electrico 793 c

Component Identifier (CID) For VIMS Current¹ CID No. 0041 0075 0091 0096 0098 0100 0101 0102 0110 0127 0168 0171 0177 0190 0248 0253 0254 0261 0262 0263 0267 0268 0269 0271 0272 0273 0274 0275 0276 0277 0278 0279 0280 0291 0292 0295 0296 0298 0324 0341 0350 0351 0352 0353 0354 0355 0356 0357 0358 0359 0360 0361 0363 0364 0365 0367 0370 0371 0372 0373 0374 0376 0377 0378 0379 0423 0424 0425 0426 0427 0428 0429 0430 0431 0432 0433 0434 0436 0438 0439 0440 0444 0457 0458 0459 0489 0490 0499 0526 0533 0541 0542 0544 0545 0546 0548 0558 0559 0562 0569 0580 0581 0590 0592 0593 0594 0595 0596 0600 0621 0623 0626 0627 0628 0641 0642 0643 0644 0645 0646 0650 0654 0655 0656 0657 0658 0659 0670 0671 0672 0678 0679 0700 0701 0702 0703 Component 8 Volt Sensor Power Supply Steering Oil Temperature Sensor Throttle Position Sensor Fuel Level Sensor Engine Oil Level Sensor Engine Oil Pressure Sensor Crankcase Air Pressure Sensor Boost Pressure Sensor Engine Coolant Temperature Sensor Transmission Oil Pressure Sensor Electrical System Voltage Ambient Air Temperature Sensor Transmission Oil Temperature Sensor Engine Speed Sensor CAT Data Link Personality Module (Engine Control) Electronic Control Module (ECM) Engine Timing Calibration 5 Volt Sensor Power Supply 8 Volt (or 12 Volt) Sensor Power Supply Engine Shutdown Switch (Remote) Programmable Parameters (Engine Control) Sensor Power Supply Action Alarm Turbocharger Outlet High (Overboost) Pressure Sensor Turbocharger Outlet Pressure Sensor Atmospheric (Barometric) Pressure Sensor Right (Bank) Turbocharger Inlet Pressure Sensor Left (Bank) Turbocharger Inlet Pressure Sensor Timing Calibration Sensor AESC Enable Lamp Aftercooler Coolant Temperature Sensor (Front) Gear Box Temperature Sensor Engine Coolant Cooling Fan Solenoid Hydraulic Oil Cooling Fan Solenoid HEX Electronic Control Module Transmission Electronic Control Module Service Brake Pedal Switch Action (Warning) Lamp Hydraulic Control Valve Warm Up Solenoid #4 Lift Linkage Position Sensor Tilt Linkage Position Sensor Lift Lever (Cab) Sensor Tilt Lever (Cab) Sensor Lift Raise Solenoid #1 Lift Lower Solenoid #1 Tilt Dump Solenoid #1 Tilt Rackback Solenoid #1 Pilot Pressure Solenoid (Supply) Lift Raise Kickout Solenoid Lift Lower Kickout Solenoid Tilt Kickout Solenoid Machine Ride Control Actuator Lift Cylinder Head Pressure Sensor Kickout Set Switch Ride Control Switch Boom Float Solenoid Horn Solenoid (Forward) Bucket/Shovel Open Solenoid Bucket/Shovel Close Solenoid Swing Brake Solenoid Travel Alarm (Solenoid/Switch) Travel Brake Solenoid Machine Autolube Solenoid Machine Autolube Pressure Sensor Front Brake Accumulator Pressure Switch Rear Brake Accumulator Pressure Switch Front Brake Oil Pressure Sensor Rear Brake Oil Pressure Sensor Front Axle Oil Temperature Sensor Rear Axle Oil Temperature Sensor Steering Pump Oil Pressure Sensor Steering Pilot Pressure Sensor Steering Oil Level Switch Steering Filter By-Pass Switch Implement Filter Switch Hydraulic Pilot Oil Pressure Sensor Torque Converter Oil Pressure Sensor Hydraulic Control Valve Warm Up Solenoid #1 Hydraulic Control Valve Warm Up Solenoid #2 Hydraulic Control Valve Warm Up Solenoid #3 Start Relay Brake Oil Temperature Sensor Tilt Cylinder Rod Pressure Sensor Impeller Clutch System Switch Implement Select Switch Implement Lockout Switch Implement Variable Hydraulic Oil Pump Solenoid Turbocharger Wastegate Valve Auto Retarder Control (ARC) Differential (Axle) Oil Pressure Sensor Engine Oil Pressure-Unfiltered Sensor Engine (Coolant Cooling) Fan Speed Sensor Ether Start Relay Ether Injection Hold Relay Throttle Lock Lamp Autolube Relay Boom Float Relay Caterpillar Monitoring System Oil Injection Solenoid Power Shift Pressure Sensor Power Shift Solenoid Engine Electronic Control Module Lift Raise Solenoid #2 Lift Lower Solenoid #2 Tilt Rackback Solenoid #2 Tilt Dump Solenoid #2 Implement Electronic Control Module Hydraulic Oil Temperature Sensor Downshift Switch Directional Switch Steering/Transmission Lock Switch Parking Brake Pressure Switch Quickshift Switch Transmission Solenoid #1 Transmission Solenoid #2 Transmission Solenoid #3 Transmission Solenoid #4 Transmission Solenoid #5 Transmission Solenoid #6 Harness Code Trailer Right Brake Oil Temperature Sensor Trailer Left Brake Oil Temperature Sensor Trailer Brake Oil Cooler Inlet Temperature Sensor Trailer Brake Oil Cooler Temperature Sensor Trailer Right Suspension Cylinder Pressure Sensor Trailer Left Suspension Cylinder Pressure Sensor Torque Converter Pedal Position Sensor Transmission Output Speed Sensor Torque Converter Output Speed Sensor Torque Converter Impeller Clutch Solenoid Torque Converter Lockup Clutch Solenoid Transmission Gear Actuator Sensor Transmission Output Speed Sensor Transmission Gear Selector Switch Trailer Door Position Sensor 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 01 02 03 04 05 Component Identifier (CID) For Transmission Control EPTC ll (Only For MID No. 27) CID No. 168 190 248 269 627 650 672 700 701 702 704 705 706 707 708 709 Component Location Component Alarm - Backup (Rear) Alarm - VIMS Action 11 Wire Description Component Schematic Location B-15 C-6 D-4 A-15 C-4 C-4 C-5 C-5 A-15 A-15 C-6 B-12 G-6 F-1 C-7 C-11 C-11 A-9 E-13 D-13 D-12 D-13 C-7 C-2 C-2 C-3 C-7 B-9 B-7 A-9 C-3 D-5 B-12 B-12 B-12 H-2 A-5 B-8 E-6 F-7 I-5 G-6 G-6 A-11 D-13 D-13 D-14 D-14 H-6 A-15 A-15 A-15 D-3 E-2 E-3 A-5 F-1 A-6 E-2 A-5 F-4 A-14 A-14 H-6 E-2 G-1 I-4 I-6 E-2 A-14 D-2 H-15 H-15 H-15 F-15 I-14 F-15 I-14 B-13 A-14 E-15 B-6 I-6 I-6 A-14 A-13 G-7 F-3 F-1 A-10 G-14 I-5 I-5 G-2 I-12 G-2 A-10 A-13 Machine Location 29 30 A 31 18 18 18 18 32 33 30 34 C 13 4 14 14 35 E 36 36 36 18 7 7 18 18 35 18 38 18 39 37 37 37 B 4 4 A A F B C 40 41 41 42 42 G 43 43 44 13 G A 3 13 15 G 15 A 36 36 C 13 G F C G 45 G E E E E C E C 46 47 E 30 C C 45 34 C A 13 30 E F F B E B 48 49 Schematic Location C-14 H-5 C-7 C-7 D-15 D-3 H-9 H-9 H-8 H-8 H-8 H-9 H-9 H-9 H-8 H-9 H-9 H-8 H-9 H-8 H-9 H-7 H-8 H-9 H-9 H-9 H-8 H-7 H-8 H-8 G-14 A-3 I-15 I-13 B-11 F-4 F-11 H-2 D-12 D-3 D-2 F-2 A-7 I-10 B-7 I-10 G-2 I-2 H-6 E-5 A-15 D-15 A-6 F-2 I-13 H-10 E-15 H-10 D-12 D-13 A-7 D-13 D-13 D-13 D-14 D-13 E-7 E-12 E-2 E-15 E-13 E-13 A-7 C-6 C-3 H-1 C-4 A-12 C-4 D-10 D-15 A-15 D-13 D-13 C-4 D-15 B-15 C-3 C-3 C-7 C-3 C-9 G-7 A-7 C-4 C-4 B-12 C-15 B-7 B-7 Machine Location 1 2 3 4 5 6 D D D D D D D D D D D D D D D D D D D D D D D D E 7 C D 8 C E B E 9 10 B 11 12 11 12 B 13 C F 1 1 15 G E E E E E E E E E E E E F E G E E E 4 7 16 17 7 5 18 E 19 20 21 21 18 22 22 17 17 23 23 24 D 25 18 18 26 27 27 28 Wire Number 101 102 103 104 105 107 109 112 113 115 120 121 122 123 124 126 132 135 139 149 150 160 170 176 Wire Color RD BU YL YL BR WH OR PU OR PK YL YL BU WH GN PK PK BU OR PU RD PU YL OR Bat(+) Hd Lmp Aux Ckt Aux Ckt Key Sw Eng Shut - Down Alt Output (+) Term. Description Power Circuits Wire Number 700 703 704 705 706 707 708 709 710 711 712 713 714 715 716 720 721 722 723 724 725 726 767 768 Wire Color PK BU GY PK BR PU YL OR GN BR WH OR YL GN BU PU BR WH OR PU GN BU WH OR BU GN BR GY YL BR PU OR GY PU BR GN BU GY PU BR OR GY PU BR GN BU GY PU PK GY YL GN PK WH BU GN PU GN YL YL BR BU YL YL GN WH PK BR BU BR GN GY OR PK WH YL BU BR OR PK PU WH YL BU BR GN GY OR PK PU WH YL BU BR GN GY OR PK PK YL GN BR GN GY PU PK PU WH GY OR GN PK GY YL PK PU BU OR PK GY BR GN BR WH BR GY BU GN OR BR WH BU YL OR GN PU YL BR BU GY BR PK WH BU OR PU GN OR GN AETA Test SW XMSN Up Sol XMSN Down Sol Description Control Circuits SENR1480-01 May 1998 Sensor - Strut Right (Rear) Sensor - TIC Temp Sensor - Throttle Position Sensor - Transmission Oil Temp Sensor - Turbo Exhaust Temp (Left) Sensor - Turbo Exhaust Temp (Right) Sensor - Turbo Pressure (Left) Sensor - Turbo Pressure (Right) Sensor - Wheel Speed (Left) Sensor - Wheel Speed (Right) Sensor-XMSN In Speed Sensor - XMSN Speed Service Hour Meter Shutdown - Ground Level Solenoid - A/C Compressor Clutch Solenoid - AETA 4 Way Solenoid - AETA Proportional Solenoid - Air Start Solenoid - Auto Lube Solenoid - Body Float Solenoid - Body Lower Solenoid - Body Raise Solenoid - Cont Oil Burn Injector Solenoid - Cylinder Head (1, 3, 5, 7, 9, 11) Solenoid - Cylinder Head (2, 4, 6, 8, 10, 12) Solenoid - Engine Fan Clutch Solenoid - Fan Brake Solenoid - Shutter Solenoid - Start Aid Solenoid - Steering Bleed Solenoid - Wastegate Proportional Solenoid - Wastegate Shutoff Solenoid - XMSN Down Shift Solenoid - XMSN Lockup Solenoid - XMSN Up Shift Speedo/Tach Cluster Switch - A/C High Pressure Engine Fan Clutch Override Switch - A/C Pressure Switch - A/C Thermostat Switch - AC/Heater Blower Switch - Arc Pressure Switch - Auto Retarder ON/OFF Switch - Backup Lamp Switch - Brake Cooling Filter Switch - Brake Cylinder Overstroke (Front Inside) Switch - Brake Cylinder Overstroke (Front Outside) Switch - Brake Cylinder Overstroke (Rear Inside) Switch - Brake Cylinder Overstroke (Rear Outside) Switch - Brake Retract ON/OFF Switch - Differential Filter Plug (Rear) Switch - Differential Oil Level (Left Rear) Switch - Differential Oil Level (Right Rear) Switch - Disconnect Switch - Dome Lamp (Dash) Switch - Dome Lamp (Door) Switch - Engine Coolant Switch - Engine Flood Lamp Switch - Engine Very Low Oil Level Switch - Fog Lamp Switch - Fuel Filter Pressure Switch - Headlamp Dimmer Switch - Hoist Screen (Inside) Switch - Hoist Screen (Outside) Switch - Key Start Switch - Ladder Lamp Switch - Ladder Lamp Switch - Manual Retard Pressure Switch - Manual Start Aid Switch - Panel Dimmer Switch - Park Brake Filter Switch - Running Lamp Switch - Secondary Brake (Parking) Switch - Service Brake (Retarder) Switch - Service Brake (Retarder) Switch - Service Clear (ARC) Switch - Service Clear (EPTC-ll) Switch - Service Set (ARC) Switch - Service Set (EPTC-ll) Switch - Steering Pressure (High) Switch - Steering Pressure (Low) Switch - Stop Lamp Pressure Switch - T/C Screen Switch - TCS Test Switch - Throttle Backup Switch - Torque Converter Inlet Filter Switch -Transmission Actual Gear Switch - Transmission Cane Position Switch - Turn/Hazard Signal Switch - VIMS Service Key Switch - XMSN Charge Filter Traction Control System Valve - Arc Control Valve - Arc Supply VIMS Keypad Module VIMS Main Module VIMS Message Center VIMS Sensor Module VIMS Sensor Module Component Electrical System Voltage Engine RPM Sensor CAT Data Link Sensor Power Supply Parking Brake Switch Harness Code Torque Converter Output Speed Sensor Actual Gear Switch Tramsmission Output Speed Sensor Shift Lever Switch Service Brake Pressure Switch Body Raise Switch Body Up Switch Up Solenoid Down Solenoid Lockup Solenoid F 2 66 62 58 C B A G 64 D 12 9 E 24 17 13 38 3 25 16 7 15 56 4 8 35 39 18 23 60 48 40 30 41 52 42 50 19 5 43 27 32 49 65 10 26 57 46 47 21 51 36 14 20 31 34 37 22 1 33 29 44 28 45 6 Alternator Arc Suppressor Arc Suppressor Battery Breaker - A/C (15A) Breaker - Accessory Lamp (15A) Breaker - Air Dryer (10A) Breaker - Alternator (105) Breaker-Arc (1OA) Breaker - Backup Alarm (10A) Breaker - Brake Retract (20A) Breaker - Converter (20A Breaker - Engine ECM (15A) Breaker - Engine Shutdown (10A) Breaker - Flood Lamp (15A) Breaker - Gauges (10A) Breaker - Head Lamp (15A) Breaker - Hoist Control (10A) Breaker - Key Switch (10A) XMSN Lockup Clutch Sol Basic XMSN Retarder SW XMSN Bed Raise SW XMSN Hold SW Sensor Power Supply XMSN Speed Pickup Signal Main Power Rly Output VIMS B+ Switched Aux Ckt Aux Ckt Back