR ELECT MYLAR MYLAR MYLAR MYLAR ELECT ELECT MYLAR FILM ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP MYLAR MYLAR 20% 20% 20% 20% 20% 20% 20% 20% 1-162-961-11 CERAMIC CHIP 1-162-946-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 64 HCD-GN700/GX8800 MAIN Ref. No. Part No. Description < CONNECTOR > CN201 * CN301 * CN304 * CN402 CN501 CN502 CN702 CN851 CN901 CN902 1-779-299-11 1-568-449-11 1-569-930-11 1-569-935-11 1-785-330-11 1-785-336-11 1-569-906-11 1-564-506-11 1-770-726-11 1-778-982-11 CONNECTOR,FFC(LIF(NON-ZIF))31P HOUSING, CONNECTOR(PC BOARD)3P SOCKET, CONNECTOR 13P SOCKET, CONNECTOR 19P PIN, CONNECTOR (LIGHT ANGLE)4P PIN, CONNECTOR(LIGHT ANGLE)10P SOCKET, CONNECTOR 11P PLUG, CONNECTOR 3P CONNECTOR, BOARD TO BOARD 6P CONNECTOR, BOARD TO BOARD 13P < DIODE > D130 D392 D393 D394 D501 D502 D503 D504 D505 D508 D509 D601 D602 D603 D901 D909 D910 D911 D912 D913 D914 D915 D917 D941 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-028-23 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 8-719-988-61 8-719-977-81 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 D3SBA20-4101 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 1SS355TE-17 UDZ-TE-17-33B Remarks Ref. No. FB516 FB562 Part No. Description 0uH 0uH Remarks 1-414-772-11 FERRITE 1-414-772-11 FERRITE < IC > IC102 IC201 IC301 IC302 IC303 IC501 IC502 IC601 IC901 IC902 IC903 IC904 6-703-650-11 8-749-019-25 6-702-130-01 8-759-508-69 8-759-710-97 6-802-545-01 6-703-610-01 8-759-533-04 8-759-701-59 8-759-701-59 IC IC IC IC IC IC IC IC IC IC M61529FP-D60G TOTX141 (CD DIGITAL OUT) HA12237F BA3126N NJM4565M(TE2) M30622MGN-B09FP RT8H015C-T112-1 M62703ML-E1 TA7809S TA7809S 6-703-546-01 IC TA7804LS 6-702-771-01 IC TA78033LS < JACK > J117 J716 1-764-767-21 JACK, PIN 2P (MD/VIDEO(AUDIO) IN) 1-774-227-11 JACK, PIN 1P (VIDEO OUT) < JUMPER RESISTOR > JR001 JR003 JR005 JR006 JR007 JR008 JR009 JR011 JR012 JR013 JR015 JR016 JR017 JR018 JR022 JR024 JR026 JR045 JR103 JR104 JR118 JR130 JR138 JR390 1-216-296-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-414-760-21 1-216-296-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 SHORT CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP FERRITE SHORT CHIP METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP < COIL> 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0uH 0 0 0 0 0 0 0 5% 5% 1/10W 1/10W 5% 5% 1/10W 1/10W 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W < FERRITE BEAD > FB117 FB167 FB201 FB202 FB202 FB203 FB203 FB204 FB204 FB205 1-216-864-11 1-216-864-11 1-469-152-11 1-216-864-11 METAL CHIP METAL CHIP FERRITE METAL CHIP 0 0 0uH 0 0uH 0 0uH 0 0uH 0 5% 5% 5% 5% 1/10W 1/10W 1/10W (GN700) (GX8800) 1/10W (GN700) (GX8800) 1/10W (GN700) (GX8800) 1/10W (GN700) (GX8800) 1/10W (GN700) (GX8800) 1/10W (GN700) (GX8800) 5% 1/10W 1-469-152-11 FERRITE 1-216-864-11 METAL CHIP 1-469-152-11 FERRITE 1-216-864-11 METAL CHIP 