Alarm To Lamp Aux Ckt Aux Ckt A/C Xmsn Ctrl Aeta Ctrl Aux Ckt Aux Ckt Aux Ckt Bat (+) Aux Ckt Aux Ckt Aux Ckt Ground Circuits XMSN Lever Code 2 XMSN Lever Code 3 XMSN Lever Code 4 XMSN Lever Code 5 XMSN Lever Code 6 XMSN Brake SW XMSN Gear Code 1 XMSN Gear Code 2 XMSN Gear Code 3 XMSN Gear Code 4 XMSN Gear Code 5 XMSN Gear Code 6 AETA Pickup Power AETA Pickup XMSN Wheel Speed Pickup Left Wheel Speed Pickup Right AETA Retarder SW AET A Servovalve AETA Sol- Left AETA Sol- Right Brake Release Motor Digital Sensor Power(+8V) Injector #1 Injector #2 Injector #3 Injector #4 Injector #5 Injector #6 Injector #7 Injector #8 Injector #9 Injector #10 Injector #11 Injector #12 Injector #13 Injector #14 Injector #15 Injector #16 Turbo Outlet Pressure Atmospheric Pressure After Cooler Temp VIMS Display +V VIMS Display Clock VIMS Service Lamp VIMS LCD Lamp Driver Fan Brake Relay To Fan Brake Sol Body Position Sensor Signal Sensor Module #3 - CAT link Right + Sensor Module #3 - CAT link Right LeftAETA Relay Sol To VIMS Right AETA Relay Sol To VIMS ATA Data linkAT A Data Link + Crankcase Press Oil Press (Unfiltered) PWM #3 Return PWM #3 PWM #1 And #2 Return PWM #1 Out (3.5A) PWM #2 Out (3.5A) Throttle Lh Turbine Inlet Exh Temp Rh Turbine Inlet Exh Temp Dout 6 Start Aid Current Level Relay Dout Dout Start Aid On Relay Left Turbo Inlet Press Right Turbo Inlet Press Shutdown (No) Shutdown (Nc) SW4 SW5 SW 6/1 SW 8/3 SW 9/4 SW 10/5 TDC Probe + TDC Probe Fuel Press Injector Common 1 & 3 Injector Common 2 & 4 Injector Common 5 & 7 Injector Common 6 & 8 Injector Common 9 & 11 Injector Common 10 & 12 Backup Camshaft Spd/Tmg(Marine) Parking Brake SW Body Raise Sol Body Lower Sol Float Indicator Body Hoist SW - Lower Body Hoist SW - Float Body Hoist SW - Roading Relay Coil Oil Cooler Motor Injector Common Injector Common VIMS Sensor Module #2 Right (+) Comm VIMS Sensor Module #2 Right (-) Comm Oil Resistor To Relay Auto Lube Sol Or Motor Payload Mon Right Front Sensor Payload Mon Left Front Sensor Payload Mon Right Rear Sensor Payload Mon Left Rear Sensor VIMS RS 232 Port Trans VIMS RS 232 Port Receive VIMS Sensor Module Rt (-) Com Port/Cat Datalink VIMS Sensor Module Rt (+) Com Port/Cat Datalink + VIMS Start Mod Right (-) Port/CAT Data Link (-) VIMS Start Mod Right (+) Port/CAT Data Link (+) Relay Logic Large Pump Relay Logic Analog Sensor Common Oil Pressure (Filtered) Coolant Temperature Engine Speed/Timing Sensor Power Analog Sensor Power (+ 5V) Digital Sensor Return Primary Camshft Speed/Timing SPI Datalink End Continuous OilInjector Solenoid VIMS - Sensor Mod 2 + 8V Supply Stick 2 Bypass Sol EPTCII Clear Switch EPTCII Set SW EPTC-II Start Relay Return VIMS Sensor Module 1 - +8V Supply Start Aid Timer Output Auto Retard On SW Auto Regard Off SW Auto Retard Air Cont Valve Auto Retard Air Supply Valve Auto Retard Press SW Auto Retard Manual Retard SW VIMS Aftercooler Coolant Level VIMS Jacket Coolant Level Auto Retard Cont Resume SW T Component Identifier (CID) For Engine Control (Only For MID No. 36) CID No. 001 002 003 004 005 006 007 008 009 010 011 012 013 014 015 016 091 100 110 168 190 248 253 261 262 263 267 268 272 273 274 275 276 281 282 283 284 285 286 Breaker - Oil Cooler Breaker - Radio/Lighter (15A) Breaker - Shuttles (10A) Breaker - Start Aid (20A) Breaker - Stop/Turn/Dome (15A) 53 54 53 54 Component Cylinder 1 Injector Solenoid Cylinder 2 Injector Solenoid Cylinder 3 Injector Solenoid Cylinder 4 Injector Solenoid Cylinder 5 Injector Solenoid Cylinder 6 Injector Solenoid Cylinder 7 Injector Solenoid Cylinder 8 Injector Solenoid Cylinder 9 Injector Solenoid Cylinder 10 Injector Solenoid Cylinder 11 Injector Solenoid Cylinder 12 Injector Solenoid Cylinder 13 Injector Solenoid Cylinder 14 Injector Solenoid Cylinder 15 Injector Solenoid Cylinder 16 Injector Solenoid Throttle Position Sensor Engine Oil Pressure Sensor Coolant Temperature Sensor Electrical System Voltage Engine RPM Sensor CAT Data Link Personality Module Mismatch Timing Calibration Analog Sensor Power Supply Digital Sensor Power Supply Shutdown Inputs Are Incorrect Programmed Parameter Fault Turbo Outlet Pressure Calibration Turbo Outlet Pressure Calibration Atmospheric Pressure Calibration Turbo Inlet Calibration Turbo Inlet Calibration Engine Lamp Overspeed Lamp Filter Restrict Lamp EMS Engine On EMS Coolant Lamp EMS Oil Lamp 24 13 62 65 66 15 38 17 4 3 8 46 35 6 58 56 7 16 47 10 25 F B C 2 18 57 11 64 D 12 23 21 48 60 30 45 40 41 52 51 42 36 50 49 14 19 20 22 31 34 37 43 44 33 32 5 E 1 G A 26 39 9 REAR COMPARTMENT (AREA E) REAR VIEW 769 770 772 773 774 775 777 A701 A701 A702 A703 A704 A705 A706 A707 A708 A709 A710 A711 A712 A713 A714 A715 A716 A746 A747 A751 E707 E708 E709 E710 E729 E750 E776 E777 E791 E792 E793 E794 E795 E796 E797 E798 E799 F700 F701 F702 F703 F704 F705 F707 F708 F709 F710 F713 F714 F715 F716 F717 F718 F719 F720 F721 F722 F723 F724 F725 F726 F727 F728 F729 F730 F731 F732 F780 G704 G705 G711 G712 G713 G714 G736 G769 G770 H700 H701 H734 801 858 859 860 861 875 876 882 883 892 893 956 958 993 994 995 996 997 998 999 E972 E986 F975 K933 K964 Breaker - Traction Control (10A) Breaker - VIMS (15A) 200 201 202 205 212 213 214 215 216 217 218 219 227 229 231 280 A215 A216 A217 A218 A251 A252 A253 A254 A255 A271 BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK BK Main Chassis Operator Monitor Return XMSN Ctrl Instr AETA Coding AETA Coding AETA Coding AETA Coding AETA Coding XMSN Id Code 2 XMSN Id Code 1 XMSN Id Code 0 XMSN Id Code 3 Bat (-) XMSN SW XMSN Ctrl Ident Code 4 Auto Retarder Ctrl Harness Code 0 Auto Retarder Ctrl Harness Code 1 Auto Retarder Ctrl Harness Code 2 Auto Retarder Ctrl Harness Code 3 VIMS Ser Mod #1 VIMS Ser Mod #2 VIMS Ser Mod #3 ARC AETA Oil Cooler Control Ground Basic Machine Circuits 793C Off-Highway Truck Electrical System 4AR218-UP 59 61 55 59 61 55 REAR COMPARTMENT SIDE WALL (AREA J) RIGTH SIDE VIEW Breaker - VIMS Modules (10A) Breaker - XMSN Control (10A) Control - Auto Retarder Control - Engine ECM Control - EPTC-ll Transmission Control - Steering Bleed Dryer - Air System Flasher - Solid State Frame Stress Monitor Gauge Cluster Ground Boss (Rear) Lamp - Cab Dome Lamp - Ladder Flood Lamp - Panel SENR1480-01 Printed in U.S.A. 1 2 Typical representation of a Sure-Seal connector. The plugand receptacle contain both pins and sockets. Component Part Number 9X-1123 27 29 Lamp - Payload Monitor (Green) Lamp - Payload Monitor (Green) Lamp - Payload Monitor (Red) Lamp - Payload Monitor (Red) Lamp - Retarder On Lamp - VIMS Action Lighter Motor - AC/Heater Motor - Brake Retract Motor - Oil Cooler Fan Motor - Prelubrication Power Connection - Radio Power Converter (15A) Relay - Alarm/Light Relay - Hoist Float/Engine Oil Burn Relay - Main Power Relay - Oil Cooler Fan (High) Relay - Oil Cooler Fan (Low) Relay - Prelubrication Main Power Relay - Prelubrication ON/OFF Relay - Shutter/Fan ON/OFF Relay - Start Aid Hold Relay - Start Aid Pull In Relay - Stop Lamp Resistor - Blower Motor Resistor - Differential Oil Cooler Low Speed (Rear) 28 Machine Harness Connector and Component Locations 306 307 308 315 317 321 326 327 337 GN OR YL GN YL BR BR PK WH Starter Relay Coil To Neut Start SW Or Key SW Key SW To Neutral Start SW Or VIMS Sensor Module Main Power Relay Coil Start Aid Breaker To Start Aid Relay Start Aid Relay To Start Aid Sol Backup Alarm Lamp Travel Alarm Key SW "C" Term. Shutdown Solenoid Prelube Pushbutton SW To Prelube Timer Monitoring Circuits © 1998 Caterpillar, All Rights Reserved Harness And Wire Electrical Schematic Symbols A 1 AA 1 2 Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins. 403 408 410 411 412 417 419 425 426 428 429 447 450 452 454 473 474 481 A451 A491 A492 A493 A494 C413 C414 C415 C419 C420 C428 C429 C453 C463 C466 C467 C473 C484 C485 F418 F419 F433 F447 G427 GN WH WH PK BU OR YL PK BR OR YL PK YL PU GN GY WH GN WH GN WH OR YL YL BU WH GN BU GN GY YL GY YL BU GN YL YL GN YL PU PU BU Alternator (R) Term. Opr Mon System Air Press. Opr Mon Action Alarm Opr Mon Master Opr Mon Cool Flow/ Primary Ster SW Opr Mon Parking Brake Opr Mon Power Train Oil Level Opr Mon Power Train Oil Filter Opr Mon Xmsn Oil Temp Opr Mon Brake Oil Temp Fuel Level Gauge Tach Sender (+) Torque Converter Retarder Indicator Lamp Overstroke SW To Overstroke SW Overstroke SW To Overstroke SW Converter Temp SW To Brake Oil Temp SW Opr Mon Steering OII Temp Overstroke SW To Overstroke SW Trans Supply SW To Torque Conv Inlet Filter SW Hoist Filter SW To Hoist Filter SW Hoist Filter SW To T.C. SW VIMS Display Data VIMS Display Load VIMS Display Keydata Load Share Select Input Diode To Lamp Test Relay Brake Cooling Filter SW Differential Oil Temp Ambient Temp Aftercooler Temp Gauge LF Brake Oil Temp LR Brake Oil Temp Rear Pump Press Rear Differential Filter Press SW Exhaust Temp VIMS RS232 Port 2 Trans VIMS RS232 Port 2 Receive Brake Temp Steering HI Press SW To LO Press SW T/C Inlet Filter SW To Hoist Screen SW Lighting Circuits Connector Location Connector Number CONN 1 Schematic Location A-15 C-15 C-15 F-15 C-14 F-14 F-14 H-14 H-14 H-14 C-13 C-14 A-12 B-12 C-12 C-12 D-12 H-12 D-11 D-10 G-10 G-10 B-9 I-9 I-9 I-9 A-8 B-8 B-8 B-8 B-8 D-8 C-6 D-6 F-6 E-4 E-5 G-4 G-4 F-2 G-2 I-2 I-2 E-1 H-1 Machine Location 20 29 27 E 50 E E E E E 20 51 34 50 52 52 53 E 54 55 E E 20 D D E 56 57 58 58 57 59 60 61 F E E B B 62 62 64 64 65 66 Resistor - Dimmer Resistor - Oil Burn Resistor - Start Aid Resistor - Start Aid Sensor - Aftercooler Coolant Level (ON/OFF) Sensor - Aftercooler Temp (Front) Sensor - Aftercooler Temp (Rear) Sensor - Ambient Air Temp Sensor - Atmospheric Pressure Sensor-Body Up Sensor - Boost Pressure Sensor - Brake Air Pressure Sensor - Brake Oil Temp (Left Rear) Sensor - Brake Oil Temp (Right Rear) Sensor - Brake Temp (Left Front) Sensor - Brake Temp (Right Front) Sensor-Crankcase Pressure Sensor - Differential Oil Temp Sensor - Differential Pump Outlet Pressure (Rear) Sensor - Engine Coolant Temp Sensor - Engine Fan Speed Sensor - Engine Speed (EPTC-II) Sensor - Engine Speed Timing Sensor - Fuel Level Sensor - Hoist Lever Position Sensor - Jacket Water Coolant Level (ON/OFF) Sensor - Oil Pressure Filtered Sensor - Oil Pressure Unfiltered Sensor- Steering Oil Temp Sensor - Strut Left (Rear) Sensor - Strut Pressure (Left Front) Sensor - Strut Pressure (Right Front) Plug 2 Receptacle Component Identifier (CID) For Automatic Retarder Control (Only For MID No. 83) Current¹ CID No. 091 168 190 248 627 650 700 702 710 711 712 713 714 715 CONN 2 CONN 3 CONN 4 CONN 5 CONN 6 CONN 7 CONN 8 CONN 9 CONN 10 CONN 11 CONN 12 CONN 13 CONN 14 CONN 15 CONN 16 CONN 17 CONN 18 CONN 19 CONN 20 CONN 21 CONN 22 CONN 23 CONN 24 CONN 25 CONN 26 CONN 27 CONN 28 CONN 29 CONN 30 CONN 31 CONN 32 CONN 33 CONN 34 N/A CONN 35 CONN 36 CONN 37 CONN 38 CONN 39 CONN 40 CONN 41 CONN 42 CONN 43 CONN 44 CONN 45 1The Component Throttle Position Sensor Electrical System Voltage Engine RPM Sensor CAT Data Link Parking Brake Switch Harness Code Actual Gear Switch Shift Lever Switch ARC Supply Solenoid ARC Control Solenoid Retarder Lamp ARC On/Off Switch Auto Retarder Pressure Switch Retarder Pressure Switch Pin or Socket Number Wire, Cable, or Harness Assembly Identification Single Wire Connector C A 325-PK-14 A 1 AA 325-PK-14 Pin Socket Wire Color 2 200-BK-14 Circuit Number Identification Wire Gauge Electrical Schematic Symbols And Definitions FUSE - A component in an electrical circuit that will open the circuit if too