1-469-152-11 FERRITE 1-216-864-11 METAL CHIP 5% 5% 5% 1/10W 1/10W 1/10W 5% 5% L301 L302 L351 1-410-780-11 INDUCTOR 1-414-189-31 INDUCTOR 1-410-780-11 INDUCTOR < TRANSISTOR > 27mH 100uH 27mH FB205 FB284 FB284 FB286 FB286 1-469-152-11 FERRITE 1-216-864-11 METAL CHIP 1-469-152-11 FERRITE 1-216-864-11 METAL CHIP 1-469-152-11 FERRITE 0uH 0 0uH 0 0uH 5% 5% Q101 Q151 Q201 Q206 Q207 Q251 8-729-120-28 8-729-120-28 8-729-802-80 8-729-900-53 8-729-027-31 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC1623-T1-L5L6 2SC1623-T1-L5L6 2SC3661-TB DTC114EKA-T146 DTA124EKA-T146 8-729-802-80 TRANSISTOR 2SC3661-TB 65 HCD-GN700/GX8800 MAIN Ref. No. Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q310 Q389 Q390 Q391 Q392 Q393 Q394 Q395 Q396 Q398 Q399 Q601 Q602 Q620 Q621 Q650 Q651 Q652 Q670 Q671 Q851 Q852 Q901 Q902 Q903 Part No. 8-729-141-73 8-729-142-46 8-729-142-46 8-729-027-31 8-729-900-53 8-729-900-53 8-729-216-22 8-729-900-53 8-729-900-53 8-729-900-53 8-729-140-04 8-729-900-53 8-729-116-57 8-729-900-53 8-729-900-53 8-729-140-04 8-729-900-53 8-729-141-73 8-729-120-28 8-729-014-97 8-729-802-80 8-729-802-80 8-729-027-31 8-729-900-53 8-729-027-31 8-729-802-80 8-729-802-80 8-729-140-04 8-729-620-05 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3624A-T1L15L16 2SC2001TP-LK 2SC2001TP-LK DTA124EKA-T146 DTC114EKA-T146 DTC114EKA-T146 2SA812-T1-M5M6 DTC114EKA-T146 DTC114EKA-T146 DTC114EKA-T146 2SB1116-TP-LK DTC114EKA-T146 2SB1068TP-K DTC114EKA-T146 DTC114EKA-T146 2SB1116-TP-LK DTC114EKA-T146 2SC3624A-T1L15L16 2SC1623-T1-L5L6 FA1L3Z-T1B 2SC3661-TB 2SC3661-TB DTA124EKA-T146 DTC114EKA-T146 DTA124EKA-T146 2SC3661-TB 2SC3661-TB 2SB1116-TP-LK 2SC2603TP-EF Remarks Ref. No. R154 R155 R156 R157 R167 R168 R204 R205 R206 R224 R226 R228 R254 R255 R256 R284 R285 R286 R301 R302 R303 R304 R305 R306 R307 R308 R309 R310 R312 R313 R314 R315 R316 R317 R320 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W R327 R328 R329 R330 R332 R333 R334 R342 0 R343 0 R344 R345 R346 R347 R351 R352 R353 R354 R355 R360 R361 R362 Part No. 1-216-821-11 1-216-841-11 1-216-833-11 1-216-809-11 1-216-845-11 1-216-821-11 1-216-833-11 1-216-821-11 1-216-839-11 1-216-826-11 1-216-847-11 1-216-843-11 1-216-833-11 1-216-821-11 1-216-839-11 1-216-853-11 1-216-837-11 1-216-837-11 1-216-827-11 1-216-829-11 1-216-833-11 1-216-825-11 1-216-841-11 1-216-837-11 1-216-857-11 1-216-809-11 1-216-829-11 1-216-809-11 1-216-809-11 1-216-821-11 1-216-821-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-825-11 1-216-835-11 1-216-827-11 1-216-833-11 1-216-837-11 1-216-832-11 1-216-825-11 1-216-845-11 1-216-825-11 1-219-787-17 1-219-787-17 1-216-836-11 1-216-836-11 1-216-830-11 1-216-827-11 1-216-829-11 1-216-833-11 1-216-825-11 1-216-841-11 1-216-819-11 1-216-825-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP FUSIBLE FUSIBLE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 47K 10K 100 100K 1K 10K 1K 33K 2.7K 150K 68K 10K 1K 33K 470K 22K 22K 3.3K 4.7K 10K 2.2K 47K 22K 1M 100 4.7K 100 100 1K 1K 10K 10K 10K 2.2K 15K 3.3K 10K 22K 8.2K 2.2K 100K 2.2K 5.6 5.6 18K 18K 5.6K 3.3K 4.7K 10K 2.2K 47K 680 2.2K 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 8-729-040-20 TRANSISTOR RT1P137L-TP 8-729-900-53 TRANSISTOR DTC114EKA-T146 8-729-209-60 TRANSISTOR 2SB1375 < RESISTOR > R101 R102 R103 R104 R105 R106 R107 R110 R112 R117 R118 R121 R122 R130 R131 R132 R133 R134 R140 R141 R142 R150 R151 R152 R153 1-216-825-11 1-216-833-11 1-220-373-11 1-216-821-11 1-216-841-11 1-216-833-11 1-216-809-11 1-216-864-11 1-216-864-11 1-216-845-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-825-11 1-216-825-11 1-216-857-11 1-216-845-11 1-218-701-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-825-11 1-216-825-11 1-216-833-11 1-220-373-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 10K 620 1K 47K 10K 100 0 0 100K 1K 1K 1K 2.2K 2.2K 1M 100K 2.4K 10K 100 100 2.2K 2.2K 10K 620 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1-216-833-11 METAL CHIP The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 66 HCD-GN700/GX8800 MAIN Ref. No. R363 R364 R365 R366 R367 R368 R369 R370 R371 R372 R373 R374 R375 R376 R377 R378 R379 R380 R382 R387 R388 R390 R391 R392 R393 R394 R395 R396 R397 R398 R399 R401 R402 R419 R420 R421 R422 R427 R429 R430 R431 R432 R433 R434 R442 R443 R444 R445 R446 R447 R448 R450 R473 R474 R477 R478 R492 R493 Part No. 1-216-825-11 1-216-819-11 1-216-833-11 1-216-819-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-825-11 1-216-827-11 1-216-825-11 1-216-825-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-837-11 1-216-832-11 1-216-833-11 1-216-837-11 1-216-833-11 1-216-827-11 1-216-825-11 1-216-829-11 1-216-833-11 1-216-829-11 1-216-833-11 1-216-835-11 1-216-861-11 1-216-827-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-829-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-817-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-817-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11 1-216-823-11 1-216-864-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 680 10K 680 10K 10K 10K 2.2K 3.3K 2.2K 2.2K 10K 10K 10K 10K 10K 10K 22K 8.2K 10K 22K 10K 3.3K 2.2K 4.7K 10K 4.7K 10K 15K 2.2M 3.3K 10K 10K 100 4.7K 10K 10K 100 100 100 100K 100 100 470 100 100 100 100 100 100 470 100 100 100 10K 10K 1.5K 0 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (GN700:E3) Ref. No. R493 Part No. Description Remarks 4.7K 5% 1/10W (GN700:AR,E2,E51,MX,GX8800) 1K 1K 100 100 470 470 470 10K 330K 0 10K 100 10K 100 100 10K 10K 10K 47K 470 100 470 100 100 100 100 10K 10K 10K 10K 10K 10K 100 100 10K 100 100 100 100 10K 10K 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1-216-829-11 METAL CHIP R501 R502 R503 R504 R505 R506 R507 R509 R511 R513 R517 R518 R519 R521 R522 R523 R529 R530 R532 R535 R536 R537 R538 R539 R540 R541 R542 R543 R544 R545 R549 