much current flows through it. REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. Failure Mode Indicator And Message Center Displays FMI No. 00 Failure Description Data Valid But Above Normal Operating Range Data Valid But Below Normal Operating Range Data Erratic, Intermittent Or Incorrect Voltage Above Normal Or Shorted High Voltage Below Normal Or Shorted Low Current Below Normal Or Open Circuit Current Above Normal Or Grounded Circuit Mechanical System Not Responding Properly Abnormal Frequency, Pulse Or Period Abnormal Update Abnormal Rate Of Change Failure Mode Not Identifiable Bad Device Or Component Out Of Calibration Not Used Not Used Parameter Not Available Module not Responding Sensor Supply Fault Condition Not Met Not Used Message Center Displays N/A Intermittent Shorted Hi Shorted Lo Lo Amps Open Hi Amps Grounded N/A Out of Range No Response N/A Unknown Error No Response Uncalibrated N/A N/A Not Available No Response Snsr Supply Fault N/A N/A Machine locations are repeated for components located close together. A = Operator Compartment B = Operator Compartment - Front Dash C = Operator Compartment - Console D = Operator Compartment - Behind Seat E = Operator Compartment - Rear Compartment F = Operator Compartment - Front Compartment G = Operator Compartment - Overhead Console SENDER - A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure. 513 517 521 522 529 537 539 540 OR BU YL WH BU GN BU WH A/C Compressor/Refrigerant Pressure SW Blower Motor (Low) A/C SW To Refrigerant SW A/C Clutch To Thermostat SW Washer Left Turn Signal SW To Flasher Turn Signal Indicator Basic/Right Turn Signal Indicator Left Lighting Circuits RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay. CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too much current flows through it. This does not destroy the circuit breaker and it can be reset to become part of the circuit again. SOLENOID - A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latch by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches. connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart. 600 601 602 604 605 606 607 608 610 611 612 614 619 BR GY WH OR YL GY PK GN OR PU GY PU GN WH PU BU GY WH BU GN Dash Lamp Basic Dash Lamp Hi Dome Lamp Stop Lamp Turn Lamp - Left Turn Lamp - Right Flood Lamp - Front Flood Lamp - Rear Head Lamp Basic Head Lamp Hi Backup Lamp Park/T ail/Dash/Lamp Head Lamp Lo Flood Lamp - Front (Eng. Flood Lamp) Flood Lamp 3-Way SW Jumper Flood Lamp 3-Way SW Jumper Fog Lamp - Right Fog Lamp - Left Payload Mon Red Lamp Payload Mon Green Lamp 0704 0705 0706 0707 0708 0709 0710 0711 0712 0713 0714 0715 0800 0801 0802 0803 0804 0805 0806 0807 0808 0809 0810 0811 0812 0813 0814 0815 0816 0817 0819 0820 0821 0822 0823 0824 0825 0826 0827 0828 0829 0830 0833 0835 0838 0839 0840 0841 0849 0851 0852 0853 0854 0855 0890 Service Brake Pressure Switch Body Raise Switch Body Up Sensor Transmission Upshift Solenoid Transmission Downshift Solenoid Torque Converter Lockup Clutch Solenoid ARC Supply Valve ARC Control Valve ARC Lamp ARC ON/OFF Switch ARC Pressure Switch Retarder Pressure Switch VIMS Main Module VIMS Interface Module #1 VIMS Interface Module #2 VIMS Interface Module #3 VIMS Interface Module #4 VIMS Interface Module #5 VIMS Interface Module #6 VIMS Interface Module #7 VIMS Interface Module #8 Speedometer/Tachometer #1 Speedometer IT achometer #2 Gauge (Quad) Cluster #1 Gauge (Quad) Cluster #2 Gauge (Quad) Cluster #3 Gauge (Quad) Cluster #4 Message Center #1 Message Center #2 ECM Internal Backup Battery Display Data Link Keypad Data Link Display Power Supply (9 Volt) Display Lighting Power Supply VIMS Service Lamp Truck Payload Lamp #1 (Green) Truck Payload Lamp #2 (Red) Torque Converter Oil Temperature Sensor Left Exhaust (Bank) Temperature Sensor Right Exhaust (Bank) Temperature Sensor Rear Aftercooler Coolant Temperature Sensor Front Brake Oil Temperature Sensor Rear Brake Oil Temperature Sensor Differential (Axle) Oil Temperature Sensor Left Front Suspension Cylinder Pressure Sensor Right Front Suspension Cylinder Pressure Sensor Left Rear Suspension Cylinder Pressure Sensor Right Rear Suspension Cylinder Pressure Sensor System Air Pressure Sensor Gear Box Pressure Sensor Brake Oil Temperature Sensor (Right Front) Brake Oil Temperature Sensor (Left Front) Brake Oil Temperature Sensor (Right Rear) Brake Oil Temperature Sensor (Left Rear) Broadcast Port (Data Link) 107-8238 8T-8692 Alternator 9X-7803 Arc Control Engine Control EPTC-II Starting And Charging Systems Traction Control System (AETA) VIMS 3E-2034 3E-2035 Service Brake Pressure (Retarder) Manual Retard Pressure A/C Thermostat Steering Pressure (High) Stop Lamp Pressure Steering Pressure (Low) Differential Filter Plug Hoist Screen Park Brake Filter T/C Screen XMSN Charge Filter Pressure A/C High Pressure Engine Fan Clutch Override ARC Pressure Refrigerant Pressure (AC) Brake Cooling Filter Fuel Filter Torque Converter Inlet Filter Pressure Off Machine Switch Specification Part No. 3E-2033 620 Function Secondary Brake Pressure (Parking) Actuate 640 kPa (92.0 psi) 80 kPa (12.0 psi) 60 kPa (8.5 psi) .25 Nm to .43 Nm (.19 lb ft to .32 lb ft) 11000 kPa MAX (1600 psi MAX) 1900 kPa MAX (275 psi MAX) Deactuate 530 ± 40 kPa (77.0 ± 6.0 psi) 55 ± 20 kPa (8.0 ± 3.0 psi) 28 ± 15 kPa (4.0 ± 2.0 psi) — — 9000 ± 350 kPa (1300 ± 51 psi) 1400 ± 140 kPa (205 ± 20 psi) Contact Position Normally Open Normally Closed Normally Open Normally Closed B-C, Normally Closed B-A, Normally Open B-C, Normally Closed B-A, Normally Open 622 623 631 632 635 636 Electrical Schematic Symbols And Definitions Module Identifier (MID) Description MID No. 24 27 30 36 39 49 57 58 59 60 65 66 67 68 81 82 83 Engine Control Transmission Control (EPTCII only) Caterpillar Monitoring System Engine Control Machine Control VIMS Main Module VIMS Interface Module #1 VIMS Interface Module #2 VIMS Interface Module #3 VIMS Interface Module #4 VIMS Interface Module #5 VIMS Interface Module #6 VIMS Interface Module #7 VIMS Interface Module #8 Transmission Control Implement Control Automatic Retarder Control 3E-5465 3E-6461 3E-7809 Description T K965 K972 K983 K984 Pressure Symbol Temperature Symbol Level Symbol Flow Symbol 9X-7781 210 ± 70 kPa (30 ± 10 psi) — — Normally Open K985 K986 K988 111-9560 111-9563 114-5333 1585 kPa ± 103 kPa (230 psi ± 14.9 psi) 80.0 kPa MAX (11.6 psi MAX) 275 to 1750 kPa ¹ (40 to 255 psi) 138 ± 14 kPa (20.0 ± 2.0 psi) 1275 kPa ± 103 kPa (185 psi ± 14.9 psi) 55.0 ± 20.0 kPa (8.0 ± 2.9 psi) — — 83 kPa Min (12.0 psi Min) Normally Closed Normally Closed Normally Open ² K989 K991 K992 M966 M967 M984 Normally open switch that will close with an increase of a specific condition (temp-press-etc.). Normally open switch that is closed due to an applied condition, and will open again with a specific decrease in that condition. 116-9933 Normally Closed Normally closed switch that will open with an increase of a specific condition. NOTE: After determining the electronic control that detected the failure, see the service manual module for that control for troubleshooting information. ¹ With increasing pressure the closed condition can be maintained up to 2800 kPa (405 psi), with decreasing pressure the closed condition can be maintained down to 170 kPa (25 psi). ² Contact position at the contacts of the harness connector. Normally closed switch that is open due to an applied condition, and will close again with a specific decrease in that condition. The circle indicates that the component has screw terminals and a wire can be disconnected from it. Resistor, Sender and Solenoid Specifications Related Electrical Service Manuals Title Form Number SENR7508 SENR5683 SENR1127 SENR9122 SENR2947 SENR2986 SENR6059 9G-9988 3T-0062 124-6704 3T-3437 Part No. 9G-1950 Component Description Resistor - Blower Motor Differential Oil Cooler Low Speed (Rear) Resistor - Dimmer Resistor - Exhaust Diverter Oil Burn Start Aid Solenoid - AETA Four Way Solenoid - AETA Proportional Solenoid - Body Float Body Lower Body Raise Solenoid - XMSN Lockup Down Shift Up Shift Resistance (Ohms)¹ Overall 2.0 ± 0.1 No circle indicates that the wire cannot be disconnected from the component. Overall 10.0 ± 0.1 This indicates that the component has a wire connected to it that is connected to ground. Overall 20 ± 0.2 24.9 16.0 34.2 This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. 33.7 ¹ At room temperature unless otherwise noted. 1 Current CID numbers apply to machines with VIMS installed after 08-01-94 and machines updated with new software after 08-01-94 36 Page, (Dimensions: 48 inches x 35 inches) XMSN Lever Code 1 SENR1480-01 36 Page, Color 2, (Dimensions: 48 inches x 35 inches) F G C D H A M B E 777-M41 PU-10 MM W W MOTOR 614-AL1 605-AL8 200-AL5 200-AL7 M M M M M M M W DIFFERENTIAL OIL TEMP SENSOR 100-3055 M-P1 772-LL18 BR-16 767-LL11 WH-16 M OIL COOLER FAN MOTOR (ATTACHMENT) 118-2085 N-P12 LEFT REAR STRUT +V SENSOR GROUND 124-0328 SIGNAL N-P1 ARC SUPPRESSOR 106-8704 N-P13 MUR440 614-AK3 PU-16 605-AK2 YL-16 200-AK7 BK-16 200-AK4 BK-16 604-AL6 OR-16 200-AL2 BK-16 604-AK5 OR-16 RIGHT WHL SPEED +V ANALOG SENSOR DIGITAL RET N-P11 SIGNAL P-P2 LEFT WHL SPEED +V ANALOG SENSOR DIGITAL RET 3T-2470 SIGNAL P-P1 200-AG77 BK-16 D993-MM26 YL-16 A254-MM5 BK-16 M 200-M40 BK-10 A B C A B C M W W OR 1 BK 2 WH 3 W M W PU-16 YL-16 BK-16 BK-16 W W W W A254-MM6 BK-16 +V ANALOG DIGITAL RET SIGNAL A271-N27 BK-14 G736-N29 PK-14 956-AG188 BR-16 E986-AG255 YL-16 W 1 2 D993-MM26 YL-16 D994-MM27 BU-16 893-MM15 GN-16 892-MM18 BR-16 202-L8 BK-16 MM W 893-LL23 GN-16 892-LL22 BR-16 126-L1 PK-16 720-L46 PU-16 706-L32 BR-16 706-L32 BR-16 202-L15 BK-16 M 720-L46 PU-16 202-L16 BK-16 608-AK8 GN-16 200-AK1 BK-16 OR-18 BK-18 WH-18 A B C 772-LL18 BR-16 700-LL10 PK-16 306-L23 GN-16 321-L25 BR-16 M W W W 893-L54 GN-16 892-L53 BR-16 608-AL3 GN-16 200-AL7 BK-16 TRANSMISSION OIL TEMP SENSOR 100-3055 M-P2 G736-N30 PK-16 A271-N10 BK-16 3E-3361 N-C1 RIGHT REAR BRAKE OIL TEMP SENSOR 100-3055 M-P4 D994-MM27 BU-16 767-P7 WH-16 A255-P3 BK-16 770-P10 GN-16 9D-3955 P-C2 767-P8 WH-16 A255-P4 BK-16 769-P9 BU-16 9D-3955 P-C3 1 113-N2 OR-16 2 A252-N14 BK-16 3 861-N25 PU-16 7N-7781 N-C3 A252-M72 BK-16 A252-M72 BK-16 A252-M29 BK-16 A252-M31 BK-16 A252-M32 BK-16 A252-M38 BK-16 A252-M30 BK-16 F975-M34 OR-16 F975-M37 OR-16 200-M40 BK-10 777-M41 PU-10 417-M33 OR-16 A491-M11 WH-16 429-M39 YL-16 A492-M16 OR-16 F780-M8 PK-16 428-M36 OR-16 F447-M1 PU-16 425-M75 PK-16 C484-M76 YL-16 C473-M14 GN-16 M M M 1 2 769-LL16 BU-16 770-LL17 GN-16 769-LL16 BU-16 770-LL17 GN-16 W W 3E-3361 N-C6 A255-LL3 BK-16 A218-MM10 BK-16 MM MM 216-LL9 BK-16 215-LL8 BK-16 767-LL14 WH-16 216-LL9 BK-16 215-LL8 BK-16 7N-8204 N-C13 CONN 5 1 2 3 4 200-AG77 BK-16 7N-8205 M-C15 D988-MM22 WH-16 D986-MM21 PK-16 D985-MM20 BR-16 D984-MM19 GN-16 176-MM1 OR-16 892-MM13 BR-16 893-MM14 GN-16 D992-MM25 PU-16 A254-MM3 BK-16 D991-MM24 OR-16 454-MM12 GN-16 450-MM11 YL-16 D989-MM23 BU-16 M M MM MM 419-M7 YL-16 F975-M50 OR-16 A252-M49 BK-16 C467-M10 BU-16 860-M25 PK-16 861-M12 PU-16 A252-M45 BK-16 113-M46 OR-16 W K984-AG279 GY-16 F707-AG258 WH-16 315-AG105 GN-16 315-AG106 GN-16 A252-M74 BK-16 A252-M73 BK-16 F975-M34 OR-16 F975-M37 OR-16 200-M40 BK-10 A252-M6- BK-16 777-M41 PU-10 A252-M4 BK-16 132-LL1 A255-LL2 768-LL15 767-LL14 700-LL10 474-M42 WH-16 892-LL22 BR-16 893-LL23 GN-16 7N-8204 T-S1 7N-8205 M-C2 G713-AG275 GY-16 F705-AG257 PK-16 E986-AG255 YL-16 160-AG191 PU-16 205-AG95 BK-16 