R550 R560 R561 R563 R565 R566 R567 R568 R573 R574 R575 R576 R577 R578 R579 R580 R581 R583 R584 R585 R586 R587 R588 R589 R590 R591 1-216-821-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-817-11 1-216-817-11 1-216-817-11 1-216-833-11 1-216-851-11 1-216-864-11 1-216-833-11 1-216-809-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-841-11 1-216-817-11 1-216-809-11 1-216-817-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 67 HCD-GN700/GX8800 MAIN Ref. No. R592 R593 R593 MOTOR (LD) Part No. Description 4.7K 2.2K 1K 1-216-829-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-821-11 METAL CHIP MOTOR (TB) Remarks 1/10W 1/10W (GX8800) 5% 1/10W (GN700:AR,E2,E51,MX) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 2W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 2W 1/10W 1/10W 1/10W 1/10W 1W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 5% 5% POWER AMP Ref. No. Part No. Description Remarks 1-687-133-11 MOTOR (LD) BOARD ***************** ************************************************************* 1-687-134-11 MOTOR (TB) BOARD ***************** < CONNECTOR > CN742 1-784-727-11 CONNECTOR, FFC 5P ************************************************************* A-4731-361-A POWER AMP BOARD, COMPLETE (GN700) A-4733-071-A POWER AMP BOARD, COMPLETE (GX8800) *************************** 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S < CAPACITOR > C501 C502 C503 C504 C507 C508 C509 C512 C513 C516 C517 C523 C524 C526 C527 C541 C542 C544 C545 C546 C551 C552 C553 C554 C557 C558 C559 C581 C591 C592 C596 1-126-963-11 1-162-294-31 1-162-286-31 1-104-665-11 1-136-495-11 1-136-495-11 1-128-560-11 1-162-306-11 1-162-306-11 1-104-665-11 1-126-964-11 1-162-306-11 1-162-306-11 1-126-964-11 1-162-306-11 1-136-165-00 1-127-811-11 1-130-777-00 1-130-777-00 1-137-843-11 1-126-963-11 1-162-294-31 1-162-286-31 1-104-665-11 1-136-495-11 1-136-495-11 1-128-560-11 1-126-965-91 1-136-165-00 1-127-811-11 ELECT CERAMIC CERAMIC ELECT FILM FILM ELECT CERAMIC CERAMIC ELECT ELECT CERAMIC CERAMIC ELECT CERAMIC FILM ELECT MYLAR MYLAR ELECT ELECT CERAMIC CERAMIC ELECT FILM FILM ELECT ELECT FILM ELECT 4.7uF 0.001uF 220PF 100uF 0.068uF 0.068uF 22uF 0.01uF 0.01uF 100uF 10uF 0.01uF 0.01uF 10uF 0.01uF 0.1uF 3300uF 0.1uF 0.1uF 2200uF 4.7uF 0.001uF 220PF 100uF 0.068uF 0.068uF 22uF 22uF 0.1uF 3300uF 2200uF 20% 10% 10% 20% 5% 5% 20% 20% 20% 20% 20% 30% 30% 20% 20% 5% 20% 5% 5% 20% 20% 10% 10% 20% 5% 5% 20% 20% 5% 20% 20% 50V 50V 50V 10V 50V 50V 100V 16V 16V 10V 50V 16V 16V 50V 16V 50V 50V 100V 100V 100V 50V 50V 50V 10V 50V 50V 100V 50V 50V 50V 100V R594 R597 R600 R601 R602 R603 R604 R620 R621 R622 R623 R624 R625 R626 R650 R651 R652 R653 R654 R655 R656 R670 R671 R672 R673 R674 R675 R676 R851 R852 R853 R854 R901 R902 R903 R904 R905 R906 R908 R913 1-216-821-11 1-216-809-11 1-216-809-11 1-216-813-11 1-216-829-11 1-216-841-11 1-216-841-11 1-216-833-11 1-216-821-11 1-216-841-11 1-216-833-11 1-215-891-11 1-216-821-11 1-216-806-11 1-216-835-11 1-216-853-11 1-216-843-11 1-216-821-11 1-216-845-11 1-216-845-11 1-216-833-11 1-216-833-11 1-216-821-11 1-216-841-11 1-216-833-11 1-215-891-11 1-216-821-11 1-216-806-11 1-216-825-11 1-216-833-11 1-216-422-11 1-216-829-11 1-216-826-11 1-216-825-11 1-216-825-11 1-216-832-11 1-216-832-11 1-216-821-11 1-216-833-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 100 100 220 4.7K 47K 47K 10K 1K 47K 10K 680 1K 56 15K 470K 68K 1K 100K 100K 10K 10K 1K 47K 10K 680 1K 56 2.2K 10K 18 4.7K 2.7K 2.2K 2.2K 8.2K 8.2K 1K 10K 47K < VARIABLE RESISTOR > RV301 RV304 RV351 RV354 1-238-019-11 1-241-768-11 1-238-019-11 1-241-768-11 RES, ADJ, CARBON 47K (REC LEVEL (L)) RES, ADJ, CARBON 220K (REC BIAS (L)) RES, ADJ, CARBON 47K (REC LEVEL (R)) RES, ADJ, CARBON 220K (REC BIAS (R)) < TRANSFORMER > T301 1-423-980-11 TRANSFORMER, BIAS OSCILLATION < VIBRATOR > X501 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) X502 1-781-107-21 VIBRATOR, SERAMIC (16MHz) ************************************************************* 1-137-843-11 ELECT < CONNECTOR > CN503 CN504 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P 1-770-722-11 CONNECTOR, BOARD TO BOARD 6P < DIODE > D501 D502 D503 D504 8-719-991-33 8-719-991-33 8-719-947-70 8-719-947-70 DIODE DIODE DIODE DIODE 1SS133T-72 1SS133T-72 MTZJ-T-72-18C MTZJ-T-72-18C 68 HCD-GN700/GX8800 POWER AMP Ref. No. D506 D507 D508 D509 D510 D511 D541 D543 D551 D581 Part No. Description Remarks Ref. No. R527 R528 R529 R530 R531 R532 R533 0 R539 0 R539 0 R540 0 R540 R541 < IC > IC501 8-749-017-06 IC STK412-150 < TRANSISTOR > Q501 Q503 Q504 Q505 Q506 Q510 Q511 Q513 Q514 Q515 Q516 Q517 Q518 Q551 Q581 8-729-140-84 8-729-140-82 8-729-140-84 8-729-119-79 8-729-119-79 8-729-119-79 8-729-119-79 8-729-119-79 8-729-119-79 8-729-119-76 8-729-119-79 8-729-119-76 8-729-119-79 8-729-140-84 8-729-140-84 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R501 R502 R503 R504 R505 R506 R507 0 R508 R509 0 R511 0 R512 R513 R514 R515 R516 R517 R518 R519 0 R520 R521 R522 R523 0 R524 1-249-417-11 1-249-437-11 1-249-411-11 1-249-437-11 1-249-416-11 1-249-435-11 1-249-441-11 1-234-798-11 1-260-076-11 1-212-881-11 1-202-972-61 1-249-435-11 1-249-421-11 1-249-433-11 1-249-429-11 1-249-429-11 1-249-435-11 1-249-439-11 1-215-872-11 1-249-441-11 CARBON CARBON CARBON CARBON CARBON 1K 47K 330 47K 820 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/2W 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1W 1/4W 1/4W 1/4W 1W R569 R570 R571 R572 R573 R577 R578 R581 R582 R591 R592 FUSIBLE CARBON CARBON CARBON CARBON CARBON CARBON CARBON METAL OXIDE CARBON 1 33K 2.2K 22K 10K 10K 33K 68K 3.3K 100K 100K 100K 3.3K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1-249-437-11 1-249-429-11 1-249-437-11 1-249-441-11 1-249-441-11 1-247-807-31 1-247-897-11 1-249-435-11 1-249-435-11 