G704-AG266 YL-16 G705-AG272 GN-16 F707-AG258 WH-16 315-AG103 GN-12 337-AG302 WH-16 F709-AG303 BU-16 F710-AG260 BR-16 604-AG141 OR-16 998-AG200 BR-16 317-AG108 YL-16 104-AG307 YL-16 998-AG301 BR-16 F708-AG299 YL-16 410-AG289 WH-16 411-AG288 PK-16 E729-AG294 GN-16 E729-AG292 GN-16 PK-16 BK-16 OR-16 WH-16 PK-16 M K992-AG238 PU-16 A254-AG218 BK-16 K991-AG237 OR-16 454-AG124 GN-16 450-AG119 YL-16 K989-AG236 BU-16 126-L2 PK-16 306-L23 GN-16 307-L24 OR-16 321-L25 BR-16 202-L10 BK-16 710-L38 GN-16 G712-L58 GN-16 G711-L59 BR-16 G714-L5 PU-16 708-L6 YL-16 K988-AG235 WH-16 K986-AG234 PK-16 K985-AG233 BR-16 M984-AG232 GN-16 176-AG56 OR-16 892-AG177 BR-16 893-AG183 GN-16 CONN 12 A252-M32 BK-16 417-M33 OR-16 W C467-M10 BU-16 A252-M49 BK-16 F975-M50 OR-16 419-M7 YL-16 H701-M22 OR-16 H700-M79 GY-16 A253-M51 BK-16 113-M52 OR-16 315-AG107 GN-16 998-AG200 BR-16 F710-AG260 BR-16 317-AG109 YL-16 1 2 3 4 G736-AG287 PK-14 893-AG187 892-AG181 450-AG120 452-AG123 709-AG166 E776-M53 GN-16 E777-M54 YL-16 M 132-AG41 PK-16 A255-AG219 BK-16 710-AG12 GN-16 767-AG168 WH-16 700-AG165 PK-16 M M M M A252-M74 A252-M73 F975-M58 F975-M55 F975-M50 F975-M55 OR-16 A252-M73 BK-16 C466-M57 YL-16 W W M M OR-16 GN-16 BU-16 BK-14 M F975-M58 OR-16 A252-M74 BK-16 F433-M60 PU-16 W M M M 104-AG305 YL-16 F708-AG299 YL-16 998-AG300 BR-16 E729-AG293 GN-16 F975-M24 OR-16 113-M2 OR-16 410-M35 WH-16 411-M56 PK-16 K991-AG237 454-AG124 K989-AG236 A251-AG206 104-AG304 YL-16 F709-AG303 BU-16 998-AG301 BR-16 337-AG302 WH-16 113-AG22 OR-16 176-AG56 OR-16 BK-16 BK-16 OR-16 OR-16 OR-16 WM WM WM W W W F780-M8 PK-16 W 113-M2 OR-16 A252-M3 BK-16 F433-M60 PU-16 C466-M57 YL-16 429-M39 YL-16 419-M7 YL-16 113-AG22 OR-16 K988-AG235 WH-16 K986-AG234 PK-16 K985-AG233 BR-16 M984-AG232 GN-16 K992-AG238 PU-16 A254-AG218 BK-16 473-M44 GY-16 120-AG30 YL-16 120-AG30 YL-16 M M W M WM WM W M M M W W W A252-M61 BK-16 G704-M62 YL-18 G713-M63 GY-16 205-M64 BK-16 G705-M65 GN-18 M A252-M61 BK-16 G736-AG287 PK-14 604-AG141 OR-16 958-AG194 WH-16 103-AG6 YL-16 103-AG7 YL-16 WM WM WM W W W W W W A252-M45 BK-16 A252-M49 BK-16 A252-M61 BK-16 113-M46 OR-16 H700-M79 GY-16 H701-M22 OR-16 F433-M60 PU-16 C466-M57 YL-16 419-M7 YL-16 C467-M10 BU-16 861-M12 PU-16 860-M25 PK-16 K984-AG280 GY-16 317-AG110 YL-16 K984-AG281 GY-16 317-AG111 YL-16 326-AG113 709-AG166 327-AG114 452-AG123 G712-AG51 G714-AG91 G711-AG92 W W W M 860-M25 PK-16 411-M56 PK-16 M W 410-M35 WH-16 CONN 11 M M G713-M63 GY-16 205-M67 BK-16 M A271-AG249 BK-14 113-AG262 OR-12 410-AG289 WH-16 A271-AG8 BK-14 G736-JJ35 PK-12 M W G736-AG287 PK-14 104-AG306 YL-16 H734-AG286 GN-12 W 103-AG7 YL-16 M 103-AG6 YL-16 113-AG285 OR-16 113-AG259 OR-14 883-M19 GY-16 882-M20 PK-16 F975-M77 OR-16 G704-M62 YL-18 205-M66 BK-16 113-AG261 OR-12 411-AG288 PK-16 A271-AG4 BK-14 H734-AG286 GN-12 428-M36 OR-16 C467-M10 BU-16 A491-M11 WH-16 861-M12 PU-16 C429-M13 GY-16 A451-M17 WH-16 C473-M14 GN-16 A492-M16 OR-16 417-M33 OR-16 F447-M1 PU-16 425-M75 PK-16 883-M19 GY-16 882-M20 PK-16 H700-M79 GY-16 H701-M22 OR-16 C484-M76 YL-16 F975-M24 OR-16 450-AG122 YL-16 A252-M6- BK-16 A252-M1- BK-16 A252-M45 BK-16 A252-M49 BK-16 A252-M61 BK-16 E776-M53 GN-16 E777-M54 YL-16 205-M64 BK-16 G713-M63 GY-16 113-M52 OR-16 G704-M62 YL-18 A253-M51 BK-16 G705-M65 GN-18 103-AG6 YL-16 113-AG285 OR-16 450-AG120 YL-16 103-AG7 YL-16 892-AG180 BR-16 C473-M14 GN-16 C484-M76 YL-16 425-M75 PK-16 F447-M1 PU-16 A491-M11 WH-16 428-M36 OR-16 F780-M8 PK-16 417-M33 OR-16 A492-M16 OR-16 429-M39 YL-16 F975-M24 OR-16 113-M2 OR-16 410-M35 WH-16 411-M56 PK-16 H701-M22 OR-16 C466-M57 YL-16 419-M7 YL-16 C467-M10 BU-16 861-M12 PU-16 C429-M13 GY-16 H700-M79 GY-16 860-M25 PK-16 F433-M60 PU-16 A252-M3 BK-16 A252-M27 BK-16 A252-M28 BK-16 A252-M26 BK-16 883-M19 GY-16 882-M20 PK-16 A451-M17 WH-16 A252-M26 BK-16 A252-M27 BK-16 A252-M28 BK-16 OR-16 BK-10 BK-16 WH-16 PK-16 PU-10 G705-M65 GN-18 205-M68 BK-16 M M F975-XX1 OR-16 A252-XX2 BK-16 A451-XX3 WH-16 201-AG83 BK-16 801-AG171 PK-16 202-K20 BK-16 202-K21 BK-16 202-K22 BK-16 998-AG300 BR-16 G736-JJ36 PK-12 M W BODY UP SENSOR 3E-0461 K-P1 450-AG122 YL-16 200-AG78 BK-16 M M M M 703-K12 BU-16 M AETA PROPORTIONAL SOLENOID 3T-0062 R-P1 A251-AG204 BK-16 BU-16 YL-16 GN-16 OR-16 BU-16 BU-16 BK-16 200-AG282 BK-16 998-AG300 BR-16 450-AG122 YL-16 205-AG96 BK-16 107-AG13 WH-16 132-AG41 PK-16 126-AG40 PK-16 767-AG168 WH-16 700-AG165 PK-16 529-AG135 BU-16 120-AG29 YL-12 321-AG112 BR-16 F717-AG193 YL-16 122-HH6 BU-16 C428-HH48 GN-16 201-HH17 BK-16 M W 201-HH46 201-HH16 201-HH15 201-HH21 201-HH14 201-HH13 201-HH12 201-HH11 C428-HH48 GN-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 105-AG9 BR-16 105-AG11 BR-16 E972-AG254 YL-16 E794-AG49 YL-16 E793-AG248 BU-16 M WM WM WM W W W M 481-HH27 PK-16 WM W WM 113-HH2 OR-16 201-HH14 BK-16 408-HH53 WH-16 C463-HH50 GY-16 447-HH25 PK-16 A493-HH65 YL-16 205-AG95 BK-16 M YL-16 BR-16 PK-16 WH-16 PU-14 PK-16 YL-14 YL-14 BU-16 OR-16 OR-16 YL-16 PU-16 BU-14 OR-14 OR-14 GN-14 PK-14 BU-14 200-AG62 BK-16 M M W 200-AG282 BK-16 109-AG14 OR-04 M WM WM WM W W W W W W 876-AG175 875-AG174 A251-AG205 E972-AG253 E972-AG250 F419-AG228 F418-AG225 F419-AG230 F418-AG227 893-AG185 892-AG179 767-AG168 700-AG165 149-AG46 105-AG9 105-AG11 E972-AG254 E794-AG49 E793-AG248 121-AG31 YL-16 122-AG33 BU-16 124-AG39 GN-14 115-AG28 PK-14 126-AG40 PK-16 150-AG50 OR-14 170-AG53 YL-14 135-AG42 BU-14 104-AG306 YL-16 PU-14 BU-14 YL-14 BR-16 PU-16 OR-16 WH-16 PK-16 OR-14 OR-16 W W W 858-HH36 GY-16 801-HH35 PK-16 W 113-HH1 OR-16 113-HH2 OR-16 201-HH16 BK-16 447-HH25 PK-16 201-HH21 BK-16 M967-HH51 OR-16 M966-HH52 GN-16 C453-HH49 YL-16 K983-HH18 BU-16 K983-HH64 BU-16 K983-HH62 BU-16 M966-HH52 GN-16 859-HH37 YL-16 C419-HH26 GN-16 C420-HH47 BU-16 C453-HH49 YL-16 M967-HH51 OR-16 C428-HH48 GN-16 426-HH42 BR-16 E792-HH20 BR-16 893-HH41 GN-16 892-HH40 BR-16 883-HH39 GY-16 882-HH38 PK-16 E791-HH19 YL-16 K983-HH64 BU-16 307-AG38 OR-16 102-AG2 BU-14 115-AG28 PK-14 124-AG39 GN-14 109-AG14 OR-04 121-AG32 YL-16 308-AG102 YL-16 612-AG149 GY-16 135-AG44 BU-14 103-AG5 YL-16 170-AG54 YL-14 113-AG259 OR-14 635-AG160 BU-16 105-AG11 BR-16 E972-AG254 YL-16 F419-AG230 YL-16 636-AG163 GN-16 F418-AG227 GN-16 200-AG72 BK-16 200-AG63 BK-14 200-AG57 BK-08 A254-AG217 BK-14 200-AG59 BK-14 201-AG81 BK-16 200-AG75 BK-16 608-AG145 GN-16 614-AG152 PU-16 326-AG113 BR-16 201-HH13 BK-16 201-HH12 BK-16 201-HH11 BK-16 M C428-HH48 GN-16 201-HH11 BK-16 201-HH12 BK-16 201-HH13 BK-16 201-HH14 BK-16 113-HH2 OR-16 C453-HH49 YL-16 200-HH7 BK-16 306-HH23 GN-16 327-HH24 PK-16 447-HH25 PK-16 481-HH27 PK-16 801-HH35 PK-16 858-HH36 GY-16 859-HH37 YL-16 882-HH38 PK-16 883-HH39 GY-16 892-HH40 BR-16 893-HH41 GN-16 C463-HH50 GY-16 M967-HH51 OR-16 M966-HH52 GN-16 408-HH53 WH-16 K983-HH64 BU-16 A493-HH65 YL-16 201-HH46 BK-16 201-HH16 BK-16 201-HH15 BK-16 201-HH21 BK-16 113-HH2 OR-16 C453-HH49 YL-16 200-HH7 BK-16 306-HH23 GN-16 327-HH24 PK-16 447-HH25 PK-16 481-HH27 PK-16 801-HH35 PK-16 858-HH36 GY-16 859-HH37 YL-16 882-HH38 PK-16 883-HH39 GY-16 892-HH40 BR-16 893-HH41 GN-16 C463-HH50 GY-16 M967-HH51 OR-16 M966-HH52 GN-16 408-HH53 WH-16 K983-HH64 BU-16 A493-HH65 YL-16 A493-HH65 YL-16 408-HH53 WH-16 C463-HH50 GY-16 893-HH41 GN-16 200-HH7 BK-16 201-HH15 BK-16 892-HH40 BR-16 859-HH37 YL-16 858-HH36 GY-16 801-HH35 PK-16 481-HH27 PK-16 327-HH24 PK-16 306-HH23 GN-16 E729-HH56 GN-16 M966-HH52 GN-16 M967-HH51 OR-16 C453-HH49 YL-16 113-HH2 OR-16 201-HH16 BK-16 201-HH21 BK-16 447-HH25 PK-16 K983-HH64 BU-16 201-HH21 BK-16 M967-HH51 OR-16 M966-HH52 GN-16 C453-HH49 YL-16 K983-HH63 BU-16 C420-HH47 E791-HH19 E792-HH20 C419-HH26 E729-HH56 BU-16 YL-16 BR-16 GN-16 GN-16 113-HH3 OR-16 C420-HH47 E791-HH19 E792-HH20 C419-HH26 BU-16 YL-16 BR-16 GN-16 E729-HH56 GN-16 200-HH9 BK-16 306-HH23 GN-16 306-HH23 GN-16 E729-HH56 GN-16 200-HH57 BK-16 W 200-HH8 BK-16 327-HH24 PK-16 200-HH7 BK-16 327-HH24 PK-16 E972-AG251 BU-16 F419-AG229 YL-16 F418-AG226 GN-16 F717-AG193 YL-16 201-DD21 BK-16 M967-DD28 OR-16 M966-DD27 GN-16 C453-DD43 YL-16 K983-DD24 BU-16 200-HH57 BK-16 E972-AG252 BU-16 876-AG175 OR-16 875-AG174 BU-16 M967-DD28 OR-16 M966-DD27 GN-16 K983-DD24 BU-16 C453-DD43 YL-16 201-DD21 BK-16 308-DD20 YL-16 170-DD7 YL-14 F418-DD44 GN-16 E972-DD47 BU-16 F419-DD45 YL-16 E709-DD46 WH-16 A251-DD19 BK-16 308-DD20 YL-16 170-DD7 YL-14 F418-DD44 GN-16 E972-DD47 BU-16 F419-DD45 YL-16 E709-DD46 WH-16 A251-DD16 BK-16 113-DD4 OR-16 201-DD13 BK-16 636-DD36 635-DD35 858-DD38 859-DD39 620-DD34 614-DD33 539-DD32 200-DD8 E709-DD46 F419-DD45 F418-DD44 201-DD23 170-DD7 308-DD20 A251-DD19 K983-DD26 E972-DD47 C453-DD43 858-DD38 201-DD15 635-DD35 636-DD36 A251-DD17 A251-DD18 113-DD6 620-DD34 539-DD32 614-DD33 200-DD8 317-DD29 YL-16 200-DD10 BK-16 HEA ER AND A R COND ENG NE CON RO C RCU PAY OAD MON OR C RCU W RES HA HAVE BA ERY VO WHEN HE KEY SW CH S ON W RES HA HAVE BA ERY VO WHEN HE KEY SW CH S O RAC ON CON RO SYS EM AU OMA C RE ARDER CON RO RANSM SS ON CON RO C RCU K983-EE6 BU-16 201-EE5 BK-16 M966-EE4 GN-16 K983-EE8 BU-16 201-EE7 BK-16 M967-EE3 OR-16 ACHMEN S 317-DD31 YL-16 200-DD11 BK-16 109-DD3 OR-04 101-DD1 RD-04 513-A41 OR-18 522-A42 WH-18 317-DD30 YL-16 200-DD12 BK-16 GN-14 YL-14 GY-14 GY-14 GN-14 BU-14 450-A50 YL-18 202-A51 BK-18 W 403-AG115 GN-16 A254-AG217 BK-14 200-AG75 BK-16 200-AG63 BK-14 124-AG39 GN-14 200-AG72 BK-16 614-AG152 PU-16 308-AG101 YL-16 326-AG113 BR-16 307-AG38 OR-16 105-AG11 BR-16 E986-A52 YL-18 200-A53 BK-18 W M M CABLE-ACRD-04 139-AG45 OR-10 F720-AG264 GN-16 E986-AF2 YL-18 200-AF1 BK-18 M W T/C TEMP SENSOR 118-7226 A-P1 K933-A54 GN-18 201-A55 BK-18 481-A56 GN-18 A B C M M RD-18 BK-18 YL-18 709-A57 OR-18 202-A58 BK-18 452-A59 PU-18 CABLE-ADBK-02 200-AG70 BK-16 200-AG60 BK-16 135-AG43 BU-16 998-AG199 BR-16 998-AG200 BR-16 998-AG301 BR-16 998-AG300 BR-16 F717-AG267 YL-16 F721-AG86 GY-16 F723-AG271 PK-16 202-AG85 BK-16 122-AG35 BU-16 150-AG50 OR-14 150-AG52 OR-14 892-AG176 BR-16 452-AG123 PU-16 450-AG122 YL-16 F710-AG260 BR-16 893-AG182 GN-16 F707-AG258 WH-16 E986-AG255 YL-16 709-AG166 OR-16 E729-AG294 GN-16 200-AG76 BK-14 A493-AG290 YL-16 426-AG291 BR-16 481-AG125 PK-16 K983-AG277 BU-16 201-AG82 BK-16 F705-AG257 PK-16 F708-AG299 YL-16 337-AG302 WH-16 F709-AG303 BU-16 AFTERCOOL TEMP-FRONT SENSOR 118-7226 A-P2 K933-A60 GN-18 201-A61 BK-18 C463-A62 GY-16 CABLE-AB RD-02 200-A70 BK-18 337-A69 WH-18 CABLE-AB RD-02 F723-A160 PK-18 A B C RD-18 BK-18 YL-18 124-VV1 GN-14 200-VV3 BK-14 515-VV6 GY-14 521-VV9 YL-14 522-VV10 WH-14 109-A45 OR-04 201-A152 BK-18 201-A151 BK-18 9G-4348 9G-4351 B-C3 A-C4 998-AG198 BR-16 CONN 34 337-A69 WH-18 CABLE-AB RD-02 F723-A160 PK-18 CONN 35 F723-A101 PK-18 F724-A102 PU-18 USED FOR ADD OIL LEVEL SWITCH ON PILOT MACHINES F718-A91 BU-18 998-A92 BR-18 515-VV8 GY-14 200-VV5 BK-14 515-VV7 GY-14 200-VV4 BK-14 426-A153 BR-18 A493-A154 YL-18 998-A137 BR-18 150-A78 RD-14 201-A63 BK-18 150-A79 RD-14 452-A59 PU-18 893-A77 GN-18 892-A76 BR-18 113-A72 OR-18 A700-A31 OR-18 998-A137 BR-18 F702-A86 GN-18 E729-A48 GN-18 F709-A82 BU-18 F721-A83 GY-18 F710-A73 BR-18 W W 150-B2 RD-14 201-B3 BK-18 150-B4 RD-14 452-B5 PU-18 893-B7 GN-18 892-B6 BR-18 113-B23 OR-18 A700-B8 OR-18 998-B9 BR-18 F702-B10 GN-18 E729-B35 GN-18 F709-B11 BU-18 F721-B12 GY-18 F710-B13 BR-18 TIE BACK D984-GN (FUTURE USE) K985-AG233 BR-16 K986-AG234 PK-16 M984-AG232 GN-16 K988-AG235 WH-16 K989-AG236 BU-16 K992-AG238 PU-16 K991-AG237 OR-16 454-AG124 GN-16 A251-AG206 BK-14 A254-AG218 BK-16 113-AG22 OR-16 A251-AG202 BK-16 113-AG21 OR-16 113-AG20 OR-16 113-AG19 OR-16 113-AG18 OR-16 113-AG27 OR-16 A254-AG217 BK-14 200-AG75 BK-16 521-AG126 YL-14 522-AG127 