1-249-441-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 47K 10K 47K 100K 100K 100 560K 33K 33K 100K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2SC1841TP-PAFAEA 2SA988TP-PAFAEA 2SC1841TP-PAFAEA 2SC2785TP-FEK 2SC2785TP-FEK 2SC2785TP-FEK 2SC2785TP-FEK 2SC2785TP-FEK 2SC2785TP-FEK 2SA1175TP-HFE 2SC2785TP-FEK 2SA1175TP-HFE 2SC2785TP-FEK 2SC1841TP-PAFAEA 2SC1841TP-PAFAEA R542 R545 R546 R547 R548 R551 R552 R553 R554 R555 R556 R557 0 R558 R559 0 R561 R564 R565 R566 R567 R568 1-249-441-11 1-249-417-11 1-249-433-11 1-249-437-11 1-249-437-11 1-249-417-11 1-249-437-11 1-249-411-11 1-249-437-11 1-249-416-11 1-249-435-11 1-249-441-11 1-234-798-11 1-260-076-11 1-212-881-11 1-249-433-11 1-249-433-11 1-249-429-11 1-249-429-11 1-249-429-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 100K 1K 22K 47K 47K 1K 47K 330 47K 820 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W F 1/4W 1/4W 1/2W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W Part No. Description 56K 47K 22K 22K 330K 100K 47K 560 680 560 680 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2W (GN700) 2W (GX8800) 2W (GN700) 2W (GX8800) 1/4W 8-719-991-33 DIODE 1SS133T-72 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-510-68 8-719-500-60 8-719-991-33 8-719-991-33 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 1SS133T-72 D5SBA204101 D5SBA20 1SS133T-72 1SS133T-72 1-249-438-11 CARBON 1-249-437-11 CARBON 1-249-433-11 1-249-433-11 1-247-891-00 1-249-441-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON 1-216-455-11 METAL OXIDE 1-215-891-11 METAL OXIDE 1-216-455-11 METAL OXIDE 1-215-891-11 METAL OXIDE 1-249-441-11 CARBON < EARTH TERMINAL > * EP501 * EP502 1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH CARBON 33K 5% CARBON 100K 5% ENCAPSULATED COMPONENT CARBON 10 5% FUSIBLE 100 5% CARBON CARBON CARBON CARBON CARBON 22K 22K 10K 10K 10K 5% 5% 5% 5% 5% CARBON 33K 5% CARBON 100K 5% ENCAPSULATED COMPONENT CARBON 10 5% FUSIBLE 100 5% 1-249-441-11 CARBON < RELAY > RY501 RY502 1-515-920-11 RELAY 1-515-920-11 RELAY < THERMISTOR > TH501 TH502 1-807-796-11 THERMISTOR 1-807-796-11 THERMISTOR 1-249-441-11 CARBON 1-249-441-11 CARBON 1-215-872-11 METAL OXIDE The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 69 HCD-GN700/GX8800 POWER AMP Ref. No. Part No. SENSOR Description < TERMINAL > SUB TRANS Remarks Ref. No. SW Part No. TRANS Description VOLUME Remarks 1-687-669-11 SW BOARD ********** < SWITCH > S751 1-786-514-11 SWITCH, LEVER (SLIDE) (LEVER) ************************************************************* 1-686-930-11 TRANS BOARD ************* < CAPACITOR > C941 1-128-576-11 ELECT < CONNECTOR > CN997 * CN998 0.01uF 100uF 2200uF 0.1uF 0.1uF 0.1uF 20% 20% 20% 250V 16V 16V 50V 50V 50V 1-564-509-11 PLUG, CONNECTOR 6P 1-564-510-11 PLUG, CONNECTOR 7P < DIODE > D977 8-719-024-99 DIODE 11ES2-NTA2B < FUSE HOLDER > FH9741 FH9742 FH9751 FH9752 FH9761 FH9762 FH9771 FH9772 FH9781 FH9782 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 1-533-233-11 FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER FUSE HOLDER < RESISTOR > 0 R941 0 R952 0 R954 1/4W 1/4W 1/2W (GX8800) ************************************************************* A-4731-329-A VOLUME BOARD, COMPLETE ************************ < CAPACITOR > C614 C615 C750 C751 C752 1-162-294-31 1-124-589-11 1-164-159-11 1-164-159-11 1-164-159-11 CERAMIC ELECT CERAMIC CERAMIC CERAMIC < CONNECTOR > 0.001uF 47uF 0.1uF 0.1uF 0.1uF 10% 20% 50V 16V 50V 50V 50V 1-217-637-00 FUSIBLE 1-219-120-11 FUSIBLE 1-219-237-91 SOLID 1 0.15 3.3M 5% 5% 20% 100uF 20% 63V 1-694-877-11 TERMINAL BOARD (8P) (FRONT/SURROUND SPEAKER) ************************************************************* 1-687-132-11 SENSOR BOARD ************** < CONNECTOR > CN731 1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE)3P ************************************************************* A-4731-346-A SUB TRANS BOARD, COMPLETE (GN700) A-4733-069-A SUB TRANS BOARD, COMPLETE (GX8800) ************************** < CAPACITOR > 0 C971 C973 C975 C976 C977 C978 1-113-925-11 1-126-933-11 1-126-768-11 1-164-159-11 1-164-159-11 CERAMIC ELECT ELECT CERAMIC CERAMIC TM501 1-164-159-11 CERAMIC < CONNECTOR > CN971 CN971 CN974 CN976 1-568-106-11 1-564-321-00 1-564-321-00 1-506-469-11 PIN, CONNECTOR(3.96MM PITCH)4P (GN700) PIN, CONNECTOR(3.96MM PITCH)2P (GX8800) PIN, CONNECTOR(3.96MM PITCH)2P PIN, CONNECTOR 4P < DIODE > D971 D972 D973 D974 D975 8-719-991-33 8-719-024-99 8-719-024-99 8-719-024-99 8-719-024-99 DIODE DIODE DIODE DIODE DIODE < IC > 1SS133T-72 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B IC971 6-703-546-01 IC TA7804LS < TRANSISTOR > Q971 8-729-119-79 TRANSISTOR 2SC2785TP-FEK < RESISTOR > R974 R975 1-249-441-11 CARBON 1-249-429-11 CARBON < RELAY > 100K 10K 5% 5% 1/4W 1/4W 0 RY971 0 RY971 1-755-497-11 RELAY 1-755-276-11 RELAY, POWER < SWITCH > (GX8800) (GN700) CN605 1-568-860-11 SOCKET, CONNECTOR 17P < DIODE > 0 S901 1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECTOR) (GN700) < TRANSFORMER > D1001 D1002 D1003 6-500-529-01 DIODE SLI-325URT31W (VOL 1) 6-500-529-01 DIODE SLI-325URT31W (VOL 2) 6-500-529-01 DIODE SLI-325URT31W (VOL 3) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 0 T972 1-437-675-11 TRANSFORMER, POWER (GX8800) 0 T972 1-435-825-11 TRANSFORMER, POWER (GN700) ************************************************************* 70 HCD-GN700/GX8800 VOLUME Ref. No. D1004 D1005 D1006 D1007 D1008 D1009 D1010 D1011 Part No. Description Remarks Ref. No. S760 S761 S762 S763 S765 S766 S767 Part No. Description Remarks 6-500-529-01 DIODE SLI-325URT31W (VOL 4) 6-500-529-01 DIODE SLI-325URT31W (VOL 5) 6-500-529-01 6-500-529-01 6-500-529-01 6-500-529-01 6-500-529-01 DIODE DIODE DIODE DIODE DIODE SLI-325URT31W (VOL 6) SLI-325URT31W (VOL 7) SLI-325URT31W (VOL 8) SLI-325URT31W (VOL 9) SLI-325URT31W (VOL 10) 1-762-875-21 SWITCH, KEYBOARD (P.FILE) 1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION) 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (GAME EQ) SWITCH, KEYBOARD (GROOVE) SWITCH, KEYBOARD (EDIT/DIRECTION) SWITCH, KEYBOARD (FM MODE/REPEAT) SWITCH, KEYBOARD (TUNER MEMORY/PLAY MODE) 6-500-529-01 DIODE SLI-325URT31W (VOL 11) < IC > S768 1-762-875-21 SWITCH, KEYBOARD (AMP MENU) S769 1-762-875-21 SWITCH, KEYBOARD (MUSIC EQ) S770 1-762-875-21 SWITCH, KEYBOARD (MOVIE EQ) S771 1-762-875-21 SWITCH, KEYBOARD (EFFECT ON/OFF) S773 1-786-528-11 SWITCH, ROTARY ( Q1001 Q1002 Q1003 Q1004 Q1005 Q1006 8-729-116-02 8-729-116-02 8-729-116-02 8-729-116-02 8-729-116-02 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR BA1A4M-TP BA1A4M-TP BA1A4M-TP BA1A4M-TP BA1A4M-TP 8-729-116-02 TRANSISTOR BA1A4M-TP < RESISTOR > R625 R750 R759 R760 R761 R762 R763 R765 R766 R767 R768 R769 R770 R771 R772 R773 R774 R775 R776 R777 R1001 R1002 R1003 R1004 R1005 R1006 R1007 R1008 R1009 R1010 R1011 1-249-401-11 1-249-410-11 1-249-427-11 1-249-429-11 1-249-431-11 1-249-433-11 1-249-435-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-425-11 1-249-427-11 1-249-429-11 1-249-431-11 1-249-433-11 1-249-435-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 1-249-413-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 47 270 6.8K 10K 15K 22K 33K 470 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 10K 15K 22K 33K 470 470 470 470 470 470 470 470 470 470 470 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W F F F F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F F F F F F 1-471-035-11 MAGNET ASSY 1-533-454-11 FUSE, GLASS TUBE (DIA. 5) (6.3A 125V) (GX8800) 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V) (GN700) 1-533-454-11 FUSE, GLASS TUBE (DIA. 5) (6.3A 125V) (GX8800) 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V) (GN700) 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (8A 125V) (GX8800) 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (T8AL 250) (GN700) 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (8A 125V) (GX8800) 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (T8AL 250) (GN700) 1-533-452-11 FUSE, GLASS TUBE (DIA. 5) (4A 125V) (GX8800) 1-533-471-11 FUSE, GLASS TUBE (DIA. 5) (T4AL 250V) (GN700) A-4723-963-A MOTOR ASSY, TABLE A-4737-553-A MOTOR ASSY, LOADING 1-763-072-11 FAN, DC 1-477-680-11 ENCODER, ROTARY 1-439-555-11 POWER TRANSFORMER (GN700) 1-439-617-11 POWER TRANSFORMER (GX8800) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 0 F976 0 F976 0 F977 0 F977 0 F978 0 F978 M741 M751 M891 RE701 0 T910 0 T910 1-249-413-11 CARBON < SWITCH > 1/4W F S748 S750 S759 1-476-504-11 ENCODER, ROTARY (VOLUME) 1-762-875-21 SWITCH, KEYBOARD (DISPLAY) 1-762-875-21 SWITCH, KEYBOARD (SURROUND SPEAKER MODE) 71 HCD-GN700/GX8800 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2003.04 New Description of Revision


Comments

Copyright © 2025 UPDOCS Inc.