WH-14 F719-A93 BR-18 998-A138 BR-18 W W A-P3 116-9933 FUEL FILTER PRESSURE SWITCH W W M W W M W W W W W M W W W W M M M M W M W M W M W M W M M W W M W W W W W M W W W W W M W M BK BK W W 403-AG115 GN-16 F720-AG264 GN-16 E793-AG248 BU-16 C463-AG224 GY-16 412-A95 BU-18 998-A96 BR-18 C463-A62 GY-16 K933-A64 GN-18 200-A66 BK-18 202-A65 BK-18 F705-A81 PK-18 709-A57 OR-18 481-A56 GN-18 F707-A80 WH-18 F723-A160 PK-18 522-A67 WH-18 C463-B14 GY-18 K983-B15 GN-18 200-B16 BK-18 202-B17 BK-18 F705-B18 PK-18 709-B19 OR-18 481-B20 PK-18 F707-B21 WH-18 F723-B39 PK-18 522-B22 WH-18 F723-A101 F724-A102 F718-A91 F719-A93 998-A136 998-A134 412-A95 998-A135 998-A133 998-A131 F725-A97 998-A157 F722-A99 PK-18 PU-18 BU-18 BR-18 BR-18 BR-18 BU-18 BR-18 BR-18 BR-18 WH-18 BR-16 OR-18 450-A50 YL-18 F708-A71 YL-18 337-A69 WH-18 E986-A52 YL-18 F725-A97 WH-18 998-A98 BR-18 450-B24 YL-18 F708-B25 YL-18 337-B38 WH-18 E986-B28 YL-18 CABLE-AB RD-02 C463-A62 201-A63 K933-A64 452-A59 202-A65 709-A57 481-A56 200-A66 E986-A52 450-A50 E729-A48 522-A67 521-A47 403-A68 426-A153 A493-A154 337-A69 F723-A160 998-A137 A700-A31 113-A72 F710-A73 F717-A74 F720-A75 892-A76 893-A77 150-A78 150-A79 F707-A80 F705-A81 F709-A82 F721-A83 E793-A84 E794-A85 F702-A86 F708-A71 GY-16 BK-18 GN-18 PU-18 BK-18 OR-18 GN-18 BK-18 YL-18 YL-18 GN-18 WH-18 YL-18 GN-18 BR-18 YL-18 WH-18 PK-18 BR-18 OR-18 OR-18 BR-18 YL-18 GN-18 BR-18 GN-18 RD-14 RD-14 WH-18 PK-18 BU-18 GY-18 BU-18 YL-18 GN-18 YL-18 F722-A99 OR-18 998-A100 BR-18 W BR-16 BR-18 BR-18 BR-18 BR-18 229-A89 BK-14 229-A90 BK-14 997-A147 OR-18 993-A104 BR-18 F713-A118 OR-18 ENGINE ECM ENGINE BLOCK GROUND 997-A146 OR-18 993-A107 BR-18 F714-A113 PK-18 998-A157 998-A133 998-A134 998-A135 998-A136 998-A131 BR-18 F725-A97 WH-18 F719-A93 BR-18 F722-A99 OR-18 412-A95 BU-18 F718-A91 BU-18 F723-A101 PK-18 F724-A102 PU-18 A700-A87 OR-18 998-A136 BR-18 F703-A123 GY-18 E793-A84 BU-18 F715-A156 PU-16 892-A76 BR-18 150-A79 RD-14 229-A89 BK-14 150-A78 RD-14 E794-A85 YL-18 F716-A155 WH-16 893-A77 GN-18 A700-A88 OR-18 998-A135 BR-18 F704-A112 OR-18 229-A90 BK-14 F724-A102 PU-18 F722-A99 OR-18 F717-A74 YL-18 A700-A103 OR-18 997-A145 OR-18 993-A108 BR-18 A747-A121 GY-18 113-A72 OR-18 F710-A73 BR-18 F717-A74 YL-18 F720-A75 GN-18 892-A76 BR-18 893-A77 GN-18 150-A78 RD-14 150-A79 RD-14 F707-A80 WH-18 F705-A81 PK-18 F709-A82 BU-18 F721-A83 GY-18 E793-A84 BU-18 E794-A85 YL-18 F702-A86 GN-18 F708-A71 YL-18 997-A144 OR-18 993-A124 BR-18 A746-A122 PK-18 E794-A85 YL-18 E793-A84 BU-18 521-A47 YL-18 403-A68 GN-18 F720-A75 GN-18 426-A153 BR-18 A493-A154 YL-18 F717-A74 YL-18 E794-B29 YL-18 E793-B30 BU-18 521-B31 YL-18 403-B32 GN-18 F720-B33 GN-18 426-B36 BR-18 A493-B37 YL-18 F717-B34 YL-18 CABLE-AB RD-02 W W F725-A97 WH-18 F723-A101 PK-18 F721-A83 GY-18 F718-A91 BU-18 F705-A81 PK-18 F707-A80 WH-18 113-A72 OR-18 F719-A93 BR-18 F720-A75 GN-18 412-A95 BU-18 F708-A71 YL-18 998-A131 BR-18 993-A130 BR-18 E795-A105 YL-18 996-A106 GN-18 997-A148 OR-18 993-A115 BR-18 E795-A105 YL-18 997-A143 OR-18 993-A126 BR-18 994-A94 GY-18 F709-A82 BU-18 A700-A103 OR-18 997-A139 OR-18 E796-A109 GN-18 999-A110 WH-18 F732-A111 PK-18 F710-A73 BR-18 F704-A112 OR-18 F714-A113 PK-18 623-AG156 BU-14 607-AG144 PK-14 619-AG154 GN-16 631-AG157 GY-16 632-AG158 WH-16 622-AG155 PU-14 149-AG48 PU-14 A700-A103 OR-18 F713-A118 OR-18 F714-A113 PK-18 F703-A123 GY-18 997-A139 OR-18 F704-A112 OR-18 A747-A121 GY-18 A746-A122 PK-18 E795-A105 YL-18 994-A94 GY-18 E796-A109 GN-18 A751-A119 YL-18 995-A116 BU-18 996-A106 GN-18 999-A110 WH-18 F732-A111 PK-18 F700-A120 BU-18 993-A130 BR-18 E799-A114 BR-18 E798-A149 PK-18 E797-A150 WH-18 F701-A153 WH-18 997-A142 OR-18 993-A127 BR-18 E796-A109 GN-18 997-A141 OR-18 993-A128 BR-18 A751-A119 YL-18 W POS NEG 750 CCA MAINT FREE 12V BATTERY 3T-5760 X-P2 997-A140 OR-18 993-A129 BR-18 995-A116 BU-18 W CABLE_ZRD-02 996-A106 GN-18 998-A134 BR-18 999-A110 WH-18 W A700-A125 OR-18 998-A133 BR-18 F732-A111 PK-18 W 113-AG23 OR-16 E710-AG244 BU-16 113-AG24 OR-16 E710-AG245 BU-16 200-AG74 BK-16 601-AG138 GY-16 GROUND DISCONNECT SWITCH 7N-0718 X-P3 F700-A120 BU-18 E799-A114 BR-18 607-UU24 PK-14 CABLE_YBK-02 E798-A149 PK-18 E797-A150 WH-18 998-A157 BR-16 F715-A156 PU-16 F716-A155 WH-16 E799-A115 BR-18 G770-A29 WH-18 F726-A20 YL-18 A714-A30 BU-18 E799-A114 BR-18 994-A94 GY-18 995-A116 BU-18 A716-A117 PU-18 F727-A21 BU-18 A712-A28 BR-18 F701-A153 BK-18 F713-A118 OR-18 A751-A119 YL-18 A701-A15 GY-18 F728-A19 BR-18 A710-A27 GY-18 F700-A120 BU-18 A747-A121 GY-18 F729-A24 GN-18 A708-A25 BR-18 A746-A122 PK-18 F702-A86 GN-18 F703-A123 GY-18 A703-A13 BR-18 F730-A18 GY-18 A706-A32 GY-18 E798-A149 PK-18 A713-A3 GN-18 A711-A5 PU-18 A705-A11 BU-18 F731-A26 OR-18 A704-A23 GN-18 E797-A150 WH-18 A715-A1 GY-18 A709-A7 OR-18 A707-A9 PU-18 G769-A17 PU-18 A702-A22 PU-18 229-A90 BK-14 229-A89 BK-14 892-A76 BR-18 150-A79 RD-14 150-A78 RD-14 E794-A85 YL-18 E793-A84 BU-18 893-A77 GN-18 F724-A102 PU-18 F717-A74 YL-18 F722-A99 OR-18 F725-A97 WH-18 F721-A83 GY-18 F718-A91 BU-18 F705-A81 PK-18 F707-A80 WH-18 113-A72 OR-18 F719-A93 BR-18 F720-A75 GN-18 412-A95 BU-18 F723-A101 PK-18 F708-A71 YL-18 998-A131 BR-18 993-A130 BR-18 E795-A105 YL-18 996-A106 GN-18 F709-A82 BU-18 A700-A103 OR-18 994-A94 GY-18 E796-A109 GN-18 999-A110 WH-18 F732-A111 PK-18 F710-A73 BR-18 F703-A123 GY-18 F704-A112 OR-18 F714-A113 PK-18 E798-A149 PK-18 A747-A121 GY-18 A751-A119 YL-18 F700-A120 BU-18 E799-A114 BR-18 E797-A150 WH-18 995-A116 BU-18 F702-A86 GN-18 A746-A122 PK-18 F713-A118 OR-18 997-A139 OR-18 F701-A153 BK-18 F715-A156 PU-16 F716-A155 WH-16 F728-A19 BR-18 F729-A24 GN-18 A702-A22 PU-18 F727-A21 BU-18 A701-A15 GY-18 F726-A20 YL-18 G770-A29 WH-18 A714-A30 BU-18 A716-A117 PU-18 A712-A28 BR-18 A710-A27 GY-18 F730-A18 GY-18 A706-A32 GY-18 A703-A13 BR-18 A713-A3 GN-18 A711-A5 PU-18 A705-A11 BU-18 F731-A26 OR-18 A704-A23 GN-18 A708-A25 BR-18 A715-A1 GY-18 A709-A7 OR-18 A707-A9 PU-18 G769-A17 PU-18 103-UU6 YL-16 A716-A117 PU-18 G770-A40 WH-16 A715-A1 GY-18 G769-A2 PU-18 +12V RADIO POWER CONNECTION A714-A30 BU-18 G770-A39 WH-18 A713-A3 GN-18 G769-A4 PU-18 A712-A28 BR-18 F731-A38 OR-18 A711-A5 PU-18 F730-A6 GY-18 PU-16 GN-14 PU-14 GY-14 WH-14 WH-16 BU-16 623-BB4 BU-16 620-BB25 WH-14 622-BB5 PU-14 619-BB9 GN-14 611-BB10 PU-14 149-BB3 PU-14 631-BB11 GY-14 632-BB12 WH-14 607-BB2 PK-14 200-BB28 BK-14 200-BB7 BK-14 200-BB6 BK-14 K983-BB17 BU-16 201-BB16 BK-16 C453-BB21 YL-16 E972-BB37 BU-16 E709-BB32 WH-16 F419-BB34 YL-16 F418-BB36 GN-16 308-BB33 YL-16 170-BB35 YL-14 A251-BB31 BK-16 A251-BB31 BK-16 308-BB33 YL-16 170-BB35 YL-14 200-BB28 BK-14 200-BB6 BK-14 200-BB7 BK-14 F418-BB36 GN-16 F419-BB34 YL-16 E709-BB32 WH-16 E972-BB37 BU-16 9G-3667 BB-C8 A710-A27 GY-18 F731-A37 OR-18 A709-A7 OR-18 F730-A8 GY-18 8 9 10 9G-3673 BB-C7 CONN 41 619-CC21 GN-14 611-CC18 PU-14 200-CC11 BK-14 201-CC12 BK-16 K983-CC38 BU-16 C453-CC35 YL-16 CONN 40 FRAME GROUND (LH DEAD CHICKEN) A708-A25 BR-18 F729-A36 GN-18 A707-A9 PU-18 F728-A10 BR-18 623-CC26 BU-14 620-CC24 WH-14 622-CC25 PU-14 619-CC22 GN-14 611-CC19 PU-14 149-CC1 PU-14 631-CC27 GY-14 632-CC30 WH-14 607-CC16 PK-14 A251-CC34 308-CC13 170-CC2 200-CC3 200-CC4 200-CC10 F418-CC36 F419-CC37 E709-CC39 E972-CC40 K983-CC38 BU-16 201-CC12 BK-16 C453-CC35 YL-16 539-FF2 BU-16 200-FF6 BK-16 614-FF3 PU-16 A706-A32 GY-18 F729-A33 GN-18 A705-A11 BU-18 F728-A12 BR-18 CABLE_SBK-000 A704-A23 GN-18 F727-A35 BU-18 A703-A13 BR-18 F726-A14 YL-18 619-CC22 GN-14 611-CC19 PU-14 632-CC30 WH-14 631-CC27 GY-14 607-CC16 PK-14 623-CC26 BU-14 622-CC25 PU-14 149-CC1 PU-14 620-CC24 WH-14 C453-CC35 YL-16 201-CC12 BK-16 K983-CC38 BU-16 200-CC10 BK-14 200-CC3 BK-14 200-CC4 BK-14 170-CC2 YL-14 E972-CC40 BU-16 F419-CC37 YL-16 F418-CC36 GN-16 308-CC13 YL-16 E709-CC39 WH-16 A251-CC34 BK-16 A702-A22 PU-18 F727-A34 BU-18 ENGINE GROUND (LH) A701-A15 GY-18 F726-A16 YL-18 9G-4348 DD-C11 9G-4351 B-C2 W 3 2 4 1 (R) (L) S-2 S-1 AETA 4-WAY SOLENOID 9G-9988 R-P2 3 2 4 1 2 BK 1 WH + BATTERY SOLENOID GROUND 704-K13 GY-16 M 103-AG7 YL-16 893-AG186 GN-16 103-AG6 YL-16 725-J3 724-J4 723-J5 722-J6 721-J7 410-M35 411-M56 E791-M18 E792-M23 201-M59 K983-M69 C419-M70 C420-M71 608-N20 200-N17 614-N23 604-N16 612-N6 200-N17 605-N18 606-N19 G736-N28 A271-N7 231-J1 BK-18 726-J2 BU-18 F717-AG267 YL-16 F721-AG86 GY-16 F723-AG271 PK-16 892-AG176 BR-16 893-AG182 GN-16 307-AG38 OR-16 113-AG22 OR-16 176-AG56 OR-16 883-M19 GY-16 882-M20 PK-16 A253-M51 BK-16 113-M52 OR-16 E777-M54 YL-16 E776-M53 GN-16 G713-M63 GY-16 G705-M65 GN-18 G704-M62 YL-18 205-M64 BK-16 113-M1- OR-16 A252-M1- BK-16 308-J8 YL-18 705-K14 PK-16 M 1 126-K15 PK-16 2 E750-K11 PU-16 3 202-K18 BK-16 7N-7781 K-C4 892-AG178 BR-16 893-AG184 GN-16 709-K15 OR-16 202-K19 BK-16 710-K10 GN-16 M 126-K15 PK-16 709-K16 OR-16 8N-1525 K-C1 202-K4 BK-16 126-K15 PK-16 709-K16 OR-16 103-AG36 YL-16 7N-7781 R-C3 1 2 3 773-R13 GY-16 A255-R5 BK-16 7N-8204 R-C4 8N-1529 R-C5 A255-R5 A255-R6 A255-R7 773-R13 774-R14 775-R15 408-AG231 WH-16 201-AG80 BK-16 K983-AG278 BU-16 BK-16 BK-16 BK-16 GY-16 YL-16 BR-16 A255-R4 BK-16 767-R9 WH-16 769-R11 BU-16 770-R12 GN-16 767-R10 WH-16 A255-R8 BK-16 A255-R1 BK-16 767-R9 WH-16 769-R11 BU-16 770-R12 GN-16 774-R14 A255-R7 775-R15 A255-R6 YL-16 BK-16 BR-16 BK-16 122-HH6 BU-16 205-HH22 BK-16 113-HH5 OR-16 113-HH4 OR-16 E776-HH54 GN-16 G704-HH58 YL-16 E777-HH55 YL-16 G705-HH59 GN-16 G713-HH60 GY-16 410-HH66 WH-16 411-HH67 PK-16 A271-HH61 BK-16 612-HH32 GY-16 A253-HH44 BK-16 A252-HH43 BK-16 614-HH33 PU-16 G736-HH45 PK-16 608-HH31 GN-16 606-HH30 GY-16 605-HH29 YL-16 604-HH28 OR-16 K983-HH18 BU-16 200-HH10 BK-10 777-HH34 PU-10 882-HH38 PK-16 883-HH39 GY-16 201-HH46 BK-16 E791-HH19 YL-16 E792-HH20 BR-16 C419-HH26 GN-16 C420-HH47 BU-16 C420-HH47 BU-16 C419-HH26 GN-16 E792-HH20 BR-16 E791-HH19 YL-16 201-HH46 BK-16 883-HH39 GY-16 882-HH38 PK-16 122-HH6 BU-16 205-HH22 BK-16 113-HH5 OR-16 113-HH4 OR-16 E776-HH54 GN-16 G704-HH58 YL-16 E777-HH55 YL-16 G705-HH59 GN-16 G713-HH60 GY-16 410-HH66 WH-16 411-HH67 PK-16 A271-HH61 BK-16 612-HH32 GY-16 A253-HH44 BK-16 A252-HH43 BK-16 614-HH33 PU-16 G736-HH45 PK-16 608-HH31 GN-16 606-HH30 GY-16 605-HH29 YL-16 604-HH28 OR-16 200-HH7 BK-16 327-HH24 PK-16 608-HH31 GN-16 200-AG64 BK-16 327-AG114 PK-16 608-AG145 GN-16 122-HH6 BU-16 612-HH32 GY-16 C463-HH50 GY-16 G704-HH58 YL-16 201-HH15 BK-16 614-HH33 PU-16 606-HH30 GY-16 605-HH29 YL-16 205-HH22 BK-16 K983-HH64 BU-16 447-HH25 PK-16 201-HH21 BK-16 201-HH16 BK-16 113-HH2 OR-16 C453-HH49 YL-16 M967-HH51 OR-16 M966-HH52 GN-16 K983-HH18 BU-16 113-HH1 OR-16 K983-HH62 BU-16 777-DD37 PU-10 104-DD2 YL-16 777-DD37 PU-10 104-DD2 YL-16 308-DD20 YL-16 170-DD7 YL-14 F418-DD44 GN-16 E972-DD47 BU-16 F419-DD45 YL-16 E709-DD46 WH-16 A251-DD16 BK-16 113-DD4 OR-16 201-DD13 BK-16 GN-16 BU-16 GY-16 YL-16 513-A43 OR-18 522-A44 WH-18 113-DD5 OR-16 201-DD14 BK-16 859-DD39 YL-16 A251-GG5 BK-16 635-GG3 BU-16 E729-A48 GN-18 200-A49 BK-18 +V ANALOG DIGITAL RET SIGNAL +V ANALOG DIGITAL RET SIGNAL 109-B1 OR-04 1 2 3 7N-7781 M-C4 3E-7809 M-P13 M-P16 116-9933 LOW TORQUE CONV STEERING INLET FILTER PRESSURE SWITCH SWITCH A271-AG249 BK-14 801-AG171 PK-16 MODULE 3 (TRACTOR) CONNECTIONS H701-T2 OR-16 H700-T1 GY-16 A490-M43 GN-16 M M M 7N-7782 T-S2 BK WH BK WH BK BK 15 REAR CHASSIS GROUND 604-N50 OR-16 200-N8 BK-16 614-N52 PU-16 614-N56 PU-16 605-N18 YL-16 604-N51 OR-16 200-N54 BK-16 104-2921 P-C8 425-AH6 PK-16 A252-AH3 BK-16 M M 200-N4 BK-16 200-N5 BK-16 113-N3 OR-16 A252-N15 BK-16 892-MM16 BR-16 892-MM17 GN-16 M MM 767-LL12 WH-16 W 767-LL13 WH-16 768-LL15 OR-16 M 450-MM11 YL-16 D985-MM20 BR-16 200-N4 BK-16 200-N5 BK-16 +V GROUND SIGNAL 861-N25 PU-16 A252-N13 BK-16 113-N1 OR-16 A271-N7 BK-14 CONN 4 A254-NN1 BK-16 A254-NN2 BK-16 D992-MM25 PU-16 M 214-LL7 BK-16 213-LL6 BK-16 212-LL5 BK-16 214-LL7 BK-16 213-LL6 BK-16 212-LL5 BK-16 D991-MM24 A217-MM9 A216-MM8 A215-MM7 OR-16 BK-16 BK-16 BK-16 +V ANALOG DIGITAL RET SIGNAL OR 1 BK 2 WH 3 1 2 3 7N-7781 N-C5 D984-MM19 GN-16 774-LL20 YL-16 775-LL21 BR-16 773-LL19 GY-16 132-LL1 PK-16 A255-LL4 BK-16 774-LL20 YL-16 775-LL21 BR-16 773-LL19 GY-16 F975-P21 OR-18 E986-AG255 YL-16 614-N55 PU-16 614-N53 PU-16 606-N19 GY-16 605-AK2 YL-16 200-AK7 BK-16 604-AK5 OR-16 200-AK4 BK-16 614-AK3 PU-16 605-AL8 YL-16 200-AL2 BK-16 604-AL6 OR-16 200-AL5 BK-16 614-AL4 PU-16 958-AG194 WH-16 176-MM1 OR-16 A254-MM4 BK-16 D988-MM22 WH-16 D989-MM23 BU-16 454-MM12 GN-16 +V ANALOG DIGITAL RET SIGNAL +V ANALOG DIGITAL RET SIGNAL 200-AG77 BK-16 160-AG191 PU-16 205-AG95 BK-16 G704-AG266 YL-16 G712-AG51 GN-16 G714-AG91 PU-16 G705-AG272 GN-16 315-AG104 GN-16 200-AG78 BK-16 G713-AG275 GY-16 F705-AG257 PK-16 G711-AG92 BR-16 956-AG188 BR-16 OR-18 BK-18 WH-18 LEFT REAR BRAKE OIL TEMP SENSOR 100-3055 M-P3 OR-18 BK-18 WH-18 A B C 767-P6 769-P9 A255-P2 767-P5 770-P10 A255-P1 C473-P18 GN-16 C429-P17 GY-16 425-P11 PK-16 A252-P12 BK-16 F975-P20 OR-16 C484-P19 YL-16 A252-P16 BK-18 A B C RIGHT REAR STRUT SENSOR 124-0328 N-P11 1 2 3 4 5 6 7 8 F975-M34 OR-16 A252-M72 BK-16 428-M36 OR-16 104-2921 M-C8 M-P24 9X-7781 REAR DIFF FILTER PLUG SW G736-N28 A271-N7 113-N1 A252-N13 861-N25 315-AG104 GN-16 200-AG78 BK-16 G713-AG275 GY-16 F705-AG257 PK-16 G711-AG92 BR-16 REAR BACKUP ALARM 123-6449 N-P6 608-N20 606-N19 614-N23 860-N26 612-N6 OR-18 BK-18 WH-18 A254-NN3 BK-16 MM D986-MM21 PK-16 A215-MM7 BK-16 A216-MM8 BK-16 A217-MM9 BK-16 A218-MM10 BK-16 A254-MM2 BK-16 A B C PK-14 BK-14 OR-16 BK-16 PU-16 604-N16 OR-16 605-N18 YL-16 GN-16 GY-16 PU-16 PK-16 GY-16 C473-M9 GN-16 C429-M6 GY-16 425-M5 PK-16 A252-M47 BK-16 F975-M14 OR-16 C484-M15 YL-16 A252-M9- BK-16 L15 CONN 1 767-R9 WH-16 WH-16 1 2 769-R11 BU-16 BU-16 3 BK-16 A255-R8 BK-16 4 767-R10 WH-16 WH-16 5 770-R12 GN-16 GN-16 6 BK-16 A255-R4 BK-16 3E-3382 3E-3379 P-C4 R-C2 F975-M37 OR-16 A252-M38 BK-16 429-M39 YL-16 104-2921 M-C7 BK-18 BK-18 A252-M72 BK-16 F975-M50 OR-16 A252-M49 BK-16 C467-M10 BU-16 104-2921 M-C9 604-N16 OR-16 612-N6 GY-16 605-N18 YL-16 606-N19 GY-16 G736-N28 PK-14 A271-N7 BK-14 614-N23 PU-16 608-N20 GN-16 113-N1 OR-16 A252-N13 BK-16 861-N25 PU-16 860-N26 PK-16 L15 G711-AG92 BR-16 G712-AG51 GN-16 G714-AG91 PU-16 200-N9 BK-16 612-N6 GY-16 126-L3 PK-16 202-L13 BK-16 K972-L14 BR-18 218-L19 BK-16 217-L18 BK-16 219-L20 BK-16 227-L22 BK-16 280-L21 BK-16 703-L28 BU-16 704-L29 GY-16 705-L30 PK-16 721-L47 BR-16 722-L48 WH-16 723-L49 OR-16 724-L50 YL-16 725-L51 GN-16 726-L52 BU-16 E750-L57 PU-16 709-L36 OR-16 710-L39 GN-16 126-L7 PK-16 126-L4 PK-16 202-L12 BK-16 712-L41 WH-16 711-L40 BR-16 713-L42 OR-16 716-L45 BU-16 202-L11 BK-16 715-L44 GN-16 714-L43 YL-16 707-L31 PU-16 218-L19 BK-16 217-L18 BK-16 219-L20 BK-16 227-L22 BK-16 280-L21 BK-16 703-L28 BU-16 704-L29 GY-16 705-L30 PK-16 721-L47 BR-16 722-L48 WH-16 723-L49 OR-16 724-L50 YL-16 725-L51 GN-16 726-L52 BU-16 E750-L57 PU-16 K965-L56 YL-16 710-L37 GN-16 712-L41 WH-16 711-L40 BR-16 713-L42 OR-16 716-L45 BU-16 15 A252-AH1 BK-16 A252-AH2 BK-16 425-AH4 PK-16 425-AH5 PK-16 307-L24 OR-16 K964-L55 PU-16 K965-L56 YL-16 126-L1 PK-16 202-L8 BK-16 703-L28 BU-16 704-L29 GY-16 705-L30 PK-16 706-L32 BR-16 W M M 708-L6 YL-16 709-L34 PU-16 710-L37 GN-16 711-L40 BR-16 712-L41 WH-16 713-L42 OR-16 714-L43 YL-16 715-L44 GN-16 716-L45 BU-16 217-L18 BK-16 218-L19 BK-16 219-L20 BK-16 720-L46 PU-16 721-L47 BR-16 722-L48 WH-16 723-L49 OR-16 724-L50 YL-16 725-L51 GN-16 726-L52 BU-16 E750-L57 PU-16 707-L31 PU-16 450-L26 YL-16 452-L27 PU-16 G714-L5 PU-16 G711-L59 BR-16 G712-L58 GN-16 W W 14 M M M W F780-M8 PK-16 W W A492-M16 OR-16 1 2 M M W F447-M1 PU-16 A252-M4 BK-16 A491-M11 WH-16 A252-M31 BK-16 M 176-AG56 OR-16 892-AG177 BR-16 893-AG183 GN-16 113-AG22 OR-16 892-AG181 892-AG298 892-AG176 892-AG178 892-AG179 892-AG180 893-AG184 GN-16 893-AG187 GN-16 893-AG297 GN-16 893-AG185 GN-16 893-AG182 GN-16 893-AG186 GN-16 BR-16 BR-16 BR-16 BR-16 BR-16 BR-16 892-AG181 BR-16 893-AG187 GN-16 892-AG178 BR-16 893-AG184 GN-16 892-AG298 BR-16 893-AG185 GN-16 893-AG297 GN-16 892-AG179 BR-16 892-AG180 BR-16 892-AG176 BR-16 893-AG182 GN-16 893-AG186 GN-16 14 777-M41 PU-10 200-M40 BK-10 F975-M34 OR-16 A252-M72 BK-16 428-M36 OR-16 F975-M37 OR-16 A252-M38 BK-16 429-M39 YL-16 A252-M29 BK-16 A252-M30 BK-16 G427-M78 BU-16 715-L44 GN-16 714-L43 YL-16 707-L31 PU-16 452-L27 PU-16 450-L26 YL-16 892-L53 BR-16 893-L54 GN-16 708-L6 YL-16 G714-L5 PU-16 G711-L59 BR-16 G712-L58 GN-16 280-L21 BK-16 227-L22 BK-16 321-L25 BR-16 307-L24 OR-16 306-L23 GN-16 709-L34 PU-16 K964-L55 PU-16 K964-L55 PU-16 W A252-M47 BK-16 F975-M14 OR-16 C429-M6 GY-16 C473-M14 GN-16 425-M75 PK-16 C484-M76 YL-16 777-M41 PU-10 200-M40 BK-10 F975-M34 OR-16 A252-M72 BK-16 428-M36 OR-16 F975-M37 OR-16 A252-M38 BK-16 429-M39 YL-16 A252-M29 BK-16 A252-M30 BK-16 A492-M16 OR-16 F780-M8 PK-16 A491-M11 WH-16 A252-M31 BK-16 A252-M32 BK-16 417-M33 OR-16 F447-M1 PU-16 M 893-L54 892-L53 450-L26 452-L27 709-L35 GN-16 BR-16 YL-16 PU-16 OR-16 GN-16 BR-16 YL-16 PU-16 OR-16 K965-L56 YL-16 W 202-L9 BK-16 202-L17 BK-16 W W 126-AG40 PK-16 306-AG99 GN-16 307-AG37 OR-16 321-AG112 BR-16 202-AG88 BK-16 710-AG12 GN-16 G712-AG51 GN-16 G711-AG92 BR-16 G714-AG91 PU-16 708-AG93 YL-16 306-AG98 GN-16 326-AG113 BR-16 306-AG98 GN-16 107-AG13 WH-16 200-AG71 BK-16 327-AG114 PK-16 893-AG187 892-AG181 450-AG120 452-AG123 709-AG166 132-AG41 A255-AG219 307-AG37 OR-16 321-AG112 BR-16 202-AG88 BK-16 G712-AG51 GN-16 G711-AG92 BR-16 G714-AG91 PU-16 708-AG93 YL-16 120-AG29 YL-12 529-AG135 BU-16 307-AG37 OR-16 708-AG93 YL-16 892-AG181 BR-16 893-AG187 GN-16 450-AG120 YL-16 892-AG178 BR-16 893-AG184 GN-16 A251-AG296 BK-16 767-AG168 WH-16 700-AG165 PK-16 13 M 113-M1200-M40 A252-M1410-M35 411-M56 777-M41 E791-M18 YL-16 E792-M23 BR-16 C419-M70 GN-16 201-M59 BK-16 C420-M71 BU-16 K983-M69 BU-16 883-M19 GY-16 882-M20 PK-16 200-AG77 BK-16 A251-AG206 BK-14 13 306-AG97 GN-16 126-AG40 PK-16 200-AG87 BK-16 GN-16 BR-16 YL-16 PU-16 OR-16 PK-16 BK-16 321-AG112 BR-16 529-AG135 BU-16 120-AG29 YL-12 107-AG13 WH-16 132-AG41 PK-16 BR-16 OR-16 PK-16 PU-16 GN-16 PU-16 BR-16 126-AG40 PK-16 767-AG168 WH-16 700-AG165 PK-16 200-AG87 BK-16 450-AG120 YL-16 893-AG187 GN-16 892-AG181 BR-16 708-AG93 YL-16 307-AG37 OR-16 306-AG97 GN-16 200-AG71 BK-16 202-AG88 BK-16 A255-AG219 BK-16 CONN 18 170-AJ1 YL-16 A251-AJ2 BK-16 892-AJ3 BR-16 893-AJ4 GN-16 113-AJ5 OR-16 F717-AG268 YL-16 307-AG269 OR-16 M M M M 12 721-K1 722-K5 723-K6 724-K7 725-K8 726-K9 BR-16 WH-16 OR-16 YL-16 GN-16 BU-16 721-K1 722-K5 723-K6 724-K7 725-K8 726-K9 202-K2 BR-16 WH-16 OR-16 YL-16 GN-16 BU-16 BK-16 W 710-K10 GN-16 E750-K11 PU-16 200-M40 BK-10 9G-4349 M-C13 1 777-M41 PU-10 9G-4352 M-C14 GN-18 PU-18 OR-18 WH-18 BR-18 WH-16 PK-16 YL-16 BR-16 BK-16 BU-16 GN-16 BU-16 M GN-16 BK-16 PU-16 OR-16 GY-16 BK-16 YL-16 GY-16 PK-14 BK-14 9G-3667 N-C12 703-K12 BU-16 704-K13 GY-16 705-K14 PK-16 710-K10 GN-16 E750-K11 PU-16 202-K3 BK-16 703-K12 BU-16 704-K13 GY-16 705-K14 PK-16 1 2 3 4 5 6 7 8 9 10 11 12 3E-5179 M-C1 CONN 15 CONN 16 725-K8 724-K7 723-K6 722-K5 721-K1 200-AG57 201-AG81 201-AG83 201-AG80 201-AG82 201-AG84 200-AG64 200-AG71 200-AG70 200-AG78 200-AG72 A252-AG209 A253-AG210 A254-AG217 BK-08 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-16 BK-14 BK-14 BK-14 231-K17 BK-16 726-K9 BU-16 GN-16 YL-16 OR-16 WH-16 BR-16 410-HH66 411-HH67 E791-HH19 E792-HH20 201-HH46 K983-HH18 C419-HH26 C420-HH47 883-HH39 GY-16 882-HH38 PK-16 A253-HH44 BK-16 113-HH5 OR-16 E777-HH55 YL-16 E776-HH54 GN-16 G713-HH60 GY-16 G705-HH59 GN-16 G704-HH58 YL-16 205-HH22 BK-16 113-HH4 OR-16 A252-HH43 BK-16 605-HH29 606-HH30 G736-HH45 A271-HH61 200-HH10 BK-10 777-HH34 PU-10 WH-16 PK-16 YL-16 BR-16 BK-16 BU-16 GN-16 BU-16 614-HH33 PU-16 604-HH28 OR-16 612-HH32 GY-16 608-HH31 GN-16 YL-16 GY-16 PK-16 BK-16 705-K14 PK-16 704-K13 GY-16 703-K12 BU-16 710-K10 GN-16 202-K19 BK-16 709-K16 OR-16 231-K17 BK-16 726-K9 BU-16 725-K8 724-K7 723-K6 722-K5 721-K1 A255-R2 BK-16 TERMINALS IN THIS BOX ARE ALL CONNECTED TO REAR CAB GROUND BOSS GN-16 YL-16 OR-16 WH-16 BR-16 212-LL5 BK-16 213-LL6 BK-16 214-LL7 BK-16 215-LL8 BK-16 767-LL12 WH-16 769-LL16 BU-16 770-LL17 GN-16 200-AG75 BK-16 200-AG76 BK-14 A251-AG206 BK-14 200-AG77 BK-16 200-AG59 BK-14 200-AG60 BK-16 200-AG87 BK-16 A271-AG58 BK-14 202-AG85 BK-16 202-AG88 BK-16 A255-AG219 BK-16 205-AG96 BK-16 200-AG63 BK-14 200-AG282 BK-16 200-AG67 BK-14 200-AG65 BK-14 200-AG66 BK-14 773-R13 767-R10 774-R14 775-R15 A255-R3 GY-16 WH-16 YL-16 BR-16 BK-16 216-LL9 BK-16 773-LL19 GY-16 767-LL14 WH-16 774-LL20 YL-16 775-LL21 BR-16 A255-LL3 BK-16 A253-AG210 BK-14 200-AG64 BK-16 A252-AG209 BK-14 201-AG84 BK-16 205-AG96 BK-16 201-AG80 BK-16 200-AG76 BK-14 200-AG70 BK-16 202-AG85 BK-16 201-AG82 BK-16 200-AG60 BK-16 K983-AG277 BU-16 RD-18 1 BU-18 2 BK-18 3 126-K15 PK-16 E750-K11 PU-16 202-K18 BK-16 721-L47 BR-16 722-L48 WH-16 723-L49 OR-16 724-L50 YL-16 725-L51 GN-16 726-L52 BU-16 217-L18 BK-16 218-L19 BK-16 219-L20 BK-16 710-L39 GN-16 E750-L57 PU-16 202-L13 BK-16 703-L28 BU-16 704-L29 GY-16 705-L30 PK-16 280-L21 BK-16 227-L22 BK-16 126-L3 PK-16 709-L36 OR-16 A271-AG58 BK-14 201-AG83 BK-16 200-AG78 BK-16 A251-AG206 BK-14 200-AG77 BK-16 200-AG71 BK-16 200-AG67 BK-14 202-AG88 BK-16 200-AG65 BK-14 A255-AG219 BK-16 200-AG87 BK-16 200-AG66 BK-14 201-AG81 BK-16 200-AG72 BK-16 200-AG57 BK-08 A254-AG217 BK-14 200-AG75 BK-16 200-AG63 BK-14 200-AG59 BK-14 200-AG282 BK-16 12 170-AJ1 YL-16 A251-AJ2 BK-16 170-AG295 YL-16 A251-AG296 BK-16 892-AG298 BR-16 893-AG297 GN-16 113-AG285 OR-16 708-AG93 YL-16 307-AG37 OR-16 307-AG38 OR-16 F723-AG271 PK-16 F721-AG86 GY-16 F717-AG267 YL-16 F717-AG193 YL-16 F717-AJ7 YL-16 F717-AJ7 YL-16 M W M M M M M M M M M M W 893-AJ4 GN-16 892-AJ3 BR-16 113-AJ5 OR-16 A255-AG219 BK-16 202-AG88 BK-16 200-AG71 BK-16 200-AG67 BK-14 200-AG66 BK-14 200-AG65 BK-14 200-AG87 BK-16 306-AG97 200-AG67 200-AG66 200-AG65 A251-AG296 GN-16 BK-14 BK-14 BK-14 BK-16 170-AG55 A251-AG201 E710-AG242 E776-AG246 E777-AG247 893-AG184 892-AG178 113-AG27 601-AG140 875-AG174 876-AG175 F419-AG228 F418-AG225 411-AG117 E709-AG241 636-AG162 635-AG159 410-AG116 E707-AG239 E708-AG240 C413-AG221 C414-AG222 C415-AG223 E972-AG250 BU-16 YL-16 BK-16 BU-16 GN-16 YL-16 GN-16 BR-16 OR-16 GY-16 BU-16 OR-16 YL-16 GN-16 PK-16 WH-16 GN-16 BU-16 WH-16 GN-16 PK-16 YL-16 BU-16 WH-16 893-AG185 GN-16 A251-AG201 BK-16 E710-AG242 BU-16 411-AG117 PK-16 200-AG66 BK-14 601-AG140 GY-16 410-AG116 WH-16 E707-AG239 GN-16 E708-AG240 PK-16 C413-AG221 YL-16 C414-AG222 BU-16 C415-AG223 WH-16 200-AG65 BK-14 A251-AG296 BK-16 200-AG67 BK-14 306-AG97 GN-16 E709-AG241 WH-16 113-AG27 OR-16 E776-AG246 GN-16 E777-AG247 YL-16 893-AG184 GN-16 892-AG178 BR-16 170-AG295 YL-16 F717-AG193 YL-16 892-AG179 BR-16 636-AG162 GN-16 635-AG159 BU-16 170-AG55 YL-16 875-AG174 BU-16 F419-AG228 YL-16 F418-AG225 GN-16 876-AG175 OR-16 E972-AG250 BU-16 892-AG180 BR-16 113-AG259 OR-14 104-AG306 YL-16 875-AG174 F419-AG228 F418-AG225 876-AG175 E972-AG250 E972-AG253 A251-AG205 A251-AG205 E972-AG253 A251-AG204 A251-AG203 A251-AG201 E710-AG242 411-AG117 200-AG66 601-AG140 410-AG116 E707-AG239 E708-AG240 C413-AG221 C414-AG222 C415-AG223 200-AG65 A251-AG296 200-AG67 103-AG36 M M 307-AG38 OR-16 113-AG22 OR-16 176-AG56 OR-16 170-AG295 YL-16 F717-AG193 YL-16 892-AG179 BR-16 893-AG186 GN-16 103-AG6 YL-16 103-AG7 YL-16 893-AG185 GN-16 103-AG36 YL-16 BK-16 BU-16 BK-16 BK-16 BK-16 BU-16 PK-16 BK-14 GY-16 WH-16 GN-16 PK-16 YL-16 BU-16 WH-16 BK-14 BK-16 BK-14 YL-16 636-AG162 GN-16 635-AG159 BU-16 170-AG55 YL-16 11 W M W 11 201-AG80 BK-16 201-AG80 BK-16 A251-AG204 BK-16 635-AG161 BU-16 A251-AG203 BK-16 636-AG164 GN-16 200-AG282 BK-16 767-AG168 WH-16 700-AG165 PK-16 170-AG55 YL-16 636-AG163 GN-16 635-AG160 BU-16 F419-AG230 YL-16 F418-AG227 GN-16 893-AG185 GN-16 892-AG179 BR-16 205-AG95 BK-16 998-AG301 BR-16 315-AG103 GN-12 160-AG191 PU-16 E729-AG294 GN-16 F709-AG303 BU-16 337-AG302 WH-16 F708-AG299 YL-16 F710-AG260 BR-16 F705-AG257 PK-16 F707-AG258 WH-16 998-AG200 BR-16 E986-AG255 YL-16 317-AG108 YL-16 104-AG307 YL-16 G736-AG287 PK-14 411-AG288 PK-16 410-AG289 WH-16 E729-AG292 GN-16 G713-AG275 GY-16 G705-AG272 GN-16 G704-AG266 YL-16 604-AG141 OR-16 801-AG171 PK-16 A271-AG249 BK-14 E709-AG241 WH-16 113-AG27 OR-16 E777-AG247 YL-16 E776-AG246 GN-16 306-AG97 GN-16 126-AG40 PK-16 132-AG41 PK-16 107-AG13 WH-16 170-AG55 YL-16 105-AG9 BR-16 149-AG46 PU-14 767-AG168 WH-16 700-AG165 PK-16 149-AG46 PU-14 M 893-AG185 GN-16 892-AG179 BR-16 636-AG163 GN-16 E972-AG254 YL-16 F418-AG227 GN-16 F419-AG230 YL-16 635-AG160 BU-16 105-AG11 BR-16 170-AG55 YL-16 105-AG9 BR-16 149-AG46 PU-14 E793-AG248 BU-16 E794-AG49 YL-16 315-AG103 GN-12 612-AG150 GY-16 M M 612-AG149 GY-16 308-AG102 YL-16 121-AG32 YL-16 998-AG300 BR-16 F717-AG193 YL-16 205-AG96 BK-16 121-AG31 105-AG9 132-AG41 107-AG13 149-AG46 126-AG40 170-AG55 YL-16 893-AG186 GN-16 122-AG34 BU-16 892-AG180 BR-16 10 M 10 M 170-AG53 103-AG3 122-AG33 113-AG22 176-AG56 104-AG306 160-AG191 135-AG42 150-AG52 150-AG50 124-AG39 115-AG28 102-AG2 149-AG46 102-AG2 103-AG3 105-AG9 160-AG191 113-AG22 107-AG13 132-AG41 150-AG52 176-AG56 112-PP1 PU-12 M A493-HH65 YL-16 408-HH53 WH-16 C463-HH50 GY-16 893-HH41 GN-16 200-HH7 BK-16 201-HH15 BK-16 892-HH40 BR-16 859-HH37 YL-16 858-HH36 GY-16 801-HH35 PK-16 481-HH27 PK-16 327-HH24 PK-16 306-HH23 GN-16 E729-HH56 GN-16 A252-HH43 BK-16 306-HH23 GN-16 604-HH28 OR-16 G705-HH59 GN-16 G713-HH60 GY-16 A253-HH44 BK-16 E776-HH54 GN-16 E777-HH55 YL-16 858-HH36 GY-16 859-HH37 YL-16 113-HH1 OR-16 OR-16 BU-16 BK-16 BU-16 BU-16 YL-16 GN-16 YL-16 GN-16 GN-16 BR-16 WH-16 PK-16 PU-14 BR-16 BR-16 YL-16 YL-16 BU-16 W 112-QQ10 PU-10 112-QQ7 PU-12 109-AG15 OR-04 112-AG17 PU-12 K983-AG276 BU-16 408-AG231 WH-16 612-AG150 GY-16 306-AG97 GN-16 E776-AG246 GN-16 E777-AG247 YL-16 A271-AG249 BK-14 801-AG171 PK-16 604-AG141 OR-16 G704-AG266 YL-16 G705-AG272 GN-16 G713-AG275 GY-16 E729-AG292 GN-16 410-AG289 WH-16 411-AG288 PK-16 G736-AG287 PK-14 205-AG189 BK-16 200-AG64 BK-16 201-AG84 BK-16 A252-AG209 BK-14 A253-AG210 BK-14 892-AG180 BR-16 122-AG34 BU-16 893-AG186 GN-16 608-AG145 GN-16 614-AG152 PU-16 327-AG114 PK-16 481-AG125 PK-16 426-AG291 BR-16 A493-AG290 YL-16 998-AG199 BR-16 606-AG143 GY-16 605-AG142 YL-16 C463-AG224 GY-16 113-AG18 OR-16 113-AG19 OR-16 113-AG20 OR-16 858-AG172 GY-16 859-AG173 YL-16 A493-HH65 YL-16 E729-HH56 GN-16 113-HH5 OR-16 481-HH27 PK-16 410-HH66 WH-16 411-HH67 PK-16 G736-HH45 PK-16 K983-HH62 BU-16 A271-HH61 BK-16 408-HH53 WH-16 113-HH4 OR-16 801-HH35 PK-16 892-HH40 BR-16 893-HH41 GN-16 K983-HH18 BU-16 200-HH10 BK-10 777-HH34 PU-10 113-HH1 OR-16 K983-HH62 BU-16 122-AG34 BU-16 612-AG150 GY-16 C463-AG224 GY-16 G704-AG266 YL-16 201-AG84 BK-16 614-AG152 PU-16 606-AG143 GY-16 605-AG142 YL-16 205-AG189 BK-16 426-AG291 BR-16 A252-AG209 BK-14 306-AG97 GN-16 604-AG141 OR-16 G705-AG272 GN-16 G713-AG275 GY-16 A253-AG210 BK-14 E776-AG246 GN-16 E777-AG247 YL-16 858-AG172 GY-16 859-AG173 YL-16 113-AG18 OR-16 998-AG199 BR-16 A493-AG290 YL-16 E729-AG292 GN-16 113-AG19 OR-16 481-AG125 PK-16 410-AG289 WH-16 411-AG288 PK-16 G736-AG287 PK-14 K983-AG276 BU-16 A271-AG249 BK-14 408-AG231 WH-16 113-AG20 OR-16 801-AG171 PK-16 892-AG180 BR-16 893-AG186 GN-16 149-QQ26 PU-14 102-QQ1 BU-14 103-QQ2 YL-14 105-QQ4 BR-16 160-QQ29 PU-16 113-QQ17 OR-14 107-QQ6 WH-16 132-QQ24 PK-16 150-QQ27 RD-14 176-QQ5 OR-16 149-AG46 PU-14 876-AG175 OR-16 875-AG174 BU-16 E972-AG254 YL-16 E972-AG253 BU-16 E972-AG250 BU-16 F419-AG228 YL-16 F419-AG230 YL-16 F418-AG227 GN-16 F418-AG225 GN-16 A251-AG205 BK-16 105-AG11 BR-16 105-AG9 BR-16 893-AG185 GN-16 892-AG179 BR-16 E793-AG248 BU-16 E794-AG49 YL-16 767-AG168 WH-16 700-AG165 PK-16 121-QQ19 YL-16 122-QQ20 BU-16 123-QQ21 WH-16 124-QQ22 GN-14 115-QQ18 PK-14 126-QQ23 PK-16 150-QQ28 RD-14 170-QQ30 YL-14 135-QQ25 BU-14 104-QQ3 YL-16 709-AG166 OR-16 452-AG123 PU-16 327-AG114 PK-16 327-AG114 PK-16 150-AG50 OR-14 150-AG52 OR-14 135-AG43 BU-16 122-AG35 BU-16 F717-AG267 YL-16 F721-AG86 GY-16 F723-AG271 PK-16 893-AG182 GN-16 892-AG176 BR-16 998-AG300 BR-16 113-AG27 OR-16 113-AG18 OR-16 113-AG19 OR-16 113-AG20 OR-16 113-AG21 OR-16 A251-AG202 BK-16 K983-AG277 201-AG82 202-AG85 200-AG70 200-AG76 200-AG60 998-AG200 F707-AG258 337-AG302 F708-AG299 F710-AG260 F705-AG257 E986-AG255 F709-AG303 998-AG301 E729-AG294 481-AG125 426-AG291 A493-AG290 998-AG199 BU-16 BK-16 BK-16 BK-16 BK-14 BK-16 BR-16 WH-16 WH-16 YL-16 BR-16 PK-16 YL-16 BU-16 BR-16 GN-16 PK-16 BR-16 YL-16 BR-16 112-QQ10 PU-10 102-QQ1 BU-14 107-QQ6 WH-16 105-QQ4 BR-16 103-QQ2 YL-14 E794-AG49 YL-16 E793-AG248 BU-16 308-AG101 YL-16 529-AG135 BU-16 112-AG16 PU-10 W W M 112-QQ10 PU-10 112-QQ7 PU-12 149-QQ26 PU-14 E793-AG248 BU-16 E794-AG49 YL-16 105-AG10 BR-16 A251-AG205 BK-16 893-AG185 GN-16 892-AG179 BR-16 132-QQ24 PK-16 150-QQ27 RD-14 176-QQ5 OR-16 121-QQ19 YL-16 122-QQ20 BU-16 123-QQ21 WH-16 124-QQ22 GN-14 115-QQ18 PK-14 126-QQ23 PK-16 150-QQ28 RD-14 170-QQ30 YL-14 135-QQ25 BU-14 104-QQ3 YL-16 160-QQ29 PU-16 113-QQ17 OR-14 9 K983-DD25 BU-16 201-DD22 BK-16 M967-DD28 OR-16 M966-DD27 GN-16 WH-16 YL-16 GN-16 BK-16 YL-14 YL-16 BK-16 BU-16 BU-16 YL-16 WH-14 PU-16 BU-16 BK-14 WH-14 BU-16 PU-16 BK-14 1 2 3 4 5 6 7 8 9 10 9G-3673 BB-C5 9 W M DIAGNOSTIC CONNECTOR (ECAP, ET, FLASH) OLD FAN CLUTCH POWER CONNECTION W M M 777-DD37 PU-10 104-DD2 YL-16 E709-DD46 WH-16 317-DD29 YL-16 170-DD7 YL-14 635-DD35 BU-16 636-DD36 GN-16 A251-DD16 BK-16 777-AG170 PU-10 104-AG307 YL-16 E709-AG241 WH-16 317-AG108 YL-16 170-AG54 YL-14 635-AG160 BU-16 636-AG163 GN-16 A251-AG202 BK-16 124-QQ22 GN-14 149-QQ26 PU-14 115-QQ18 PK-14 115-QQ18 PK-14 112-QQ11 PU-14 101-RR6 RD-10 M 112-QQ12 PU-14 112-PP1 PU-12 TELEMETRY DOWNLOAD PORT M 101-RR1 RD-10 113-AG259 OR-14 105-AG11 BR-16 612-AG149 GY-16 326-AG113 BR-16 307-AG38 OR-16 121-AG32 YL-16 135-AG44 BU-14 200-AG59 BK-14 608-AG145 GN-16 F418-AG227 GN-16 102-AG2 BU-14 115-AG28 PK-14 A254-AG217 BK-14 200-AG75 BK-16 200-AG63 BK-14 124-AG39 GN-14 200-AG72 BK-16 614-AG152 PU-16 103-AG5 YL-16 201-AG81 BK-16 F419-AG230 YL-16 E972-AG254 YL-16 635-AG160 BU-16 636-AG163 GN-16 170-AG54 YL-14 109-AG14 OR-04 308-AG102 YL-16 200-AG57 BK-08 121-QQ19 YL-16 104-QQ3 YL-16 122-QQ20 BU-16 121-QQ19 YL-16 M 636-DD36 635-DD35 858-DD38 859-DD39 317-DD29 200-DD9 109-DD3 101-DD1 GY-16 BK-16 BU-16 GN-16 BK-16 BK-16 OR-16 GN-16 BU-16 GY-16 YL-16 YL-16 BK-08 OR-04 RD-04 E972-DD47 BU-16 F418-DD44 GN-16 F419-DD45 YL-16 308-DD20 YL-16 113-DD4 OR-16 109-DD3 OR-04 101-DD1 RD-04 201-DD13 BK-16 E972-AG254 YL-16 F418-AG227 GN-16 F419-AG230 YL-16 308-AG102 YL-16 113-AG21 OR-16 109-AG14 OR-04 101-AG1 RD-04 201-AG81 BK-16 858-DD38 GY-16 200-DD9 BK-08 859-DD39 YL-16 858-AG172 GY-16 200-AG57 BK-08 859-AG173 YL-16 859-AG173 YL-16 858-AG172 GY-16 104-AG307 YL-16 113-AG21 OR-16 A251-AG202 BK-16 E709-AG241 WH-16 317-AG108 YL-16 200-AG57 BK-08 308-AG102 YL-16 109-AG14 OR-04 170-AG54 YL-14 636-AG163 GN-16 635-AG160 BU-16 E972-AG254 YL-16 F419-AG230 YL-16 201-AG81 BK-16 F418-AG227 GN-16 101-AG1 RD-04 777-AG170 PU-10 200-AG57 BK-08 308-AG102 YL-16 109-AG14 OR-04 170-AG54 YL-14 636-AG163 GN-16 635-AG160 BU-16 E972-AG254 YL-16 F419-AG230 YL-16 201-AG81 BK-16 F418-AG227 GN-16 101-AG1 RD-04 777-AG170 PU-10 123-QQ21 WH-16 112-QQ7 PU-12 123-QQ21 WH-16 M M M 8 620-BB24 614-BB30 539-BB22 200-BB29 620-FF1 539-FF2 614-FF3 200-FF4 WH-14 BU-16 PU-16 BK-14 K983-EE1 BU-16 201-EE2 BK-16 M967-EE3 OR-16 M966-EE4 GN-16 WH-14 PU-16 BU-16 BK-14 A251-GG6 BK-16 636-GG4 GN-16 8 859-DD39 YL-16 113-DD5 OR-16 201-DD14 BK-16 858-GG1 GY-16 201-GG2 BK-16 635-GG3 BU-16 636-GG4 GN-16 A251-GG5 BK-16 A251-GG6 BK-16 113-GG7 OR-16 606-AG143 GY-16 605-AG142 YL-16 C463-AG224 GY-16 317-DD29 YL-16 200-DD10 BK-16 E709-BB32 WH-16 F419-BB34 YL-16 F418-BB36 GN-16 201-BB16 BK-16 170-BB35 YL-14 308-BB33 YL-16 A251-BB31 BK-16 K983-BB17 BU-16 E972-BB37 BU-16 C453-BB21 YL-16 150-QQ27 132-QQ24 126-QQ23 113-QQ17 150-QQ28 RD-14 PK-16 PK-16 OR-14 RD-14 113-QQ17 OR-14 112-QQ15 PU-14 A 102-AG2 115-AG28 A254-AG217 200-AG75 200-AG63 124-AG39 200-AG72 614-AG152 103-AG5 W 176-QQ5 OR-16 160-QQ29 PU-16 BU-14 PK-14 BK-14 BK-16 BK-14 GN-14 BK-16 PU-16 YL-16 DASHED PANE 170-QQ30 YL-14 M @ ARC SUPPRESSOR 106-8704 A-P10 MUR440 200-E1 BK-02 1 2 GUAGE C RCU GROUND C RCU S AR NG C RCU S AR A D C RCU MON OR NG C RCU URN S GNA C RCU NES ARE A AMP C RCU M C463-AG224 GY-16 605-AG142 YL-16 606-AG143 GY-16 103-AG5 YL-16 115-AG28 PK-14 102-AG2 BU-14 E793-AG248 BU-16 E794-AG49 YL-16 F720-AG264 GN-16 403-AG115 GN-16 105-AG11 BR-16 612-AG149 GY-16 326-AG113 BR-16 307-AG38 OR-16 121-AG32 YL-16 135-AG44 BU-14 200-AG59 BK-14 608-AG145 GN-16 777-AG170 PU-10 E793-AG248 BU-16 E794-AG49 YL-16 F720-AG264 GN-16 101-RR8 RD-10 112-PP1 PU-12 M 513-A46 OR-16 521-A47 YL-18 ONER C RCU 109-A45 OR-04 126-L7 PK-16 202-L12 BK-16 707-L31 PU-16 W E793-AG248 BU-16 E794-AG49 YL-16 F720-AG264 GN-16 AGE AGE M W 113-GG7 OR-16 201-GG2 BK-16 858-GG1 GY-16 7 337-A69 WH-18 200-A70 BK-18 W M 337-A69 WH-18 7 W W 777-AG170 PU-10 326-AG113 BR-16 307-AG38 OR-16 105-AG11 BR-16 135-AG44 BU-14 200-AG59 BK-14 121-AG32 YL-16 612-AG149 GY-16 608-AG145 GN-16 124-YY1 521-YY7 515-YY3 515-YY4 516-YY5 517-YY6 F717-AG193 YL-16 767-AG168 WH-16 700-AG165 PK-16 W W 716-L45 715-L44 202-L11 711-L40 126-L4 W M 707-L31 PU-16 202-L12 BK-16 126-L7 PK-16 M BU-16 GN-16 BK-16 BR-16 PK-16 714-L43 YL-16 713-L42 OR-16 712-L41 WH-16 M 608-AG145 GN-16 W W M W W M 403-AG115 GN-16 200-AG72 BK-16 M GN-14 BK-14 GY-14 YL-14 WH-14 M W 135-AG44 BU-14 200-AG59 BK-14 124-YY1 200-YY2 515-YY3 521-YY7 522-YY8 612-AG149 GY-16 121-AG32 YL-16 777-AG170 PU-10 W F717-AG193 YL-16 998-AG283 BR-16 6 5 4 3 M M CABLE_HBK-09 6 150-B2 201-B3 150-B4 452-B5 RD-14 BK-18 RD-14 PU-18 892-B6 BR-18 893-B7 GN-18 A700-B8 OR-18 998-B9 BR-18 F702-B10 GN-18 F709-B11 F721-B12 F710-B13 C463-B14 BU-18 GY-18 BR-18 GY-18 150-AG52 OR-14 201-AG82 BK-16 150-AG50 OR-14 452-AG123 PU-16 135-AG44 BU-14 200-AG59 BK-14 522-VV10 521-VV9 200-VV2 124-VV1 WH-14 YL-14 BK-14 GN-14 892-AG176 BR-16 893-AG182 GN-16 A700-AG220 OR-16 998-AG196 BR-16 F702-AG256 GN-16 122-AG35 BU-16 F709-AG303 BU-16 F721-AG86 GY-16 F710-AG260 BR-16 C463-AG224 GY-16 A254-AG211 BK-16 W W W M M W M M W 998-AG198 BR-16 998-AG283 BR-16 200-AG70 BK-16 200-AG60 BK-16 135-AG43 BU-16 102-AG2 BU-14 606-AG143 GY-16 605-AG142 YL-16 115-AG28 PK-14 103-AG5 YL-16 E794-AG49 YL-16 K983-B15 GN-18 200-B16 BK-18 709-B19 OR-18 F705-B18 PK-18 E729-B35 GN-18 481-B20 PK-18 F707-B21 WH-18 F723-B39 PK-18 522-B22 WH-18 113-B23 OR-18 450-B24 YL-18 202-B17 BK-18 F708-B25 YL-18 337-B38 WH-18 E986-B28 YL-18 K983-AG277 BU-16 200-AG76 BK-14 709-AG166 OR-16 F705-AG257 PK-16 E729-AG294 GN-16 481-AG125 PK-16 F707-AG258 WH-16 F723-AG271 PK-16 522-AG127 WH-14 113-AG26 OR-16 450-AG122 YL-16 202-AG85 BK-16 F708-AG299 YL-16 337-AG302 WH-16 E986-AG255 YL-16 F708-AG299 YL-16 202-AG85 BK-16 F709-AG303 BU-16 122-AG35 BU-16 337-AG302 WH-16 709-AG166 OR-16 201-AG82 BK-16 481-AG125 PK-16 F710-AG260 BR-16 893-AG182 GN-16 E729-AG294 GN-16 426-AG291 BR-16 E986-AG255 YL-16 892-AG176 BR-16 150-AG50 OR-14 F705-AG257 PK-16 150-AG52 OR-14 452-AG123 PU-16 A493-AG290 YL-16 F707-AG258 WH-16 K983-AG277 BU-16 200-AG76 BK-14 450-AG122 YL-16 F723-AG271 PK-16 F721-AG86 GY-16 F717-AG267 YL-16 998-AG196 BR-16 C463-AG224 GY-16 E793-AG248 BU-16 F720-AG264 GN-16 403-AG115 GN-16 614-AG152 PU-16 5 410-AG116 WH-16 200-AG66 BK-14 200-AG67 BK-14 200-AG65 BK-14 411-AG117 PK-16 A251-AG201 BK-16 A251-AG296 BK-16 A251-AG203 BK-16 A251-AG205 BK-16 A251-AG204 BK-16 E708-AG240 PK-16 C413-AG221 YL-16 C414-AG222 BU-16 C415-AG223 WH-16 E707-AG239 GN-16 E972-AG253 BU-16 601-AG140 GY-16 103-AG36 YL-16 E710-AG242 BU-16 E794-B29 YL-18 E793-B30 BU-18 521-B31 YL-18 403-B32 GN-18 F720-B33 GN-18 426-B36 BR-18 A493-B37 YL-18 F717-B34 YL-18 E794-AG49 YL-16 E793-AG248 BU-16 521-AG126 YL-14 403-AG115 GN-16 F720-AG264 GN-16 426-AG291 BR-16 A493-AG290 YL-16 F717-AG267 YL-16 E794-AG49 YL-16 522-AG127 WH-14 113-AG26 OR-16 521-AG126 YL-14 A700-AG220 OR-16 F702-AG256 GN-16 K985-AG233 BR-16 K986-AG234 PK-16 M984-AG232 GN-16 K988-AG235 WH-16 K989-AG236 BU-16 K992-AG238 PU-16 K991-AG237 OR-16 A254-AG216 BK-16 A254-AG214 BK-16 A254-AG215 BK-16 A254-AG213 BK-16 623-AG156 BU-14 619-AG154 GN-16 607-AG144 PK-14 622-AG155 PU-14 998-AG198 BR-16 998-AG283 BR-16 632-AG158 WH-16 631-AG157 GY-16 614-AG151 PU-16 149-AG47 PU-14 611-AG148 PU-14 540-AG132 WH-16 539-AG129 BU-16 611-AG147 PU-16 998-AG198 BR-16 998-AG283 BR-16 623-AG156 BU-14 607-AG144 PK-14 619-AG154 GN-16 631-AG157 GY-16 632-AG158 WH-16 A254-AG213 BK-16 K992-AG238 PU-16 A254-AG214 BK-16 K991-AG237 OR-16 K988-AG235 WH-16 A254-AG215 BK-16 K989-AG236 BU-16 A254-AG216 BK-16 622-AG155 PU-14 200-B35 BK-18 122-B36 BU-18 W M M 998-AG198 BR-16 998-AG283 BR-16 522-AG127 WH-14 113-AG26 OR-16 521-AG126 YL-14 619-AG154 GN-16 632-AG158 WH-16 631-AG157 GY-16 622-AG155 PU-14 623-AG156 BU-14 607-AG144 PK-14 614-AG151 PU-16 149-AG47 PU-14 601-AG136 GY-16 610-AG146 OR-14 540-AG132 WH-16 539-AG129 BU-16 611-AG147 PU-16 611-AG148 PU-14 522-AG127 WH-14 521-AG126 YL-14 998-AG283 BR-16 619-AG154 GN-16 632-AG158 WH-16 149-AG47 PU-14 998-AG198 BR-16 631-AG157 GY-16 607-AG144 PK-14 622-AG155 PU-14 611-AG148 PU-14 623-AG156 BU-14 539-AG129 BU-16 614-AG151 PU-16 611-AG147 PU-16 540-AG132 WH-16 113-AG26 OR-16 601-AG136 GY-16 610-AG146 OR-14 E710-AG242 BU-16 103-AG36 YL-16 601-AG140 GY-16 454-AG124 GN-16 A251-AG206 BK-14 A251-AG202 BK-16 W 113-AG25 200-AG73 601-AG137 E710-AG243 601-AG140 103-AG36 E710-AG242 A254-AG211 A254-AG213 A254-AG215 A254-AG214 A254-AG216 113-AG21 113-AG20 113-AG19 113-AG18 113-AG27 A254-AG217 200-AG75 113-AG26 601-AG136 611-AG148 611-AG147 539-AG129 540-AG132 610-AG146 601-AG136 149-AG47 614-AG151 607-AG144 623-AG156 622-AG155 631-AG157 632-AG158 619-AG154 200-AG70 200-AG60 135-AG43 102-AG2 606-AG143 605-AG142 115-AG28 103-AG5 A254-AG218 BK-16 113-AG22 OR-16 610-AG146 OR-14 M A700-AG220 OR-16 998-AG197 BR-16 F702-AG256 GN-16 M M CABLE-AB RD-02 9G-4348 AA-C1 200-UU13 BK-16 602-UU23 WH-16 101-AA1 RD-02 M M M POS NEG 750 CCA MAINT FREE 12V BATTERY 3T-5760 X-P1 W 103-UU4 YL-16 602-UU21 WH-16 W 103-UU3 103-UU7 103-UU6 103-UU5 YL-16 YL-16 YL-16 YL-16 M W M M M M CABLE_XBK-02 W M OR-16 BK-16 GY-16 BU-16 GY-16 YL-16 BU-16 BK-16 BK-16 BK-16 BK-16 BK-16 OR-16 OR-16 OR-16 OR-16 OR-16 BK-14 BK-16 OR-16 GY-16 PU-14 PU-16 BU-16 WH-16 OR-14 GY-16 PU-14 PU-16 PK-14 BU-14 PU-14 GY-16 WH-16 GN-16 BK-16 BK-16 BU-16 BU-14 GY-16 YL-16 PK-14 YL-16 MM W M 537-AG128 GN-16 606-AG143 GY-16 605-AG142 YL-16 537-AG128 GN-16 539-AG129 BU-16 540-AG132 WH-16 614-AG151 610-AG146 622-AG155 632-AG158 103-AG5 102-AG2 200-AG60 623-AG156 619-AG154 601-AG136 200-AG70 115-AG28 135-AG43 607-AG144 BU-14 BK-16 BU-14 GN-16 GY-16 BK-16 PK-14 BU-16 PK-14 102-UU2 BU-14 200-UU14 BK-14 623-UU31 BU-14 619-UU29 GN-14 601-UU19 GY-16 200-UU13 BK-16 115-UU8 PK-14 135-UU11 BU-14 607-UU24 PK-14 631-AG157 GY-16 149-AG47 PU-14 149-UU12 PU-14 PU-16 OR-14 PU-14 WH-16 YL-16 614-UU26 PU-16 610-UU25 OR-14 622-UU30 PU-14 632-UU33 WH-14 103-UU4 YL-16 601-UU19 GY-16 135-UU11 BU-14 200-UU14 BK-14 115-UU8 PK-14 632-UU33 WH-14 631-UU32 GY-14 149-UU12 PU-14 622-UU30 PU-14 623-UU31 BU-14 614-UU26 PU-16 102-UU2 BU-14 610-UU25 OR-14 619-UU29 GN-14 607-UU24 PK-14 103-UU4 YL-16 200-UU13 BK-16 WW 537-WW1GN-16 539-WW2BU-16 540-WW3WH-16 604-WW4OR-16 606-WW5GY-16 605-WW6YL-16 631-UU32 GY-14 W W 410-AG116 WH-16 A251-AG208 BK-16 601-AG136 GY-16 601-AG137 GY-16 601-AG140 GY-16 A254-AG218 BK-16 A254-AG216 BK-16 A254-AG217 BK-14 A254-AG215 BK-16 A254-AG214 BK-16 A254-AG211 BK-16 A254-AG213 BK-16 200-AG75 BK-16 200-AG73 BK-16 103-AG36 YL-16 103-AG36 YL-16 113-AG25 OR-16 113-AG19 OR-16 113-AG20 OR-16 113-AG26 OR-16 113-AG21 OR-16 113-AG22 OR-16 113-AG18 OR-16 113-AG27 OR-16 E710-AG243 BU-16 E710-AG242 BU-16 E972-AG253 C413-AG221 C414-AG222 C415-AG223 E707-AG239 E708-AG240 BU-16 YL-16 BU-16 WH-16 GN-16 PK-16 411-AG117 PK-16 454-AG124 GN-16 611-AG147 PU-16 200-AG73 BK-16 539-AG131 BU-16 A251-AG207 BK-16 540-AG134 WH-16 601-AG137 GY-16 113-AG25 OR-16 E710-AG243 BU-16 200-AG66 BK-14 200-AG67 BK-14 200-AG65 BK-14 539-AG130 BU-16 411-TT11 PK-16 454-TT12 GN-16 611-TT19 PU-16 200-TT7 BK-16 539-TT13 BU-16 A251-TT10 BK-16 540-TT14 WH-16 601-TT15 GY-16 113-TT1 OR-16 611-TT20 BU-16 OR-16 OR-16 BU-16 BU-16 GY-16 BK-16 454-TT12 GN-16 539-TT13 BU-16 C415-SS14 WH-16 200-TT3 BK-16 123-TT2 WH-16 E972-SS5 BU-16 E972-SS4 BU-16 C413-SS8 YL-16 C413-SS9 YL-16 C414-SS13 BU-16 C414-SS12 BU-16 E707-SS19 GN-16 E707-SS18 GN-16 E708-SS21 PK-16 E708-SS22 PK-16 113-AG24 113-AG23 E710-AG245 E710-AG244 601-AG138 200-AG74 E972-SS1 BU-16 C413-SS6 YL-16 C414-SS10 BU-16 C415-SS14 WH-16 E707-SS15 GN-16 E708-SS20 PK-16 611-TT19 PU-16 200-TT9 BK-16 200-TT8 BK-16 200-TT6 BK-16 200-TT5 BK-16 411-TT11 PK-16 A251-TT10 BK-16 540-TT14 WH-16 601-TT18 GY-16 601-TT17 GY-16 623-AG156 607-AG144 619-AG154 631-AG157 632-AG158 622-AG155 BU-14 PK-14 GN-16 GY-16 WH-16 PU-14 540-AG133 WH-16 4 614-AG152 PU-16 614-AG151 PU-16 149-AG47 PU-14 611-AG148 PU-14 200-AG66 BK-14 200-AG67 BK-14 200-AG65 BK-14 539-AG130 BU-16 614-AG153 540-AG133 611-AG148 200-AG66 200-AG67 200-AG65 539-AG130 PU-16 WH-16 PU-14 BK-14 BK-14 BK-14 BU-16 3 W 631-UU32 GY-14 632-UU33 WH-14 614-UU28 PU-16 149-UU12 PU-14 602-UU22 WH-16 623-UU31 BU-14 614-UU26 PU-16 614-UU27 PU-16 614-UU27 PU-16 614-UU28 PU-16 619-UU29 GN-14 610-UU25 OR-14 E707-SS17 GN-16 E972-SS3 BU-16 E708-SS23 PK-16 C413-SS7 YL-16 C414-SS11 BU-16 E707-SS19 GN-16 E972-SS5 BU-16 E708-SS21 PK-16 C413-SS8 YL-16 C414-SS13 BU-16 E707-SS18 GN-16 E972-SS4 BU-16 E708-SS22 PK-16 C413-SS9 YL-16 C414-SS12 BU-16 E707-SS16 GN-16 E972-SS2 BU-16 C415-SS14 WH-16 CHASSIS GROUND (FRONT) 622-UU30 PU-14 103-UU7 YL-16 103-UU6 YL-16 MM W W M W M M W M W M 411-TT11 PK-16 A251-TT10 BK-16 200-TT3 BK-16 539-TT13 BU-16 454-TT12 GN-16 123-TT2 WH-16 135-UU11 BU-14 200-UU14 BK-14 200-TT8 BK-16 611-TT19 PU-16 200-TT9 BK-16 540-TT14 WH-16 601-UU16 GY-16 601-TT16 200-TT4 113-TT1 611-TT20 CONN 42 CONN 43 601-TT18 200-TT6 200-TT5 601-TT17 M W W W W A715-A1 GY-18 A713-A3 GN-18 G769-A17 PU-18 A711-A5 PU-18 A709-A7 OR-18 F730-A18 GY-18 A707-A9 PU-18 A705-A11 BU-18 F728-A19 BR-18 A703-A13 BR-18 A701-A15 GY-18 F726-A20 YL-18 F727-A21 BU-18 A702-A22 PU-18 A704-A23 GN-18 F729-A24 GN-18 A706-A32 GY-18 A708-A25 BR-18 F731-A26 OR-18 A710-A27 GY-18 A712-A28 BR-18 G770-A29 WH-18 A714-A30 BU-18 A716-A117 PU-18 998-A157 BR-16 F715-A156 PU-16 F716-A155 WH-16 113-AG23 OR-16 E710-AG244 BU-16 113-AG24 OR-16 E710-AG245 BU-16 GY-16 BK-16 OR-16 BU-16 GY-16 BK-16 BK-16 GY-16 115-UU9 PK-14 115-UU10 PK-14 103-UU7 YL-16 600-UU15 BR-16 601-UU20 GY-16 MM M M M M M M M M M 614-AG153 619-AG154 611-AG148 631-AG157 632-AG158 540-AG133 539-AG130 623-AG156 622-AG155 200-AG66 200-AG67 M M M M M 601-UU18 GY-16 M 200-AG74 BK-16 601-AG138 GY-16 M 601-UU18 GY-16 115-UU8 PK-14 200-AG65 BK-14 607-AG144 PK-14 149-AG48 PU-14 BU-14 PU-14 BK-14 BK-14 M 103-UU5 YL-16 PU-16 GN-16 PU-14 GY-16 WH-16 WH-16 BU-16 102-UU1 BU-14 102-UU2 BU-14 102-UU1 BU-14 W 1 2 3 4 5 6 7 8 623-BB4 622-BB5 200-BB6 200-BB7 9G-3675 BB-C2 614-BB8 619-BB9 611-BB10 631-BB11 632-BB12 540-BB13 539-BB22 9G-3670 BB-C3 620-BB24 539-BB22 200-BB29 614-BB30 620-FF1 200-FF4 539-FF2 614-FF3 539-BB22 620-BB24 200-BB29 614-BB30 200-BB1 BK-14 607-BB2 PK-14 149-BB3 PU-14 2 1 2 BU-16 PU-14 BK-14 BK-14 M WW M M W M THIS SCHEMATIC IS FOR THE 793C MACHINE EFFECTIVE WITH 4AR218-UP (146-8805 CH01) M M M W W COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE MACHINE WITH THE KEY AND ENGINE OFF AND THE XMSN SHIFTER IN NEUTRAL. UNLESS OTHERWISE SPECIFIED: ALL WIRE IS 16 GAGE NOTE A: NORMALLY OPEN BEFORE REFRIGERANT CHARGE NOTE B: NOT USED ON MACHINES WITH AIR START NOTE C: USED ON MACHINES WITH AIR START ONLY 998-A157 BR-16 F715-A156 PU-16 F716-A155 WH-16 WH-14 BK-14 BU-16 PU-16 WH-14 BU-16 BK-14 PU-16 BU-16 WH-14 BK-14 PU-16 1 2 3 4 5 6 7 614-FF3 PU-16 539-FF2 BU-16 200-FF4 BK-14 620-FF1 WH-14 998-A157 BR-16 F715-A156 PU-16 F716-A155 WH-16 998-AE1 BR-16 F715-AE2 PU-16 F716-AE3 WH-16 C453-CC35 YL-16 K983-CC38 BU-16 201-CC12 BK-16 200-CC9 BK-14 611-CC20 PU-14 619-CC23 GN-14 BK-16 YL-16 YL-14 BK-14 BK-14 BK-14 GN-16 YL-16 WH-16 BU-16 611-CC18 200-CC11 619-CC21 201-CC12 C453-CC35 K983-CC38 PU-14 BK-14 GN-14 BK-16 YL-16 BU-16 1 2 200-BB29 BK-14 200-BB28 BK-14 614-BB30 PU-16 539-BB22 BU-16 632-BB12 WH-14 631-BB11 GY-14 611-BB10 PU-14 619-BB9 GN-14 200-BB7 BK-14 200-BB6 BK-14 622-BB5 PU-14 623-BB4 BU-16 149-BB3 PU-14 607-BB2 PK-14 620-BB24 WH-14 620-BB25 WH-14 539-D4 PU-16 200-D7 BK-16 614-D1 BU-16 540-BB13 WH-16 200-BB50 BK-16 614-BB26 PU-16 M CONN 45 3 4 5 6 9G-3677 V-C1 W K983-CC38 BU-16 201-CC12 BK-16 C453-CC35 YL-16 611-CC20 PU-14 619-CC23 GN-14 200-CC9 BK-14 200-BB27 BK-14 620-BB23 WH-14 MM W W M M W W M W M M M M M W 611-V5 PU-14 200-V1 BK-14 619-V6 GN-14 201-V4 BK-14 C453-V7 YL-16 K983-V8 BU-16 540-G1 WH-16 200-G7 BK-16 614-G4 PU-16 9G-3676 U-C1 1 K983-W1 BU-16 201-W2 BK-16 C453-W3 YL-16 7N-7782 W-C1 8T-8731 W-C2 611-U1 PU-16 619-U5 GN-16 200-U2 BK-16 A B C 1 K983-V8 BU-16 2 201-V4 BK-14 3 C453-V7 YL-16 7N-7781 V-C2 LH ENGINE WORK LAMP 9X-4381 BB-P1 E709-CC39 WH-16 A251-CC34 BK-16 539-D6 PU-16 200-D8 BK-16 614-D2 BU-16 539-D5 PU-16 200-D9 BK-16 614-D3 BU-16 540-G3 WH-16 200-G9 BK-16 614-G5 PU-16 540-G2 WH-16 200-G8 BK-16 614-G6 PU-16 L# RD WH OR YL PK BK GY PU BR GN BU OR-18 BK-18 WH-18 ABBREV SYMBOL 308-CC14 E972-CC40 F419-CC37 F418-CC36 308-CC13 611-V5 PU-14 200-V2 BK-14 200-V3 BK-14 619-V6 GN-14 W M 631-CC28 GY-14 200-CC6 BK-14 200-CC5 BK-14 631-CC29 GY-14 998-AE1 BR-16 632-CC32 WH-14 200-CC8 BK-14 620-FF1 WH-14 200-FF5 BK-16 200-CC7 BK-14 632-CC31 WH-14 611-U1 PU-16 200-U4 BK-16 200-U3 BK-16 619-U5 GN-16 +V ANALOG DIGITAL RET SIGNAL RED WHITE ORANGE YELLOW PINK BLACK GRAY PURPLE BROWN GREEN BLUE ATCH WIRE, CABLE, COMPONENT CIRCUIT GROUPING DESIGNATION CIRCUIT CONNECTED BLADE, SPADE, RING, OR SCREW TERMINAL DESCRIPTION M M M CIRCUIT NOT CONNECTED ELECTRICAL CONNECTION TO MACHINE STRUCTURE INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT CONNECTOR F715-AE2 PU-16 F716-AE3 WH-16 CONN 44 YL-16 BU-16 M YL-16 GN-16 YL-16 M M M ENGINE FLOOD LAMP SWITCH 8D-2676 CC-P1 COLOR M W 2 3 W M 623-CC26 BU-14 622-CC25 PU-14 W M W M M M M M M M LH HIGH BEAM HEADLAMP 9X-7170 V-P1 LH LOW BEAM HEADLAMP 9X-7169 V-P2 AMBIENT AIR TEMP SENSOR 118-3909 W-P1 RH LOW BEAM HEADLAMP 9X-7169 U-P2 RH HIGH BEAM HEADLAMP 9X-7170 U-P1 M M M M M W M M M M F G C D H A B E